Multilayer polyelectrolyte films as nanofiltration membranes for separating monovalent and divalent cations

Abstract Alternating adsorption of polyanions and polycations on porous supports provides a convenient way to prepare ion-selective nanofiltration membranes. This work examines optimization of ultrathin, multilayer polyelectrolyte films for monovalent/divalent cation separations relevant to water softening. Membranes composed of five bilayers of poly(styrene sulfonate)/poly(allylamine hydrochloride) (PSS/PAH) on porous alumina supports allow a solution flux of 0.85 m 3 /(m 2  day) at 4.8 bar, and exhibit 95% rejection of MgCl 2 along with a Na + /Mg 2+ selectivity of 22. Similar results were obtained in Na + /Ca 2+ separations. PSS/poly(diallyl-dimethylammonium chloride) (PDADMAC) films permit higher fluxes than PSS/PAH systems due to the higher swelling of films containing PDADMAC, but the Mg 2+ rejection by PSS/PDADMAC membranes is less than 45%. However, capping PSS/PDADMAC films with a bilayer of PSS/PAH yields Mg 2+ rejections and Na + /Mg 2+ selectivities that are typical of pure PSS/PAH membranes. Separation performance can be optimized through control over deposition conditions (pH and supporting electrolyte concentration) and the charge of the outer layer since Donnan exclusion is a major factor in monovalent/divalent cation selectivity. Streaming potential measurements demonstrate that the magnitude of positive surface charge increases with increasing concentrations of Mg 2+ in solution or when the outer polycation layer is deposited from a solution of high ionic strength.

[1]  Seong Uk Hong,et al.  Separation of fluoride from other monovalent anions using multilayer polyelectrolyte nanofiltration membranes. , 2007, Langmuir : the ACS journal of surfaces and colloids.

[2]  Christopher J. Barrett,et al.  Fabrication of Microporous Thin Films from Polyelectrolyte Multilayers , 2000 .

[3]  H. Tan,et al.  A novel nanofiltration membrane prepared with PAMAM and TMC by in situ interfacial polymerization on PEK-C ultrafiltration membrane , 2006 .

[4]  Merlin L. Bruening,et al.  Ultrathin, Multilayered Polyelectrolyte Films as Nanofiltration Membranes , 2003 .

[5]  J. Schlenoff,et al.  Polyelectrolyte Multilayers Containing a Weak Polyacid: Construction and Deconstruction , 2001 .

[6]  F. Rehfeldt,et al.  Swelling Behavior of Polyelectrolyte Multilayers in Saturated Water Vapor , 2004 .

[7]  M. Zembala,et al.  Characterization of polyelectrolyte multilayers by the streaming potential method. , 2004, Langmuir : the ACS journal of surfaces and colloids.

[8]  Johannes Schmitt,et al.  Detailed Structure of Molecularly Thin Polyelectrolyte Multilayer Films on Solid Substrates as Revealed by Neutron Reflectometry , 1998 .

[9]  B. Tieke,et al.  Selective Ion Transport across Self-Assembled Alternating Multilayers of Cationic and Anionic Polyelectrolytes , 2000 .

[10]  Daxin Wang,et al.  Modeling the separation performance of nanofiltration membranes for the mixed salts solution with Mg2+ and Ca2+ , 2006 .

[11]  N. Chau,et al.  Influence of surface charge and solution pH on the performance characteristics of a nanofiltration membrane , 2005 .

[12]  S. Schwarz,et al.  Polyelectrolyte adsorption onto planar surfaces: a study by streaming potential and ellipsometry measurements☆ , 1999 .

[13]  Michael F. Rubner,et al.  Influence of the Degree of Ionization on Weak Polyelectrolyte Multilayer Assembly , 2005 .

[14]  G. Das.  You and Your Drinking Water: Health Implications for the Use of Cation Exchange Water Softeners , 1988, Journal of clinical pharmacology.

[15]  C. Helm,et al.  Molecular Mechanisms Controlling the Self-Assembly Process of Polyelectrolyte Multilayers , 1998 .

[16]  M. Bruening,et al.  Size-Selective Transport of Uncharged Solutes through Multilayer Polyelectrolyte Membranes , 2004 .

[17]  Masaaki Ando,et al.  Separation performance of a nanofiltration membrane influenced by species and concentration of ions , 2005 .

[18]  M. Bruening,et al.  High-flux nanofiltration membranes prepared by adsorption of multilayer polyelectrolyte membranes on polymeric supports. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[19]  Jeremy J. Harris,et al.  Layered Polyelectrolyte Films as Selective, Ultrathin Barriers for Anion Transport , 2000 .

[20]  Gero Decher,et al.  Fuzzy Nanoassemblies: Toward Layered Polymeric Multicomposites , 1997 .

[21]  J. Petrus,et al.  Ultrafiltration/complexation process for metal removal from pulp and paper industry wastewater , 2002 .

[22]  Runhong Du,et al.  Properties of poly (N,N-dimethylaminoethyl methacrylate)/polysulfone positively charged composite nanofiltration membrane , 2004 .

[23]  S. Bhattacharjee,et al.  A Novel Asymmetric Clamping Cell for Measuring Streaming Potential of Flat Surfaces , 2002 .

[24]  David Hasson,et al.  Utilization of the Donnan effect for improving electrolyte separation with nanofiltration membranes , 1996 .

[25]  J. Schlenoff,et al.  Doping-controlled ion diffusion in polyelectrolyte multilayers: mass transport in reluctant exchangers. , 2003, Journal of the American Chemical Society.

[26]  P. Schaaf,et al.  In Situ Determination of the Structural Properties of Initially Deposited Polyelectrolyte Multilayers , 2000 .

[27]  Peter Eriksson,et al.  NF membrane characteristics and evaluation for sea water processing applications , 2005 .

[28]  T. J. McCarthy,et al.  Stepwise Polymer Surface Modification: ChemistryLayer-by-Layer Deposition , 1998 .

[29]  Johannes Schmitt,et al.  Buildup of ultrathin multilayer films by a self-assembly process: III. Consecutively alternating adsorption of anionic and cationic polyelectrolytes on charged surfaces , 1992 .

[30]  M. Schönhoff,et al.  Oscillations in solvent fraction of polyelectrolyte multilayers driven by the charge of the terminating layer. , 2004, Langmuir : the ACS journal of surfaces and colloids.

[31]  W. Jin,et al.  Selective transport of ions and molecules across layer-by-layer assembled membranes of polyelectrolytes, p-sulfonato-calix[n]arenes and Prussian Blue-type complex salts. , 2005, Advances in colloid and interface science.

[32]  Merlin L. Bruening,et al.  Electrochemical and in Situ Ellipsometric Investigation of the Permeability and Stability of Layered Polyelectrolyte Films , 2000 .

[33]  H. Matsumura,et al.  Binding behavior of metal cations and hydrophobic ions from a mixed solution. , 1987 .

[34]  W. Jin,et al.  Self-Assembled Films of Prussian Blue and Analogues: Structure and Morphology, Elemental Composition, Film Growth, and Nanosieving of Ions , 2003 .

[35]  Michael F. Rubner,et al.  pH-Dependent Thickness Behavior of Sequentially Adsorbed Layers of Weak Polyelectrolytes , 2000 .

[36]  R. J. Petersen,et al.  Composite reverse osmosis and nanofiltration membranes , 1993 .

[37]  L. Krasemann.  Self-assembled polyelectrolyte multilayer membranes with highly improved pervaporation separation of ethanol/water mixtures , 2001 .

[38]  Daxin Wang,et al.  Modeling the separation performance of nanofiltration membranes for the mixed salts solution , 2006 .

[39]  Zhiqiang Wang,et al.  To Construct “Ion Traps” for Enhancing the Permselectivity and Permeability of Polyelectrolyte Multilayer Films , 2007 .

[40]  Cong-jie Gao,et al.  A novel composite nanofiltration (NF) membrane prepared from graft copolymer of trimethylallyl ammonium chloride onto chitosan (GCTACC)/poly(acrylonitrile) (PAN) by epichlorohydrin cross-linking. , 2006, Carbohydrate research.

[41]  S. Taha,et al.  Softening of Hamma drinking water by nanofiltration and by lime in the presence of heavy metals , 2005 .

[42]  Guojun Zhang,et al.  Self-assembly of polyelectrolyte multilayer pervaporation membranes by a dynamic layer-by-layer technique on a hydrolyzed polyacrylonitrile ultrafiltration membrane , 2007 .

[43]  J. P. Boom,et al.  Retention measurements of nanofiltration membranes with electrolyte solutions , 1998 .

[44]  Michael F. Rubner,et al.  Controlling Bilayer Composition and Surface Wettability of Sequentially Adsorbed Multilayers of Weak Polyelectrolytes , 1998 .

[45]  S. Nakao,et al.  The electrostatic and steric-hindrance model for the transport of charged solutes through nanofiltration membranes , 1997 .

[46]  Menachem Elimelech,et al.  Effect of solution chemistry on the surface charge of polymeric reverse osmosis and nanofiltration membranes , 1996 .

[47]  H. Möhwald,et al.  Influence of the Ionic Strength on the Polyelectrolyte Multilayers' Permeability , 2003 .

[48]  Wanqin Jin,et al.  Use of Polyelectrolyte Layer-by-Layer Assemblies as Nanofiltration and Reverse Osmosis Membranes , 2003 .

[49]  R. Steitz,et al.  Influence of the ionic strength on the structure of polyelectrolyte films at the solid/liquid interface , 2000 .

[50]  M. Schönhoff.  Layered polyelectrolyte complexes: physics of formation and molecular properties , 2003 .

[51]  J. Gilron.  Experimental analysis of negative salt rejection in nanofiltration membranes , 2001 .

[52]  Merlin L. Bruening,et al.  Correlation of the Swelling and Permeability of Polyelectrolyte Multilayer Films , 2005 .

[53]  M. Schönhoff,et al.  Surface Potential Driven Swelling of Polyelectrolyte Multilayers , 2002 .