Scale effects on propeller cavitating hydrodynamic and hydroacoustic performances with non-uniform inflow

Considering the lack of theoretical models and ingredients necessary to explain the scaling of the results of propeller cavitation inception and cavitating hydroacoustics from model tests to full scale currently, and the insufficient reflection of the nuclei effects on cavitation in the numerical methods, the cavitating hydrodynamics and cavitation low frequency noise spectrum of three geometrically similar 7-bladed highly skewed propellers with non-uniform inflow are addressed. In this process, a numerical bridge from the multiphase viscous simulation of propeller cavitation hydrodynamics to its hydro-acoustics is built, and the scale effects on performances and the applicability of exist scaling law are analyzed. The effects of non-condensable gas(NCG) on cavitation inception are involved explicitly in the improved Sauer’s cavitation model, and the cavity volume acceleration related to its characteristic length is used to produce the noise spectrum. Results show that, with the same cavitation number, the cavity extension on propeller blades increases with diameter associated with an earlier shift of the beginning point of thrust decline induced by cavitation, while the three decline slopes of thrust breakdown curves are found to be nearly the same. The power of the scaling law based on local Reynolds number around 0.9R section is determined as 0.11. As for the smallest propeller, the predominant tonal noise is located at blade passing frequency(BPF), whereas 2BPF for the middle and both 2BPF and 3BPF for the largest, which shows the cavitating line spectrum is fully related to the interaction between non-uniform inflow and fluctuated cavity volume. The predicted spectrum level exceedance from the middle to the large propeller is 6.65 dB at BPF and 5.94 dB at 2BPF. Since it just differs less than 2 dB to the increment obtained by empirical scaling law, it is inferred that the scale effects on them are acceptable with a sufficient model scale, and so do the scaling law. The numerical implementation of cavitating hydrodynamics and hydro-acoustics prediction of propeller in big scale in wake has been completed.

[1]  Francisco Pereira,et al.  Measurement and Modeling of Propeller Cavitation in Uniform Inflow , 2004 .

[2]  Georges L. Chahine,et al.  Scaling of Tip Vortex Cavitation Inception Noise With a Bubble Dynamics Model Accounting for Nuclei Size Distribution , 2005 .

[3]  Andreas Peter Keller,et al.  Cavitation Scale Effects - Empirically Found Relations and the Correlation of Cavitation Number and Hydrodynamic Coefficients , 2001 .

[4]  Bin Ji,et al.  Unsteady Numerical Simulation of Cavitating Turbulent Flow Around a Highly Skewed Model Marine Propeller , 2011 .

[5]  Mehmet Atlar,et al.  CAVITATION TUNNEL TESTS FOR PROPELLER NOISE OF A FRV AND COMPARISONS WITH FULL-SCALE MEASUREMENTS , 2001 .

[6]  Woo Young Choi,et al.  Numerical prediction of tip vortex cavitation behavior and noise considering nuclei size and distribution , 2009 .

[7]  Mitja Morgut,et al.  Influence of the Mass Transfer Model on the Numerical Prediction of the Cavitating Flow Around a Marine Propeller , 2011 .

[8]  A. K. Singhal,et al.  Mathematical Basis and Validation of the Full Cavitation Model , 2002 .

[9]  Mesut Güner,et al.  A Practical Noise Prediction Method for Cavitating Marine Propellers , 2010 .

[10]  Yang,et al.  Propeller cavitation viscous simulation and low-frequency noise prediction with non-uniform inflow , 2013 .

[11]  François Avellan,et al.  Prediction of Cavitation Erosion: An Energy Approach , 1998 .

[12]  Takafumi Kawamura,et al.  Propeller Cavitation Study Using an Unstructured Grid Based Navier-Stoker Solver , 2005 .

[13]  D. R. Stinebring,et al.  A preconditioned Navier–Stokes method for two-phase flows with application to cavitation prediction , 2000 .

[14]  G. P. Succi,et al.  The prediction of helicopter rotor discrete frequency noise , 1982 .

[15]  Keun Woo Shin,et al.  Cavitation simulation on marine propellers , 2010 .

[16]  J. A. Szantyr.  Scale effects in cavitation experiments with marine propeller models , 2006 .

[17]  Jung-Chun Suh,et al.  Prediction of Non-Cavitating Underwater Propeller Noise , 2002 .

[18]  Michael P. Kinzel,et al.  Computation of cavitating flow through marine propulsors , 2009 .

[19]  Mehmet Atlar,et al.  On the importance of the effect of turbulence in cavitation inception tests of marine propellers , 2002, Proceedings of the Royal Society of London. Series A: Mathematical, Physical and Engineering Sciences.

[20]  Yang Qiongfang.  Assessment of the Improved Cavitation Model and Modified Turbulence Model for Ship Propeller Cavitation Simulation , 2012 .

[21]  Donald Roe Ross,et al.  Mechanics of underwater noise , 1976 .

[22]  Marina Olsson.  Numerical investigation on the cavitating flow in a waterjet pump Master's Thesis , 2008 .

[23]  Yang Qiong-fang.  Procedural realization of pre-operation in CFD prediction of propeller hydrodynamics , 2012 .

[24]  C. Testa,et al.  Acoustic formulations for aeronautical and naval rotorcraft noise prediction based on the Ffowcs Williams and Hawkings equation , 2008 .