Experimental investigations and an updated correlation of flow boiling heat transfer coefficients for ammonia/lithium nitrate mixture in horizontal tubes

Abstract In this work, experiments have been performed to investigate the flow boiling heat transfer coefficients (HTC) of ammonia/lithium nitrate mixture in horizontal smooth tubes with different internal diameters (4 mm, 6 mm). According to the practical working conditions of absorption refrigeration system, the ammonia concentration for the tested ammonia/lithium nitrate mixture was selected as 45.0 wt%, and the boiling temperature of tests were in the range of 78–90 °C. The effects of boiling temperature, heat flux, mass flux and tube size on the flow boiling HTCs were investigated in this article. Results show that higher heat and mass fluxes as well as heat transfer tube with larger diameter tend to exert positive influence on flow boiling HTCs of the present study cases. Based on more than 600 groups of experimental data, a new correlation was proposed to predict the effects of mass flux, heat flux, and tube size on flow boiling HTCs for NH 3 /LiNO 3 mixture under investigated conditions, with a mean deviation less than ±10%. The new correlation will be of great significance to the design and optimization of generators in the practical absorption refrigeration units using ammonia/lithium nitrate mixture.

[1]  Boiling heat transfer and pressure drop of NH3/LiNO3 and NH3/(LiNO3 + H2O) in a plate heat exchanger , 2016 .

[2]  O. Kaynakli.  The first and second law analysis of a lithium bromide/water coil absorber , 2008 .

[3]  K. Stephan,et al.  Heat-transfer correlations for natural convection boiling , 1980 .

[4]  Joaquín Navarro-Esbrí,et al.  Evaluation of R448A and R450A as low-GWP alternatives for R404A and R134a using a micro-fin tube evaporator model , 2016 .

[5]  S. Klein,et al.  Measured and predicted heat transfer coefficients for boiling zeotropic mixed refrigerants in horizontal tubes , 2016 .

[6]  Qiqi Tian,et al.  Exergy analysis of a novel air-cooled non-adiabatic absorption refrigeration cycle with NH3–NaSCN and NH3–LiNO3 refrigerant solutions , 2014 .

[7]  C. A. Infante Ferreira,et al.  Thermodynamic and physical property data equations for ammonia-lithium nitrate and ammonia-sodium thiocyanate solutions , 1984 .

[8]  J. Navarro-Esbrí,et al.  Shell-and-tube evaporator model performance with different two-phase flow heat transfer correlations. Experimental analysis using R134a and R1234yf , 2014 .

[9]  Saeed Moghaddam,et al.  Impact of micromixing on performance of a membrane-based absorber , 2015 .

[10]  J. Cieśliński,et al.  Evaporation of R407C/oil mixtures inside corrugated and micro-fin tubes , 2007 .

[11]  H. K. Varma,et al.  Heat transfer coefficients in forced convection evaporation of refrigerants mixtures , 1981 .

[12]  M. Venegas,et al.  Boiling heat transfer and pressure drop of ammonia-lithium nitrate solution in a plate generator , 2010 .

[13]  Masayasu Hatazawa,et al.  Performance of a Thermoacoustic Sound Wave Generator driven with Waste Heat of Automobile Gasoline Engine. , 2004 .

[14]  Niu Lijuan,et al.  Experimental evaluation on thermal performance of an air-cooled absorption refrigeration cycle with NH3–LiNO3 and NH3–NaSCN refrigerant solutions , 2016 .

[15]  Roberto Best,et al.  Comparison of the experimental evaluation of a solar intermittent refrigeration system for ice production operating with the mixtures NH3/LiNO3 and NH3/LiNO3/H2O , 2012 .

[16]  Roberto Best,et al.  Boiling heat transfer coefficients inside a vertical smooth tube for water/ammonia and ammonia lithium nitrate mixtures , 1999 .

[17]  A. Sathyabhama,et al.  Experimental Investigation of Pool Boiling Heat Transfer in Ammonia–Water–Lithium Nitrate Solution , 2012 .

[18]  Alberto Coronas,et al.  Densities, Viscosities, and Heat Capacities of Ammonia + Lithium Nitrate and Ammonia + Lithium Nitrate + Water Solutions between (293.15 and 353.15) K , 2008 .

[19]  Lin Fu,et al.  A review of working fluids of absorption cycles , 2012 .

[20]  Robert J. Moffat,et al.  Describing the Uncertainties in Experimental Results , 1988 .

[21]  Sérgio de Morais Hanriot,et al.  Using engine exhaust gas as energy source for an absorption refrigeration system , 2010 .

[22]  K. Gungor,et al.  Simplified general correlation for saturated flow boiling and comparisons of correlations with data , 1987 .

[23]  E. Hihara,et al.  Correlation for boiling heat transfer of R-134a in horizontal tubes including effect of tube diameter , 2007 .

[24]  S. Kandlikar.  A General Correlation for Saturated Two-Phase Flow Boiling Heat Transfer Inside Horizontal and Vertical Tubes , 1990 .

[25]  Mahmoud Bourouis,et al.  Analysis of ammonia/water and ammonia/salt mixture absorption cycles for refrigeration purposes in fishing ships , 2014 .

[26]  E. N. Sieder,et al.  Heat Transfer and Pressure Drop of Liquids in Tubes , 1936 .

[27]  A. F. Oliveira,et al.  Automotive exhaust gas flow control for an ammonia–water absorption refrigeration system , 2014 .

[28]  Dehua Cai,et al.  Flow boiling heat transfer characteristics and pressure drop of ammonia-lithium nitrate solution in a smooth horizontal tube , 2017 .

[29]  A. Greco,et al.  Convective boiling of pure and mixed refrigerants: An experimental study of the major parameters affecting heat transfer , 2008 .

[30]  Minxia Li,et al.  Flow boiling heat transfer of HFO1234yf and HFC32 refrigerant mixtures in a smooth horizontal tube: Part II. Prediction method , 2013 .

[31]  Alberto Coronas,et al.  Pre-industrial development and experimental characterization of new air-cooled and water-cooled ammonia/lithium nitrate absorption chillers , 2014 .

[32]  C. Vereda,et al.  Subcooled and saturated boiling of ammonia–lithium nitrate solution in a plate-type generator for absorption machines , 2012 .

[33]  S. Moghaddam,et al.  Absorption characteristics of falling film LiBr (lithium bromide) solution over a finned structure , 2015 .

[34]  G. He,et al.  Experimental investigation on flow boiling heat transfer performance of a new near azeotropic refrigerant mixture R290/R32 in horizontal tubes , 2016 .

[35]  Qiqi Tian,et al.  Thermodynamic analysis of a novel air-cooled non-adiabatic absorption refrigeration cycle driven by low grade energy , 2014 .

[36]  J. C. Chen.  Correlation for Boiling Heat Transfer to Saturated Fluids in Convective Flow , 1966 .

[37]  Qiqi Tian,et al.  First law analysis of a novel double effect air-cooled non-adiabatic ammonia/salt absorption refrigeration cycle , 2015 .