Comparison of SI-ANN and Extended Kalman Filter-Based Sensorless Speed Controls of a DC Motor

In this study, a speed sensorless algorithm was developed to control a single-link manipulator connected to DC motor. The armature voltage value can be obtained by using duty cycle information generated by the controller without using any sensor. Thus, the proposed system does not require any additional measurement sensor. This paper presents a study for artificial neural network (ANN)-based speed estimation algorithm which has a closed-loop speed control with the first and second inputs generated via support of system identification (SI). The second SI input was obtained as a simple transfer function with discrete time. The performances of the SI-input ANN structure and the conventional extended Kalman filter (EKF) method were compared in the MATLAB/Simulink environment. It was observed that the proposed method revealed better results than the EKF method in the steady and transient states. Thus, it was shown that high-performance sensorless speed control could be performed with SI-ANN structure in applications.

[1]  Ayedh Alqahtani,et al.  Photovoltaic Power Forecasting Model Based on Nonlinear System Identification , 2016, Canadian Journal of Electrical and Computer Engineering.

[2]  Damian Giaouris,et al.  Advances on System Identification Techniques for DC–DC Switch Mode Power Converter Applications , 2019, IEEE Transactions on Power Electronics.

[3]  Jianning Dong,et al.  Position Sensorless Drive and Online Parameter Estimation for Surface-Mounted PMSMs Based on Adaptive Full-State Feedback Control , 2020, IEEE Transactions on Power Electronics.

[4]  Erkan Deniz,et al.  ANN-based MPPT algorithm for solar PMSM drive system fed by direct-connected PV array , 2016, Neural Computing and Applications.

[5]  He Zhang,et al.  A Third-Order Super-Twisting Extended State Observer for Dynamic Performance Enhancement of Sensorless IPMSM Drives , 2020, IEEE Transactions on Industrial Electronics.

[6]  Chris Gerada,et al.  A Nonlinear Extended State Observer for Rotor Position and Speed Estimation for Sensorless IPMSM Drives , 2020, IEEE Transactions on Power Electronics.

[7]  Omur Aydogmus,et al.  A comparison of artificial neural network and extended Kalman filter based sensorless speed estimation , 2015 .

[8]  Malika Zazi,et al.  A novel metaheuristic model-based approach for accurate online broken bar fault diagnosis in induction motor using unscented Kalman filter and ant lion optimizer , 2020, Trans. Inst. Meas. Control.

[9]  Jianbin Qiu,et al.  Observer-Based Fuzzy Adaptive Event-Triggered Control for Pure-Feedback Nonlinear Systems With Prescribed Performance , 2019, IEEE Transactions on Fuzzy Systems.

[10]  Roberto Oboe,et al.  Sensorless full-digital PMSM drive with EKF estimation of speed and rotor position , 1999, IEEE Trans. Ind. Electron..

[11]  Murat Barut,et al.  Novel hybrid estimator based on model reference adaptive system and extended Kalman filter for speed-sensorless induction motor control , 2018, Trans. Inst. Meas. Control.

[12]  Gerasimos G Rigatos,et al.  Particle and Kalman filtering for state estimation and control of DC motors. , 2009, ISA transactions.

[13]  Robert E. Kearney,et al.  A Subspace Approach to the Structural Decomposition and Identification of Ankle Joint Dynamic Stiffness , 2017, IEEE Transactions on Biomedical Engineering.

[14]  Frede Blaabjerg,et al.  A Class of Speed-Sensorless Sliding-Mode Observers for High-Performance Induction Motor Drives , 2009, IEEE Transactions on Industrial Electronics.

[15]  Omur Aydogmus,et al.  Comparison of Extended-Kalman- and Particle-Filter-Based Sensorless Speed Control , 2012, IEEE Transactions on Instrumentation and Measurement.

[16]  Jianbin Qiu,et al.  Fuzzy Adaptive Finite-Time Fault-Tolerant Control for Strict-Feedback Nonlinear Systems , 2020, IEEE Transactions on Fuzzy Systems.

[17]  Resat Celikel,et al.  ANN based angle tracking technique for shaft resolver , 2019 .

[18]  M. Kemal Leblebicioglu,et al.  Experimental test of vision-based navigation and system identification of an unmanned underwater survey vehicle (SAGA) for the yaw motion , 2019 .

[19]  Shaoguang Zhang,et al.  Very-low speed control of PMSM based on EKF estimation with closed loop optimized parameters. , 2013, ISA transactions.

[20]  Mehmet Polat,et al.  Sensorless field oriented control of nonsinusoidal flux-distribution permanent magnet synchronous motor with a FEM based ANN observer , 2016 .

[21]  Reşat Çelikel,et al.  Speed Control of BLDC Using NARMA-L2 Controller in Single Link Manipulator , 2019, Balkan Journal of Electrical and Computer Engineering.

[22]  Sule Ozev,et al.  Online Built-In Self-Test of High Switching Frequency DC–DC Converters Using Model Reference Based System Identification Techniques , 2018, IEEE Transactions on Circuits and Systems I: Regular Papers.

[23]  Mingyi Wang,et al.  Robust Predictive Current Control of PMLSM With Extended State Modeling Based Kalman Filter: For Time-Varying Disturbance Rejection , 2020, IEEE Transactions on Power Electronics.

[24]  Giuseppe Giordano,et al.  Model-Based Lithium-Ion Battery Resistance Estimation From Electric Vehicle Operating Data , 2018, IEEE Transactions on Vehicular Technology.

[25]  Khaled Nouri,et al.  Adaptive control of a nonlinear dc motor drive using recurrent neural networks , 2008, Appl. Soft Comput..

[26]  Shumei Cui,et al.  Sensorless Control Strategy for IPMSM to Reduce Audible Noise by Variable Frequency Current Injection , 2020, IEEE Transactions on Industrial Electronics.

[27]  Omur Aydogmus,et al.  Implementation of EKF based sensorless drive system using vector controlled PMSM fed by a matrix converter , 2012 .

[28]  Ahmet Gundogdu,et al.  System identification‐based MPPT algorithm for PV systems under variable atmosphere conditions using current sensorless approach , 2020 .

[29]  Carlos-M. Astorga-Zaragoza,et al.  Bounded neuro-control position regulation for a geared DC motor , 2010, Eng. Appl. Artif. Intell..

[30]  Emre Ege,et al.  Experimental test of the acoustic-based navigation and system identification of an unmanned underwater survey vehicle (SAGA) , 2018, Trans. Inst. Meas. Control.

[31]  Andrija T. Saric,et al.  Information geometry for model identification and parameter estimation in renewable energy – DFIG plant case , 2017 .

[32]  Eric Monmasson,et al.  Optimization of Perturbative PV MPPT Methods Through Online System Identification , 2014, IEEE Transactions on Industrial Electronics.

[33]  Jianbin Qiu,et al.  Command Filter-Based Adaptive NN Control for MIMO Nonlinear Systems With Full-State Constraints and Actuator Hysteresis , 2020, IEEE Transactions on Cybernetics.

[34]  Shuaichen Ye,et al.  A Modified Flux Sliding-Mode Observer for the Sensorless Control of PMSMs With Online Stator Resistance and Inductance Estimation , 2020, IEEE Transactions on Power Electronics.