Ultra-clean hydrogen production by ammonia decomposition

Abstract A rigorous heterogeneous mathematical model is used to simulate a cascade of multi-stage fixed bed membrane reactors (MSFBMR) with inter-stage heating and fresh sweep gas for the decomposition of ammonia to produce high purity hydrogen suitable for the PEM fuel cells. Different reactor configurations are compared. The comparison between a single fixed bed reactor (FBR) and a single fixed bed membrane reactor (FBMR) shows that the FBMR is superior to the FBR and gives 60.48% ammonia conversion higher than the FBR. However, 20.91% exit ammonia conversion obtained by the FBMR is considered to be poor. The FBMR is limited by the kinetics at low temperatures. The numerical results show that the MSFBMR of four beds achieve 100.0% ammonia conversion. It was found that the membrane plays the prime role in the displacement of the thermodynamic equilibrium. The results also show that, a linear relationship exists between the number of beds and the feed temperature and a correlation has been developed. A critical point for an effective hydrogen permeation zone has been identified. It is observed that the diffusion limitation is confined to a slim region at the entrance of the reactor. It is also observed that the heat load assumes a maximum inflection point and explanations offered. The results show that the multi-stage configuration has a promising potential to be applied successfully on-site for ultra-clean hydrogen production.

[1]  D. Dyson,et al.  Kinetic expression with diffusion correction for ammonia synthesis on industrial catalyst , 1968 .

[2]  R. Hughes,et al.  The catalytic dehydrogenation of isobutane to isobutene in a palladium/silver composite membrane reactor , 2005 .

[3]  H. Neomagus,et al.  Reactor technology options for distributed hydrogen generation via ammonia decomposition: A review , 2013 .

[4]  Z. Prete,et al.  Ammonia decomposition over commercial Ru/Al2O3 catalyst: An experimental evaluation at different operative pressures and temperatures , 2014 .

[5]  O. Hansen,et al.  Promoted Ru on high-surface area graphite for efficient miniaturized production of hydrogen from ammonia , 2006 .

[6]  J. Villadsen,et al.  Solution of differential equation models by polynomial approximation , 1978 .

[7]  M.E.E. Abashar,et al.  Integrated catalytic membrane reactors for decomposition of ammonia , 2002 .

[8]  S. Yin,et al.  A mini-review on ammonia decomposition catalysts for on-site generation of hydrogen for fuel cell applications , 2004 .

[9]  Said S.E.H. Elnashaie,et al.  Simulation and optimization of an industrial ammonia reactor , 1988 .

[10]  R. Hughes,et al.  Elimination of Ammonia from Coal Gasification Streams by Using a Catalytic Membrane Reactor , 1995 .

[11]  Volkmar M. Schmidt,et al.  Performance Data of a Proton Exchange Membrane Fuel Cell Using H 2 / CO as Fuel Gas , 1996 .

[12]  John P. Collins,et al.  A mathematical model of a catalytic membrane reactor for the decomposition of NH3 , 1993 .

[13]  Bernard P. A. Grandjean,et al.  Methane steam reforming in asymmetric Pd- and Pd-Ag/porous SS membrane reactors , 1994 .

[14]  R. Buxbaum,et al.  Power output and load following in a fuel cell fueled by membrane reactor hydrogen , 2003 .

[15]  Ibrahim S. Al-Mutaz,et al.  Investigation of low temperature decomposition of ammonia using spatially patterned catalytic membrane reactors , 2002 .

[16]  R. Metkemeijer,et al.  Comparison of ammonia and methanol applied indirectly in a hydrogen fuel cell , 1994 .

[17]  R. Hughes.  Composite palladium membranes for catalytic membrane reactors , 2001 .

[18]  Saurabh A. Vilekar,et al.  The peculiar catalytic sequence of the ammonia decomposition reaction and its steady-state kinetics , 2012 .

[19]  Yi Hua Ma,et al.  High purity hydrogen production by low temperature catalytic ammonia decomposition in a multifunctional membrane reactor , 2008 .

[20]  Zaccaria Del Prete,et al.  3D simulation of hydrogen production by ammonia decomposition in a catalytic membrane reactor , 2011 .

[21]  G. Botte,et al.  Hydrogen Production from the Electro-oxidation of Ammonia Catalyzed by Platinum and Rhodium on Raney Nickel Substrate , 2006 .

[22]  Jacob N. Chung,et al.  Numerical modeling of hydrogen production from ammonia decomposition for fuel cell applications , 2010 .

[23]  V. Nassehi,et al.  Computer modelling and numerical analysis of hydrodynamics and heat transfer in non-porous catalytic reactor for the decomposition of ammonia , 2005 .

[24]  Mohammad Reza Rahimpour,et al.  Production of hydrogen from purge gases of ammonia plants in a catalytic hydrogen-permselective membrane reactor , 2009 .

[25]  Chandra P. P. Singh,et al.  Simulation of Ammonia Synthesis Reactors , 1979 .

[26]  Shimshon Gottesfeld,et al.  Effect of Ammonia as Potential Fuel Impurity on Proton Exchange Membrane Fuel Cell Performance , 2002 .

[27]  William J. Thomson,et al.  Ammonia decomposition kinetics over Ni-Pt/Al2O3 for PEM fuel cell applications , 2002 .

[28]  Roman Chvalek,et al.  Hydrogen storage methods in the fuel cells laboratory , 2011, 2011 10th International Conference on Environment and Electrical Engineering.

[29]  Xianguo Li,et al.  Effective transport properties for polymer electrolyte membrane fuel cells – With a focus on the gas diffusion layer , 2013 .

[30]  Roland Dittmeyer,et al.  Membrane reactors for hydrogenation and dehydrogenation processes based on supported palladium , 2001 .

[31]  Srinivas Palanki,et al.  Analysis of ammonia decomposition reactor to generate hydrogen for fuel cell applications , 2010 .

[32]  M. Ternan,et al.  Experimental and modelling studies of CO poisoning in PEM fuel cells , 2007 .

[33]  Volkmar M. Schmidt,et al.  Performance Data of a Proton Exchange Membrane Fuel Cell Using H2/CO as Fuel Gas. , 2010 .

[34]  M. Abashar.  Parametric sensitivity analysis to investigate heptane reforming in circulating fast fluidized bed membrane reactors , 2015 .

[35]  J. Nørskov,et al.  Ammonia synthesis and decomposition on a Ru-based catalyst modeled by first-principles , 2009 .

[36]  Z. Prete,et al.  Characterization of an ammonia decomposition process by means of a multifunctional catalytic membrane reactor , 2014 .