Microstructure and environmental functionalities of TiO2-supported photocatalysts obtained by suspension plasma spraying

Abstract This paper deals with the elaboration of titanium dioxide coatings, designed for photocatalytic applications, obtained by a non-conventional method of deposition, suspension plasma spraying (SPS), an alternative of the atmospheric plasma spraying (APS) in which the material feedstock is a suspension of the material powder to be sprayed. TiO 2 P25 powder (Degussa AG) mechanically dispersed in distilled water and/or ethanol was injected in argon–hydrogen and argon–hydrogen–helium plasma under atmospheric conditions. Scanning electron microscopy and X-ray diffraction were performed to study the morphology and the crystalline phases of the titania coatings. Surface features were investigated by Fourier transform infrared (FT-IR) and X-ray photoelectron spectroscopy (XPS). Photocatalytic efficiency of the elaborated samples was tested in an environmental test chamber set-up and evaluated from the conversion rate of nitrogen oxides. The results showed that the coating obtained from the injection of an alcoholic suspension contained 23% of anatase ratio and ensured a very low photocatalytic decomposition of nitrogen oxides. In contrast, the injection of an aqueous suspension into the plasma permitted to obtain deposits where the anatase phase and the crystallites size were preserved. Also, a conversion rate of the pollutants of about 40%, slightly better compared to that of the initial P25 powder (around 32%) was noticed. This slightly higher efficiency was correlated with a cleaning of the particles surfaces when crossing the plasma and a higher hydroxylation of the coating surface.

[1]  M. S. Hegde,et al.  Synthesis and structure of nanocrystalline TiO2 with lower band gap showing high photocatalytic activity. , 2004, Langmuir : the ACS journal of surfaces and colloids.

[2]  M. Vardelle,et al.  Deposition of nanoparticle suspensions by aerosol flame spraying: Model of the spray and impact processes , 2003 .

[3]  S. Kuroda,et al.  Plasma Spraying of Submicron Ceramic Suspensions Using a Continuous Ink Jet Printer , 1999 .

[4]  M. Mendelson.  Theoretical evaluation of wear in plasma-sprayed TiO2 against grey cast iron☆ , 1978 .

[5]  Changhee Lee,et al.  Photocatalytic properties of nano-structured TiO2 plasma sprayed coating , 2003 .

[6]  J. Herrmann,et al.  Heterogeneous photocatalysis: fundamentals and applications to the removal of various types of aqueous pollutants , 1999 .

[7]  Baki M. Cetegen,et al.  Towards durable thermal barrier coatings with novel microstructures deposited by solution-precursor plasma spray , 2001 .

[8]  N. Jaffrezic‐Renault,et al.  Physicochemical properties and photocatalytic activities of TiO2-films prepared by sol–gel methods , 2002 .

[9]  Chang-jiu Li,et al.  Microstructure and photocatalytic performance of high velocity oxy-fuel sprayed TiO2 coatings , 2004 .

[10]  E. Jordan,et al.  Identification of coating deposition mechanisms in the solution-precursor plasma-spray process using model spray experiments , 2003 .

[11]  L. Palmisano,et al.  The role of H2O in the photocatalytic oxidation of toluene in vapour phase on anatase TiO2 catalyst: A FTIR study , 1999 .

[12]  Zili Xu,et al.  The preparation and characterization of TiO2 ultrafine particles , 1999 .

[13]  Herve Toulhoat,et al.  Effects of morphology on surface hydroxyl concentration: a DFT comparison of anatase–TiO2 and γ-alumina catalytic supports , 2004 .

[14]  Robert B. Heimann.  Plasma-Spray Coating , 1996 .

[15]  A. Ohmori,et al.  The photocatalytic activity and photo-absorption of plasma sprayed TiO2–Fe3O4 binary oxide coatings , 2002 .

[16]  Robert B. Heimann,et al.  Plasma-Spray Coating: Principles and Applications , 1996 .

[17]  Qiang Zhang,et al.  Effects of calcination on the photocatalytic properties of nanosized TiO2 powders prepared by TiCl4 hydrolysis , 2000 .

[18]  M. Primet,et al.  Infrared study of the surface of titanium dioxides. II. Acidic and basic properties , 1971 .

[19]  F. Fabreguette,et al.  Amorphous TiO2 in LP-OMCVD TiNxOy thin films revealed by XPS , 2001 .

[20]  K. Khor,et al.  Titanium dioxide reinforced hydroxyapatite coatings deposited by high velocity oxy-fuel (HVOF) spray. , 2002, Biomaterials.

[21]  P. M. Kumar,et al.  Nanocrystalline TiO2 studied by optical, FTIR and X-ray photoelectron spectroscopy: correlation to presence of surface states , 2000 .

[22]  B. K. Hodnett.  Photocatalytic purification and treatment of water and air : by D.F. Ollis and H. Al-Ekabi (Editors), Elsevier Science Publishers BV, Amsterdam, 1993, ISBN 0-444-89855-7, xiv + 820 pp., f450.00/$257.25 , 1994 .

[23]  K. Yeung,et al.  Gas-phase photo-oxidation of toluene using nanometer-size TiO2 catalysts , 2001 .

[24]  E. Altman,et al.  Structure and chemical reactivity of adsorbed carboxylic acids on anatase TiO2(0 0 1) , 2002 .

[25]  G. Martra.  Lewis acid and base sites at the surface of microcrystalline TiO2 anatase: relationships between surface morphology and chemical behaviour , 2000 .

[26]  T. Chartier,et al.  Understanding of suspension DC plasma spraying of finely structured coatings for SOFC , 2005, IEEE Transactions on Plasma Science.

[27]  J. Baran,et al.  IR-analysis of H-bonded H2O on the pure TiO2 surface , 2004 .

[28]  M. A. Hasan,et al.  In situ FTIR spectra of pyridine adsorbed on SiO2-Al2O3, TiO2, ZrO2 and CeO2: general considerations for the identification of acid sites on surfaces of finely divided metal oxides , 2001 .

[29]  J. White,et al.  Characterization of species adsorbed on oxidized and reduced anatase , 1982 .

[30]  Kuyen Li,et al.  TiO2 photocatalytic oxidation of nitric oxide: transient behavior and reaction kinetics , 2003 .

[31]  Pierre Fauchais,et al.  Quo vadis thermal spraying? , 2001, International Thermal Spray Conference.

[32]  Paul A. Connor,et al.  Infrared Spectroscopy of the TiO2/Aqueous Solution Interface , 1999 .

[33]  S. Guessasma,et al.  Neural computation to predict TiO2 photocatalytic efficiency for nitrogen oxides removal , 2004 .

[34]  G. C. Allen,et al.  Photocatalytic oxidation of NOx gases using TiO2: a surface spectroscopic approach. , 2002, Environmental pollution.

[35]  Hiroyuki Hatano,et al.  Ultrafine particle fluidization and its application to photocatalytic NOx treatment , 2001 .

[36]  C. Coddet,et al.  Microstructure of plasma-sprayed titania coatings deposited from spray-dried powder , 2003 .

[37]  Jinlong Li,et al.  Wear mechanism of plasma-sprayed TiO2 coating against stainless steel , 1996 .