Estimating gas holdup via pressure difference measurements in a cocurrent bubble column

Abstract Estimating gas holdup via pressure difference measurements is a simple and low-cost non-invasive technique to study gas holdup in bubble columns. It is usually used in a manner where the wall shear stress effect is neglected, termed Method II in this paper. In cocurrent bubble columns, when the liquid velocity is high or the fluid is highly viscous, wall shear stress may be significant and Method II may result in substantial error. Directly including the wall shear stress term in the determination of gas holdup (Method I) requires knowledge of two-phase wall shear stress models and usually requires the solution of non-linear equations. A new gas holdup estimation method (Method III) via differential pressure measurements for cocurrent bubble columns is proposed in this paper. This method considers the wall shear stress influences on gas holdup values without calculating the wall shear stress. A detailed analysis shows that Method III always results in a smaller gas holdup error than Method II, and in many cases, the error is significantly smaller than that of Method II. The applicability of Method III in measuring gas holdup in a cocurrent air–water–fiber bubble column is examined. Analysis based on experimental data shows that with Method III, accurate gas holdup measurements can be obtained, while measurement error is significant when Method II is used for some operational conditions.

[1]  Theodore J. Heindel,et al.  Gas Holdup Behavior in Nylon Fiber Suspensions , 2004 .

[2]  M. Fialová,et al.  Duality of the gas-liquid flow regimes in bubble column reactors , 1997 .

[3]  J. H. Hills,et al.  The operation of a bubble column at high throughputs: I. Gas holdup measurements , 1976 .

[4]  Gabriel Wild,et al.  Study of hydrodynamic behaviour in bubble columns and external loop airlift reactors through analysis of pressure fluctuations , 2000 .

[5]  J. Joshi,et al.  Transport phenomena in bubble colunm reactor II: Pressure drop , 1992 .

[6]  Rajamani Krishna,et al.  Gas holdup and mass transfer in bubble column reactors operated at elevated pressure. , 1999 .

[7]  D. E. Beasley,et al.  Theory and design for mechanical measurements , 1991 .

[8]  Tay-Jian Liu.  Investigation of the wall shear stress in vertical bubbly flow under different bubble size conditions , 1997 .

[9]  J. Ruud van Ommen,et al.  Detecting regime transitions in slurry bubble columns using pressure time series , 2005 .

[10]  van Jr Ommen,et al.  Bubble size estimation in slurry bubble columns from pressure fluctuations , 2005 .

[11]  B. G. Kelkar,et al.  Effect of addition of alcohols on gas holdup and backmixing in bubble columns , 1983 .

[12]  Liang-Shih Fan,et al.  Bubble flow characteristics in bubble columns at elevated pressure and temperature , 1998 .

[13]  Gabriel Wild,et al.  Experimental study of bubble column hydrodynamics , 2001 .

[14]  T. Heindel,et al.  Local Gas Holdup Variation in a Fiber Slurry , 2005 .

[15]  Theodore J. Heindel,et al.  Gas Holdup in a Fiber Suspension , 2008 .

[16]  B. G. Kelkar,et al.  Hydrodynamics and axial mixing in a three-phase bubble column , 1982 .

[17]  Theodore J. Heindel,et al.  The effect of fiber consistency on bubble size , 1999 .

[18]  J. Gullichsen.  Medium-Consistency Technology, I. Fundamental Data , 1981 .

[19]  Theodore J. Heindel,et al.  Effect of fiber type on gas holdup in a cocurrent air–water–fiber bubble column , 2005 .

[20]  Theodore J. Heindel,et al.  Gas‐liquid‐fiber flow in a cocurrent bubble column , 2005 .

[21]  G. Wallis.  One Dimensional Two-Phase Flow , 1969 .

[22]  J. Marié,et al.  Modelling of the skin friction and heat transfer in turbulent two-component bubbly flows in pipes , 1987 .

[23]  Yatish T. Shah,et al.  Design parameters estimations for bubble column reactors , 1982 .

[24]  Waheed A. Al-Masry.  Gas Holdup in Circulating Bubble Columns with Pseudoplastic Liquids , 2001 .

[25]  R. Kerekes,et al.  Power requirements for pulp suspension fluidization , 1996 .

[26]  Liang-Shih Fan,et al.  High-pressure three-phase fluidization: Hydrodynamics and heat transfer , 1997 .

[27]  Sailesh Kumar,et al.  Measurement techniques for local and global fluid dynamic quantities in two and three phase systems , 1998 .

[28]  Jose C. Merchuk,et al.  Local hold‐up and liquid velocity in air‐lift reactors , 1981 .

[29]  Chengzhi Tang.  Hydrodynamics and gas holdup in a cocurrent air-water-fiber bubble column , 2005 .

[30]  Faïçal Larachi,et al.  Non-invasive monitoring of multiphase flows , 1997 .

[31]  Michael R. Davis,et al.  Flow structure and distribution effects in gas-liquid mixture flows , 1978 .

[32]  Gabriel Wild,et al.  Measuring techniques in gas–liquid and gas–liquid–solid reactors , 2002 .

[33]  Steven Beyerlein,et al.  Prediction of bubble concentration profiles in vertical turbulent two-phase flow , 1985 .