Impact of Epi-Layer Quality on Reliability of GaN/AlGaN/GaN Heterostructure Field-Effect Transistors on Si Substrate

This paper reports the impact of epi-layer quality on the short-term reliability of GaN/AlGaN/GaN heterostructure field-effect transistors fabricated on Si substrates. At an early stage of 50 V high-temperature operating life tests, they exhibited a significant lowering of the forward breakdown voltage. The mean time to failure (MTTF) determined by this degradation mode was exponentially increased by decreasing full-width at half-maximum (FWHM) values of X-ray rocking curves. In small FWHM samples, extrapolated MTTF values exceeded 1×107 h at Tch=150°C. Alternatively, another degradation mode such as drain current degradation will dominate the long-term reliability at this temperature range. High-resolution transmission electron microscope and energy dispersive X-ray spectroscopy analyses revealed thinning or partial vanishment of GaN cap layer in a degraded sample. Gate current-voltage characteristics calculation based on the self-consistent Schrödinger-Poisson analysis suggested lowering of the effective barrier height by decreasing cap layer thickness is responsible for the Schottky degradation. When considering these experimental and theoretical findings, degradation mechanisms assuming diffusion of interfacial materials along dislocations are discussed.

[1]  Umesh K. Mishra,et al.  GaN-Based RF Power Devices and Amplifiers , 2008, Proceedings of the IEEE.

[2]  R. Grundbacher,et al.  Degradation of AlGaN/GaN HEMTs under elevated temperature lifetesting , 2004, Microelectron. Reliab..

[3]  J. D. del Alamo,et al.  Mechanisms for Electrical Degradation of GaN High-Electron Mobility Transistors , 2006, 2006 International Electron Devices Meeting.

[4]  Olivier Latry,et al.  Physical analysis of Schottky contact on power AlGaN/GaN HEMT after pulsed-RF life test , 2012, Microelectron. Reliab..

[5]  Gaudenzio Meneghesso,et al.  Evaluation of GaN HEMT degradation by means of pulsed I-V, leakage and DLTS measurements , 2009 .

[6]  Thomas Ihn.  Two-dimensional electron gases in heterostructures , 2009 .

[7]  Carl V. Thompson,et al.  Evolution of structural defects associated with electrical degradation in AlGaN/GaN high electron mobility transistors , 2010 .

[8]  Seong-Yong Park,et al.  TEM Observation of Crack- and Pit-Shaped Defects in Electrically Degraded GaN HEMTs , 2008, IEEE Electron Device Letters.

[9]  K. Matsunaga,et al.  Novel AlGaN/GaN dual-field-plate FET with high gain, increased linearity and stability , 2005, IEEE InternationalElectron Devices Meeting, 2005. IEDM Technical Digest..

[10]  S. Singhal,et al.  GaN-ON-Si Failure Mechanisms and Reliability Improvements , 2006, 2006 IEEE International Reliability Physics Symposium Proceedings.

[11]  Y. Okamoto,et al.  10-W/mm AlGaN-GaN HFET with a field modulating plate , 2003, IEEE Electron Device Letters.

[12]  Naoki Hara,et al.  Reliability of GaN HEMTs: current status and future technology , 2009, 2009 IEEE International Reliability Physics Symposium.

[13]  Electron Transport Mechanism for Ohmic Contact to GaN/AlGaN/GaN Heterostructure Field-Effect Transistors , 2013, IEEE Transactions on Electron Devices.

[14]  G. Verzellesi,et al.  Reliability of GaN High-Electron-Mobility Transistors: State of the Art and Perspectives , 2008, IEEE Transactions on Device and Materials Reliability.

[15]  K. Makiyama,et al.  Degradation-Mode Analysis for Highly Reliable GaN-HEMT , 2007, 2007 IEEE/MTT-S International Microwave Symposium.

[16]  Lin Zhou,et al.  Effect of source field plate on the characteristics of off-state, step-stressed AlGaN/GaN high electron mobility transistors , 2011 .

[17]  Hervé Blanck,et al.  Reliability behavior of GaN HEMTs related to Au diffusion at the Schottky interface , 2009 .

[18]  H. Miyamoto,et al.  A normally-off GaN FET with high threshold voltage uniformity using a novel piezo neutralization technique , 2009, 2009 IEEE International Electron Devices Meeting (IEDM).

[19]  K. Hilton,et al.  Piezoelectric strain in AlGaN∕GaN heterostructure field-effect transistors under bias , 2006 .

[20]  Umesh K. Mishra,et al.  AlGaN/GaN HEMT device reliability and degradation evolution: Importance of diffusion processes , 2011, Microelectron. Reliab..

[21]  Gaudenzio Meneghesso,et al.  RF degradation of GaN HEMTs and its correlation with DC stress and I-DLTS measurements , 2009, 2009 European Microwave Integrated Circuits Conference (EuMIC).

[22]  Sven Einfeldt,et al.  X-ray diffraction analysis of the defect structure in epitaxial GaN , 2000 .

[23]  K. Asano,et al.  Theoretical and Experimental Study of Inverse Piezoelectric Effect in AlGaN/GaN Field-Plated Heterostructure Field-Effect Transistors , 2012, IEEE Transactions on Electron Devices.

[24]  S. J. Pearton,et al.  Oxygen diffusion into SiO2-capped GaN during annealing , 1999 .

[25]  Hyungtak Kim,et al.  Hot electron induced degradation of undoped AlGaN/GaN HFETs , 2003, Microelectron. Reliab..

[26]  S. Delage,et al.  Evidence of traps creation in GaN/AlGaN/GaN HEMTs after a 3000 hour on-state and off-state hot-electron stress , 2005, IEEE InternationalElectron Devices Meeting, 2005. IEDM Technical Digest..

[27]  Lester F. Eastman,et al.  Two-dimensional electron gases induced by spontaneous and piezoelectric polarization charges in N- and Ga-face AlGaN/GaN heterostructures , 1999 .

[28]  Guann-Pyng Li,et al.  Observing Electroluminescence from Yellow Luminescence-Like Defects in GaN High Electron Mobility Transistors , 2008 .