Microcystis aeruginosa-laden surface water treatment using ultrafiltration: Membrane fouling, cell integrity and extracellular organic matter rejection.

Despite its superb separation performance, ultrafiltration (UF) still faces challenges in treating the Microcystis aeruginosa-laden water of lakes or reservoirs, due to membrane fouling and poor rejection of soluble organics. In this work, to better understand the mechanisms of membrane fouling, cell breakage and organic rejection and their mutual influence, a comparative UF experiment was conducted under a variety of transmembrane pressures (TMPs, 50-250 kPa) with lab-cultured Microcystis aeruginosa. Membrane fouling was characterized with respect to flux decline and fouling reversibility, and cell breakage during UF filtration was evaluated using a flow cytometer. Moreover, the rejection of extracellular organic matter (EOM) by UF was investigated with respect to the dissolved organic carbon (DOC), ultraviolet absorbance at 254 nm (UV254) and microcystin-LR (MCLR). The results indicated that the accumulation of Microcystis cells and EOM on the membrane surface caused serious reversible fouling that substantially aggravated with the increasing TMP and was successively governed by pore blocking and cake filtration. The cell breakage during filtration was less than 5% and mainly occurred in the cake layer due to hydraulic shear, but the breakage did not substantially vary with increasing TMP. EOM removal by UF ranged from 40% to 70% (in terms of DOC removal), and the removal performance increased with the reversible resistance, implying a trade-off between organic removal and permeability. Regarding soluble and small organics such as MCLR, a higher degree of removal was also found at higher TMP, despite of some variations over the duration of the filtration tests, and the cake layer retention proved to be the principle removal mechanism, especially during steady filtration stages.

[1]  M. Rosa,et al.  Evaluation of cyanobacterial cells removal and lysis by ultrafiltration , 2010 .

[2]  Xiaolei Zhang,et al.  Influence of the characteristics of soluble algal organic matter released from Microcystis aeruginosa on the fouling of a ceramic microfiltration membrane , 2013 .

[3]  Christopher Bellona,et al.  Factors affecting the rejection of organic solutes during NF/RO treatment--a literature review. , 2004, Water research.

[4]  S. Jamaly.  Ultrafiltration Membrane Fouling and the Effect of Ion Exchange Resins , 2011 .

[5]  How Yong Ng,et al.  Influence of colloidal fouling on rejection of trace organic contaminants by reverse osmosis , 2004 .

[6]  A. Zydney,et al.  A Combined Pore Blockage and Cake Filtration Model for Protein Fouling during Microfiltration. , 2000, Journal of colloid and interface science.

[7]  Heng Liang,et al.  Ultrafiltration membrane fouling by extracellular organic matters (EOM) of Microcystis aeruginosa in stationary phase: influences of interfacial characteristics of foulants and fouling mechanisms. , 2012, Water research.

[8]  L. Ho,et al.  A coagulation-powdered activated carbon-ultrafiltration--multiple barrier approach for removing toxins from two Australian cyanobacterial blooms. , 2011, Journal of hazardous materials.

[9]  J. Brookes,et al.  The effects of various control and water treatment processes on the membrane integrity and toxin fate of cyanobacteria. , 2014, Journal of hazardous materials.

[10]  Xiaolei Zhang,et al.  Feedwater coagulation to mitigate the fouling of a ceramic MF membrane caused by soluble algal organic matter , 2014 .

[11]  M. Burch,et al.  A STUDY OF MEMBRANE FILTRATION FOR THE REMOVAL OF CYANOBACTERIAL CELLS , 1997 .

[12]  Wei Zhang,et al.  Characterization of dissolved organic matters responsible for ultrafiltration membrane fouling in algal harvesting , 2013 .

[13]  L. Ho,et al.  Integrated membrane systems incorporating coagulation, activated carbon and ultrafiltration for the removal of toxic cyanobacterial metabolites from Anabaena circinalis. , 2011, Water science and technology : a journal of the International Association on Water Pollution Research.

[14]  Gary Amy,et al.  Characterizing algogenic organic matter (AOM) and evaluating associated NF membrane fouling. , 2004, Water research.

[15]  M. Bilad,et al.  Role of transparent exopolymeric particles in membrane fouling: Chlorella vulgaris broth filtration. , 2013, Bioresource technology.

[16]  Yang Deng,et al.  Characterization of algal organic matters of Microcystis aeruginosa: biodegradability, DBP formation and membrane fouling potential. , 2014, Water research.

[17]  S. Takizawa,et al.  Microfiltration membrane fouling and cake behavior during algal filtration , 2010 .

[18]  David A. Ladner,et al.  Effects of shear on microfiltration and ultrafiltration fouling by marine bloom-forming algae , 2010 .

[19]  Jun Ma,et al.  Understanding ultrafiltration membrane fouling by extracellular organic matter of Microcystis aeruginosa using fluorescence excitation-emission matrix coupled with parallel factor analysis , 2014 .

[20]  Stuart J. Khan,et al.  Removal of trace organics by anaerobic membrane bioreactors. , 2014, Water research.

[21]  N. Gao,et al.  Formation of organic chloramines during chlor(am)ination and UV/chlor(am)ination of algae organic matter in drinking water. , 2016, Water research.

[22]  Xihui Zhang,et al.  Effect of in-situ ozonation on ceramic UF membrane fouling mitigation in algal-rich water treatment , 2016 .

[23]  Jun Ma,et al.  Comparison of permanganate preoxidation and preozonation on algae containing water: cell integrity, characteristics, and chlorinated disinfection byproduct formation. , 2013, Environmental science & technology.

[24]  Andrew L. Zydney,et al.  Analysis of humic acid fouling during microfiltration using a pore blockage-cake filtration model , 2002 .

[25]  Raj Mutharasan,et al.  Highly sensitive and rapid detection of microcystin-LR in source and finished water samples using cantilever sensors. , 2011, Environmental science & technology.

[26]  Jun Ma,et al.  Characterization of dissolved extracellular organic matter (dEOM) and bound extracellular organic matter (bEOM) of Microcystis aeruginosa and their impacts on UF membrane fouling. , 2012, Water research.

[27]  A. Fane,et al.  Microfiltration of algae (Chlorella sorokiniana): Critical flux, fouling and transmission , 2012 .

[28]  I. Chorus,et al.  Removal of cyanotoxins by ultrafiltration and nanofiltration , 2006 .

[29]  B. Jefferson,et al.  The impact of algogenic organic matter on water treatment plant operation and water quality: A review , 2016 .

[30]  Yang Deng,et al.  Characterization of intracellular & extracellular algae organic matters (AOM) of Microcystic aeruginosa and formation of AOM-associated disinfection byproducts and odor & taste compounds. , 2012, Water research.

[31]  J. Hermia,et al.  Constant Pressure Blocking Filtration Laws - Application To Power-law Non-newtonian Fluids , 1982 .

[32]  X. Niu,et al.  Retentions of bisphenol A and norfloxacin by three different ultrafiltration membranes in regard to drinking water treatment , 2016 .

[33]  Frederik Hammes,et al.  Stabilization of flux during dead-end ultra-low pressure ultrafiltration. , 2010, Water research.

[34]  Xiaolei Zhang,et al.  Understanding the fouling of a ceramic microfiltration membrane caused by algal organic matter released from Microcystis aeruginosa , 2013 .

[35]  R. Stuetz,et al.  Evaluation of effluent organic matter fouling in ultrafiltration treatment using advanced organic ch , 2011 .

[36]  Jungju Lee,et al.  Mechanisms and factors influencing the removal of microcystin-LR by ultrafiltration membranes , 2008 .

[37]  P. Leese.  Comparison of the effects , 1992 .

[38]  B. Jefferson,et al.  Characterisation of algogenic organic matter extracted from cyanobacteria, green algae and diatoms. , 2008, Water research.

[39]  Avani Mukesh Sanghvi,et al.  Characterization of algal biomeal for applications in food , 2009 .

[40]  L. Rietveld,et al.  Comparison of the effects of extracellular and intracellular organic matter extracted from Microcystis aeruginosa on ultrafiltration membrane fouling: dynamics and mechanisms. , 2014, Environmental science & technology.

[41]  M. Teixeira,et al.  Microcystins removal by nanofiltration membranes , 2005 .

[42]  F. Rosario‐Ortiz,et al.  Intracellular organic matter from cyanobacteria as a precursor for carbonaceous and nitrogenous disinfection byproducts. , 2013, Environmental science & technology.

[43]  H. Chu,et al.  Fouling effects of algogenic organic matters during nanofiltration of naproxen , 2014 .