Selective hydrogenation of 1,5,9-cyclododecatriene in up- and down-flow fixed-bed reactors: experimental observations and modeling

The performance of trickle- and flooded-bed reactors has been investigated and compared for an exothermic multi-step catalytic reaction. Selective hydrogenation of cyclododecatriene over Pd/Al 2 O 3 has been studied in both up- and down-flow modes of operation in the same pilot reactor. In the down-flow mode, hot spots and runaway could not be avoided without diluting both catalyst bed and liquid reactant. With this diluted system, the up-flow reactor leads to a higher productivity and a much better selectivity. A non-isothermal plug-flow reactor model predicts the performances of the up-flow reactor satisfactorily, but is found to be unsuitable to the case of a trickle-bed reactor. In the latter case, the productivity was underestimated, when complete wetting of catalyst particles was assumed. On the other hand, when partial wetting effect was incorporated, the calculated selectivity was always much higher than that observed actually in a trickle bed, due to heterogeneities of liquid velocity and partial wetting (poorly irrigated zones).

[1]  C. Satterfield,et al.  Liquid‐solid mass transfer in packed beds with downward concurrent gas‐liquid flow , 1978 .

[2]  S. Goto,et al.  Mass Transfer in Packed Beds with Two-Phase Flow , 1975 .

[3]  Yuanxin Wu,et al.  Comparison of trickle-bed and upflow reactor performance at high pressure: Model predictions and experimental observations , 1996 .

[4]  Milorad P. Dudukovic,et al.  Trickle-Bed Reactors: Dynamic Tracer Tests, Reaction Studies, and Modeling of Reactor Performance , 1982 .

[5]  Frank Stüber.  Sélectivité en réacteur catalytique triphasique : analyse expérimentale et théorique d'hydrogénations consécutives en lit fixe catalytique à co-courant ascendant de gaz et de liquide , 1995 .

[6]  Vito Specchia,et al.  HEAT TRANSFER IN TRICKLE-BED REACTORS , 1979 .

[7]  S. Whitaker.  Forced convection heat transfer correlations for flow in pipes, past flat plates, single cylinders, single spheres, and for flow in packed beds and tube bundles , 1972 .

[8]  Shigeo Goto,et al.  Hydration of 2-Methyl-2-Butene in Gas-Liquid Cocurrent Upflow and Downflow Reactors , 1993 .

[9]  F. Stüber,et al.  Modelling of three phase catalytic upflow reactor: A significant chemical determination of liquid-solid and gas-liquid mass transfer coefficients , 1996 .

[10]  S. N. Upadhyay,et al.  Particle-Fluid Mass Transfer in Fixed and Fluidized Beds , 1977 .

[11]  Raghunath V. Chaudhari,et al.  A trickle-bed reactor model for hydrogenation of 2,4 dinitrotoluene: experimental verification , 1998 .

[12]  Koichi Mabuchi,et al.  Oxidation of ethanol in gas‐liquid cocurrent upflow and downflow reactors , 1984 .

[13]  S. Fukushima,et al.  Liquid-phase volumetric and mass-transfer coefficient, and boundary of hydrodynamic flow region in packed column with cocurrent downward flow. , 1977 .

[14]  Faïçal Larachi,et al.  Some experimental liquid saturation results in fixed-bed reactors operated under elevated pressure in cocurrent upflow and downflow of the gas and the liquid , 1991 .

[15]  J. Smith,et al.  A dynamic method for liquid‐particle mass transfer in trickle beds , 1982 .

[16]  Vito Specchia,et al.  Trickle-bed reactors: state of art and perspectives , 1992 .