Ultraviolet femtosecond, picosecond and nanosecond laser microstructuring of silicon: structural and optical properties.

The effect of laser pulse duration on the morphology, composition, crystallinity and optical properties of self-organized Si microcones fabricated using 248 nm laser pulses (500 fs, 5 ps and 15 ns) in an SF(6) atmosphere, is presented in this paper. Despite distinct differences in the morphology, the Si cones show similar structure and composition independently of the laser pulse duration used: a core of single-crystalline Si, covered by a few hundred nanometer thick, sulfur-doped nanocrystalline Si layer, where no amorphous Si is present. The obtained features exhibit strong below-bandgap absorptance, making them excellent candidates for Si based photodetectors with improved spectral response.

[1]  Eric Mazur,et al.  Comparison of Structure and Properties of Femtosecond and Nanosecond Laser-Structured Silicon , 2004 .

[2]  E. Zschech,et al.  Cross-sectional thin film characterization of Si compounds in semiconductor device structures using both elemental and ELNES mapping by EFTEM , 2002 .

[3]  G. Duscher,et al.  Core-hole effects on energy-loss near-edge structure. , 2001, Ultramicroscopy.

[4]  S. Muto,et al.  Experimental and full multiple scattering approaches to energy-loss near-edge structures (ELNES) for c-Si, a-Si and a-Si:H , 2003 .

[5]  Costas Fotakis,et al.  Making silicon hydrophobic: wettability control by two-lengthscale simultaneous patterning with femtosecond laser irradiation , 2006, Nanotechnology.

[6]  E. Mazur,et al.  Infrared absorption by sulfur-doped silicon formed by femtosecond laser irradiation , 2004 .

[7]  E. N. Loubnin,et al.  Low-threshold field electron emission of Si micro-tip arrays produced by laser ablation , 2003 .

[8]  I. Alexandrou,et al.  Laser microstructuring of Si surfaces for low-threshold field-electron emission , 2004 .

[9]  Jason D. Fowlkes,et al.  Early stages of pulsed-laser growth of silicon microcolumns and microcones in air and SF6 , 1999 .

[10]  Gianluigi A. Botton,et al.  Imaging, spectroscopy and spectroscopic imaging with an energy filtered field emission TEM , 1999 .

[11]  Eric Mazur,et al.  Near-unity below-band-gap absorption by microstructured silicon , 2001 .

[12]  K. Kolasinski,et al.  Solidification driven extrusion of spikes during laser melting of silicon pillars , 2006 .

[13]  Jason D. Fowlkes,et al.  Silicon microcolumn arrays grown by nanosecond pulsed-excimer laser irradiation , 1999 .

[14]  Costas Fotakis,et al.  Silicon electron emitters fabricated by ultraviolet laser pulses , 2006 .

[15]  W. M. Skiff,et al.  Near-edge fine-structure analysis of core-shell electronic absorption edges in silicon and its refractory compounds with the use of electron-energy-loss microspectroscopy , 1987 .