Fuel effects on lean blow-out in a realistic gas turbine combustor

Abstract Towards the implementation of alternative jet fuels in aviation gas turbines, testing in combustor rigs and engines is required to evaluate the fuel performance on combustion stability, relight, and lean blow-out (LBO) characteristics. The objective of this work is to evaluate the effect of different fuel candidates on the operability of gas turbines by comparing a conventional petroleum-based fuel with two other alternative fuel candidates. A comparative study of fuel properties is first conducted to identify physico-chemical processes that are affected by these fuels. Subsequently, large-eddy simulations (LES) are performed to examine the performance of these fuels on the stable condition close to blow-out in a referee gas turbine combustor. LES results are compared to available experimental data to assess their capabilities in reproducing observed fuel effects. It is shown that the simulations correctly predict the spray main characteristics as well as the flame position. The change in OH*-emissions for different fuel candidates is also qualitatively captured. An analysis of the flame anchoring mechanisms highlights the fuel effects on the flame position. Finally, the LBO-behavior is examined in order to evaluate the LBO-limit in terms of equivalence ratio and identify fuel effects on the blow-out behavior.

[1]  Robert C. Hendricks,et al.  Alternate Fuels for Use in Commercial Aircraft , 2008 .

[2]  Epaminondas Mastorakos,et al.  Measurements in turbulent premixed bluff body flames close to blow-off , 2012 .

[3]  T. Lieuwen,et al.  Fuel Flexibility Influences on Premixed Combustor Blowout, Flashback, Autoignition, and Stability paper addresses the impact of fuel composition on the operability of lean premixed , 2006 .

[4]  Christian J R Coronado,et al.  Flammability limits: a review with emphasis on ethanol for aeronautical applications and description of the experimental procedure. , 2012, Journal of hazardous materials.

[5]  G. J. Sturgess,et al.  Fuel Effects on Lean Blowout and Emissions from a Well-Stirred Reactor , 1999 .

[6]  J. P. Longwell,et al.  Flame stabilization by bluff bodies and turbulent flames in ducts , 1953 .

[7]  M. Ihme,et al.  On the generalisation of the mixture fraction to a monotonic mixing-describing variable for the flamelet formulation of spray flames , 2015 .

[8]  Santosh J. Shanbhogue,et al.  Lean blowoff of bluff body stabilized flames: Scaling and dynamics , 2009 .

[9]  M. Stöhr,et al.  Dynamics of lean blowout of a swirl-stabilized flame in a gas turbine model combustor , 2011 .

[10]  Heinz Pitsch,et al.  Prediction of local extinction and re-ignition effects in non-premixed turbulent combustion using a flamelet/progress variable approach , 2005 .

[11]  Parviz Moin,et al.  Towards time-stable and accurate LES on unstructured grids , 2007 .

[12]  Tim Edwards,et al.  Advancements in Gas Turbine Fuels From 1943 to 2005 , 2005 .

[13]  F. Nicoud,et al.  Subgrid-Scale Stress Modelling Based on the Square of the Velocity Gradient Tensor , 1999 .

[14]  A. Lefebvre,et al.  Ignition and flame quenching of flowing heterogeneous fuel-air mixtures , 1979 .

[15]  Simon Blakey,et al.  Aviation gas turbine alternative fuels: A review , 2011 .

[16]  J. Gore,et al.  Effect of Aviation Fuel Type and Fuel Injection Conditions on Non-reacting Spray Characteristics of a Hybrid Airblast Fuel Injector , 2016 .

[17]  P. Habisreuther,et al.  Similarity Issues of Kerosene and Methane Confined Flames Stabilized by Swirl in Regard to the Weak Extinction Limit , 2012 .

[18]  James F. Driscoll,et al.  Enhancement of flame blowout limits by the use of swirl , 1989 .

[19]  Christof Schulz,et al.  Investigation of the kinetics of OH∗ and CH∗ chemiluminescence in hydrocarbon oxidation behind reflected shock waves , 2012 .

[20]  Arash Ateshkadi,et al.  Lean blowout model for a spray-fired swirl-stabilized combustor , 2000 .

[21]  P. Moin,et al.  LES of atomizing spray with stochastic modeling of secondary breakup , 2002 .

[22]  T. Muruganandam,et al.  Fluid Mechanics of Lean Blowout Precursors in Gas Turbine Combustors , 2012 .

[23]  Heinz Pitsch,et al.  Development of an Experimental Database and Kinetic Models for Surrogate Diesel Fuels , 2007 .

[24]  LES/CMC of Blow-off in a Liquid Fueled Swirl Burner , 2014 .

[25]  M. Boileau,et al.  LES of an ignition sequence in a gas turbine engine , 2008 .

[26]  Sourabh V. Apte,et al.  Large-Eddy Simulation of Realistic Gas Turbine Combustors , 2004 .

[27]  Marina Braun-Unkhoff,et al.  About the interaction between composition and performance of alternative jet fuels , 2016 .

[28]  Thierry Poinsot,et al.  Acoustic and Large Eddy Simulation studies of azimuthal modes in annular combustion chambers , 2012 .

[29]  Carl L. Yaws,et al.  Chemical properties handbook : physical, thermodynamic, environmental, transport, safety, and health related properties for organic and inorganic chemicals , 1999 .

[30]  S. Plee,et al.  Characteristic time correlation for lean blowoff of bluff-body-stabilized flames☆ , 1979 .

[31]  Tim Edwards,et al.  Advanced aviation fuels : a look ahead via a historical perspective , 2001 .

[32]  K. M. Watson,et al.  Prediction of Critical Temperatures and Heats of Vaporization , 1931 .

[33]  Jian Zhang,et al.  Regularization of reaction progress variable for application to flamelet-based combustion models , 2012, J. Comput. Phys..

[34]  Arthur H. Lefebvre,et al.  Fuel Effects on Gas Turbine Combustion—Ignition, Stability, and Combustion Efficiency , 1984 .

[35]  David Turner,et al.  An Overview of the National Jet Fuels Combustion Program , 2017 .

[36]  E. Mastorakos,et al.  Detailed chemistry LES/CMC simulation of a swirling ethanol spray flame approaching blow-off , 2017 .

[37]  E. Mastorakos,et al.  A Comparison of the Blow-Off Behaviour of Swirl-Stabilized Premixed, Non-Premixed and Spray Flames , 2013 .

[38]  M. Ihme,et al.  The role of preferential evaporation on the ignition of multicomponent fuels in a homogeneous spray/air mixture , 2017 .

[39]  Tim Edwards.  Advancements in Gas Turbine Fuels From 1943 to 2005 , 2005 .

[40]  Renaud Lecourt,et al.  Detailed Characterisation of a Swirled Air/Kerosene Spray in Reactive and Non-Reactive Conditions Downstream From an Actual Turbojet Injection System , 2011 .

[41]  A. W. Vreman.  An eddy-viscosity subgrid-scale model for turbulent shear flow: Algebraic theory and applications , 2004 .

[42]  E. Mastorakos,et al.  Heat Release Imaging in Turbulent Premixed Ethylene-Air Flames Near Blow-off , 2016 .

[43]  T. Hasegawa,et al.  Structure and blow-off mechanism of rod-stabilized premixed flame , 1985 .

[44]  M. Ihme,et al.  Large eddy simulation of a partially-premixed gas turbine model combustor , 2015 .

[45]  Josette Bellan,et al.  Direct numerical simulations of supercritical fluid mixing layers applied to heptane–nitrogen , 2001, Journal of Fluid Mechanics.

[46]  E. Mastorakos,et al.  Prediction of Global Extinction Conditions and Dynamics in Swirling Non-premixed Flames Using LES/CMC Modelling , 2015, Flow, Turbulence and Combustion.

[47]  P. Moin,et al.  Progress-variable approach for large-eddy simulation of non-premixed turbulent combustion , 2004, Journal of Fluid Mechanics.

[48]  A. Masri,et al.  Visualization of blow-off events in bluff-body stabilized turbulent premixed flames , 2011 .