Synergism between Cu and Zn sites in Cu/Zn catalysts for methanol synthesis

Abstract Three Cu-based catalysts prepared using RF plasma-sputtering (Cu/ZnO and Cu/Al2O3) and coprecipitation (Cu/Zn/Al oxide) methods were employed for the investigation of the synergism between Cu and Zn sites. The static secondary ion mass spectrometry (SIMS) experiments indicate that, on both Cu/ZnO/Al2O3 and Cu/ZnO catalysts, CO is adsorbed at Cu sites (SIMS peaks appear at 91 and 93 amu), and H is bound to ZnO sites (67, 69, 70, 71 and 81, 83, 84, 85 amu) when the catalyst surfaces are exposed to H2, CO and CO2. Methoxy, the intermediate species of methanol synthesis, is found to be bound at Zn sites (95, 97, 98, 99 amu). CO and CO2 are found to induce Zn migration from sub-layers to the topmost layer while H2 is heterolyzed easier due to the presence of Cu. The coexistence of ZnO with Cu could enhance the capability of Cu to adsorb CO species and itself to adsorb H2 species. Al2O3 shows no synergetic effect with Cu in this experiment. No CO and H2 are detected on the Cu/Al2O3 catalyst exposed to syngas. The synergetic effect between Cu and Zn in the course of methanol synthesis was discussed.

[1]  G. Millar,et al.  Evidence for the adsorption of molecules at special sites located at copper/zinc oxide interfaces: part 1.—A Fourier-transform infrared study of formic acid and formaldehyde adsorption on reduced and oxidised Cu/ZnO/SiO2 catalysts , 1992 .

[2]  S. Golunski,et al.  The role of copper and zinc oxide in methanol synthesis catalysts , 1990 .

[3]  J. Bart,et al.  Copper-Zinc Oxide-Alumina Methanol Catalysts Revisited , 1987 .

[4]  T. Fujitani,et al.  The role of metal oxides in promoting a copper catalyst for methanol synthesis , 1994 .

[5]  V. Ponec,et al.  On the problem of the activity in methanol synthesis of supported, unpromoted copper catalysts , 1990 .

[6]  Jianyi Lin,et al.  Variable photon energy photoelectron spectroscopic study of carbon monoxide adsorption to coordinatively unsaturated tetrahedral copper(I) and zinc(II) sites of copper chloride(111) and zinc oxide(10.hivin.10) surfaces: d10 contributions to CO bonding and activation , 1991 .

[7]  S. Golunski,et al.  The role of hydrogen in methanol synthesis over copper catalysts , 1990 .

[8]  K. C. Waugh,et al.  Synthesis of Methanol , 1988 .

[9]  J. Lavalley,et al.  An in situ FT-IR study of adsorbed species on a Cu-ZnAl2O4 methanol catalyst under 1 MPa pressure and at 525 K: effect of the H2/CO/CO2 feed stream composition , 1989 .

[10]  G. Millar,et al.  Combined temperature-programmed desorption and fourier-transform infrared spectroscopy study of CO2, CO and H2 interactions with model ZnO/SiO2, Cu/SiO2 and Cu/ZnO/SiO2 methanol synthesis catalysts , 1993 .

[11]  G. Millar,et al.  A combined infrared, temperature programmed desorption and temperature programmed reaction spectroscopy study of CO2 and H2 interactions on reduced and oxidized silica-supported copper catalysts , 1992 .

[12]  S. Golunski,et al.  Synergy at a distance in the synthesis of methanol over copper catalysts , 1988 .

[13]  S. Golunski,et al.  Synergy between copper and zinc oxide during methanol synthesis. Transfer of activating species , 1989 .

[14]  Plummer,et al.  Angle-resolved photoemission study of the orientation and electronic interactions of romanCO+K/Ru(001) in the low-coverage regime. , 1986, Physical Review B (Condensed Matter).

[15]  Janos Szanyi,et al.  Methanol synthesis on a Cu(100) catalyst , 1991 .

[16]  S. Fujita,et al.  Mechanisms of Methanol Synthesis from Carbon Dioxide and from Carbon Monoxide at Atmospheric Pressure over Cu/ZnO , 1995 .

[17]  Shin-ichiro Fujita,et al.  Mechanism of the reverse water gas shift reaction over Cu/ZnO catalyst , 1992 .

[18]  M. S. Spencer,et al.  Mechanism of methanol synthesis from carbon monoxide and hydrogen on copper catalysts , 1989 .

[19]  Gilbert F. Froment,et al.  A DRIFTS study of the morphology and surface adsorbate composition of an operating methanol synthesis catalyst , 1994 .

[20]  T. S. King,et al.  Potassium's promotional effect of unsupported copper catalysts for methanol synthesis , 1989 .

[21]  T. S. King,et al.  Differences in the promotional effect of the group IA elements on unsupported copper catalysts for carbon monoxide hydrogenation , 1989 .

[22]  K. L. Tan,et al.  Comparative surface studies of high-Zn-level and commercial Cu/ZnO/Al2O3 catalysts , 1998 .

[23]  Junji Nakamura,et al.  The synergy between Cu and ZnO in methanol synthesis catalysts , 1996 .

[24]  G. Millar,et al.  Evidence for the adsorption of molecules at special sites located at copper/zinc oxide interfaces. Part 3.—Fourier-transform infrared study of methyl formate adsorption on reduced and oxidised Cu/ZnO/SiO2 catalysts , 1992 .

[25]  V. Ponec.  Cu and Pd, two catalysts for CH3OH synthesis : the similarities and the differences , 1992 .