Total Focusing Method With Virtual Sources in the Presence of Unknown Geometry Interfaces

Auto-focused virtual source imaging (AVSI) has been recently presented as an alternative method for synthetic aperture focusing through arbitrarily shaped interfaces with arrays. This paper extends the AVSI concept to the case of the total focusing method (TFM-AVSI) using several virtual receivers for each virtual source. This approach overcomes the known contrast limitation of AVSI, while preserving the advantage of performing synthetic focusing in the second medium only [no time-of-flight (TOF) calculations through the interface]. In contrast, equipment with more active channels must be used to digitalize the signals received by all the array elements after each focused emission. When compared with the conventional TFM, the proposed method reduces the processing complexity of the most time consuming task: TOF calculation in the presence of interfaces. This improvement could lead to more efficient real-time implementations of the TFM in non-destructive testing applications where water immersion or flexible wedges are used. In this paper, the mathematical formulation for the new method is given, accounting for the surface slope and the array angular sensitivity. Its performance is evaluated by numerical simulation, experimentally and compared with AVSI and the conventional TFM. It was found that the TFM-AVSI achieves the same resolution and contrast as that of the TFM, although it shows a wider blind zone below the interface due to focusing with normal incidence.

[1]  Alexander Sutor,et al.  Ultrasonic defect detection in multi-material, axis-symmetric devices with an improved synthetic aperture focusing technique (SAFT) , 2012, 2012 IEEE International Ultrasonics Symposium.

[2]  J. F. Cruza,et al.  Ultrafast hardware-based focal law calculator for automatic focusing , 2015 .

[3]  Miles Weston,et al.  Full matrix capture with time-efficient auto-focusing of unknown geometry through dual-layered media , 2013 .

[4]  R. Y. Chiao,et al.  Sparse array imaging with spatially-encoded transmits , 1997, 1997 IEEE Ultrasonics Symposium Proceedings. An International Symposium (Cat. No.97CH36118).

[5]  Peter Grant,et al.  A Digital Synthetic Focus Acoustic Imaging System for NDE , 1978 .

[6]  Jorge Camacho,et al.  Auto-focused virtual source imaging with arbitrarily shaped interfaces , 2015, IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control.

[7]  Miles Weston,et al.  Advanced ultrasonic digital imaging and signal processing for applications in the field of non-destructive testing , 2012 .

[8]  J. F. Cruza,et al.  High resolution Autofocused Virtual Source Imaging (AVSI) , 2015, 2015 IEEE International Ultrasonics Symposium (IUS).

[9]  Peter Cawley,et al.  ULTRASONIC PHASED ARRAY INSPECTION OF FLAWS ON WELD FUSION FACES USING FULL MATRIX CAPTURE , 2009 .

[10]  J. F. Cruza,et al.  Automatic dynamic depth focusing for NDT , 2014 .

[11]  H. Ermert,et al.  A 100-MHz ultrasound imaging system for dermatologic and ophthalmologic diagnostics , 1996, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[12]  Vera Behar,et al.  ANALYSIS AND OPTIMIZATION OF SYNTHETIC APERTURE ULTRASOUND IMAGING USING THE EFFECTIVE APERTURE APPROACH , 2006 .

[13]  Miles Weston,et al.  Time efficient auto-focussing algorithms for ultrasonic inspection of dual-layered media using Full Matrix Capture , 2012 .

[14]  T. Stepinski.  SAFT Performance in Ultrasonic Inspection of Coarse Grained Metals , 2008 .

[15]  Miles Weston,et al.  Real-time full matrix capture with auto-focussing of known geometry through dual layered media , 2012 .

[16]  W.D. O'Brien,et al.  Synthetic aperture techniques with a virtual source element , 1998, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[17]  P. Wilcox,et al.  Post-processing of the full matrix of ultrasonic transmit-receive array data for non-destructive evaluation , 2005 .

[18]  Jørgen Arendt Jensen,et al.  Synthetic aperture ultrasound imaging. , 2006, Ultrasonics.

[19]  C. Fritsch,et al.  Dynamic focusing through arbitrary geometry interfaces , 2008, 2008 IEEE Ultrasonics Symposium.

[20]  Bruce W. Drinkwater,et al.  Ultrasonic array inspection of the Clifton Suspension Bridge chain-links , 2009 .

[21]  Carlos Fritsch,et al.  Real time autofocusing hardware for ultrasonic imaging with interfaces , 2015, 2015 IEEE International Ultrasonics Symposium (IUS).