Effect of dispersion state of carbon nanotube on the thermal conductivity of poly(dimethyl siloxane) composites

Abstract Herein, the effect of dispersion uniformity of multi-walled carbon nanotube (MWCNT) on the thermal conductivity of poly(dimethyl siloxane) (PDMS) composites was investigated by comparing experimentally obtained and calculated results based on simple models. Two different MWCNTs, i.e., raw and oxidized/masterbatched MWCNTs, were used and compared. For raw MWCNT, the dispersion in PDMS was poor, resulting in the significant reduction in the aspect ratio of MWCNT. However, for composites using masterbatched MWCNT, the thermal conductivity was always about 10% greater than those prepared with raw MWCNT and the aspect ratio calculated by the model equation was also 1.7 times greater. Above 1.5 phr masterbatched MWCNT concentrations, the aspect ratio of 430 was maintained. Finally, the results suggest that the thermal conductivity can be correlated with the degree of dispersion and aspect ratio obtained from the model equation used.

[1]  R. L. Webb,et al.  Performance and testing of thermal interface materials , 2003, Microelectron. J..

[2]  Yuanhua Lin,et al.  Interface effect on thermal conductivity of carbon nanotube composites , 2004 .

[3]  Kankanhalli N. Seetharamu,et al.  Thermal characterization of Al2O3 and ZnO reinforced silicone rubber as thermal pads for heat dissipation purposes , 2005 .

[4]  Eklund,et al.  Solution properties of single-walled carbon nanotubes , 1998, Science.

[5]  M. Radosavljevic,et al.  Carbon nanotube composites for thermal management , 2002, cond-mat/0205418.

[6]  I. Yilgor,et al.  Thermal stabilities of end groups in hydroxyalkyl terminated polydimethylsiloxane oligomers , 1998 .

[7]  D. Chung.  Materials for thermal conduction , 2001 .

[8]  G. Boiteux,et al.  Segregated network polymer/carbon nanotubes composites , 2004 .

[9]  Ravi Prasher,et al.  Thermal Interface Materials: Historical Perspective, Status, and Future Directions , 2006, Proceedings of the IEEE.

[10]  C. Hong,et al.  Measurement of the dispersion stability of pristine and surface-modified multiwalled carbon nanotubes in various nonpolar and polar solvents , 2007 .

[11]  E. Grulke,et al.  Anomalous thermal conductivity enhancement in nanotube suspensions , 2001 .

[12]  M. Monthioux,et al.  Sensitivity of single-wall carbon nanotubes to chemical processing: an electron microscopy investigation , 2001 .

[13]  P. McEuen,et al.  Thermal transport measurements of individual multiwalled nanotubes. , 2001, Physical Review Letters.

[14]  C. Nan,et al.  A simple model for thermal conductivity of carbon nanotube-based composites , 2003 .