Design and Fabrication of a Microfluidic Viscometer Based on Electrofluidic Circuits

This paper reports a microfluidic viscometer based on electrofluidic circuits for measuring viscosities of liquid samples. The developed micro-device consists of a polydimethylsiloxane (PDMS) layer for electrofluidic circuits, a thin PDMS membrane, another PDMS layer for sample pretreatment, and a glass substrate. As the sample flows inside the microfluidic channel, its viscosity causes flow resistance and a pressure drop along this channel. This pressure drop, in turn, generates a hydraulic pressure which deforms the PDMS membrane, causing changes in the cross-sectional area and the electrical resistance of the electrofluidic resistor. This small resistance change is then measured via the electrofluidic Wheatstone bridge to relate the measured voltage difference to the fluidic viscosity. The performance of this viscometer was first tested by flowing nitrogen gas with controllable pressures into the device. The relationship between measured voltage difference and input gas pressure was analyzed to be linear in the pressure range of 0–15 psi. Another test using pure water indicated good linearity between measured voltage difference and flow rate in the rate range of 20–100 μL/min. Viscosities of glycerol/water solutions with volume/volume (v/v) concentrations ranging from 0 to 30% were measured, and these values were close to those obtained using commercially available viscometers. In addition, the sample-pretreatment layer can be used to mix and/or dilute liquid samples to desired concentrations. Therefore, this microfluidic device has potential for measurements of fluidic viscosity in a fast, accurate, and high-throughput manner.

[1]  Paolo F Maccarini,et al.  The impact of temperature and urinary constituents on urine viscosity and its relevance to bladder hyperthermia treatment , 2013, International journal of hyperthermia : the official journal of European Society for Hyperthermic Oncology, North American Hyperthermia Group.

[2]  Xiaoju Tang,et al.  A PDMS viscometer for microliter Newtonian fluid , 2007 .

[3]  Deepak E. Solomon,et al.  Multiplexed microfluidic viscometer for high-throughput complex fluid rheology , 2014 .

[4]  Wei-Hao Liao,et al.  Integrated ionic liquid-based electrofluidic circuits for pressure sensing within polydimethylsiloxane microfluidic systems. , 2011, Lab on a chip.

[5]  Yeng-Long Chen,et al.  Electrofluidic Circuit-Based Microfluidic Viscometer for Analysis of Newtonian and Non-Newtonian Liquids under Different Temperatures. , 2018, Analytical chemistry.

[6]  K. Shadan,et al.  Available online: , 2012 .

[7]  Mark A Burns,et al.  Analysis of non-Newtonian liquids using a microfluidic capillary viscometer. , 2006, Analytical chemistry.

[8]  Ji-Yen Cheng,et al.  Use microfluidic chips to study the effects of ultraviolet lights on human fibroblasts , 2017 .

[9]  Yi-Chung Tung,et al.  Integrated electrofluidic circuits: pressure sensing with analog and digital operation functionalities for microfluidics. , 2012, Lab on a chip.

[10]  N. Cheng.  Formula for the Viscosity of a Glycerol−Water Mixture , 2008 .

[11]  S. Shippy,et al.  Development of a simple droplet-based microfluidic capillary viscometer for low-viscosity Newtonian fluids. , 2015, Analytical chemistry.

[12]  Kai-Yin Lo,et al.  Effects of shear stresses and antioxidant concentrations on the production of reactive oxygen species in lung cancer cells. , 2013, Biomicrofluidics.

[13]  Thomas Gervais,et al.  Flow-induced deformation of shallow microfluidic channels. , 2006, Lab on a chip.

[14]  Yasuyuki Yamamoto,et al.  Self-excited vibrational viscometer for high-viscosity sensing , 2014 .

[15]  Ryutaro Maeda,et al.  A polydimethylsiloxane (PDMS) deformable diffraction grating for monitoring of local pressure in microfluidic devices , 2002 .

[16]  Josefa Fernández,et al.  Compressibilities and viscosities of reference and vegetable oils for their use as hydraulic fluids and lubricants , 2011 .

[17]  K. Sakai,et al.  Electromagnetically Spinning Sphere Viscometer , 2010 .

[18]  Yi-Chung Tung,et al.  Electrofluidic pressure sensor embedded microfluidic device: a study of endothelial cells under hydrostatic pressure and shear stress combinations. , 2013, Lab on a chip.

[19]  J. Segovia,et al.  Densities, viscosities, and isobaric heat capacities of the system (1-butanol + cyclohexane) at high pressures , 2014 .

[20]  J. Carlos Gómez-Blanco,et al.  Fluid Structural Analysis of Urine Flow in a Stented Ureter , 2016, Comput. Math. Methods Medicine.

[21]  Shaoxi Cai,et al.  A novel polydimethylsiloxane microfluidic viscometer fabricated using microwire-molding. , 2015, The Review of scientific instruments.

[22]  M. Almasi.  Temperature dependence and chain length effect on density and viscosity of binary mixtures of nitrobenzene and 2-alcohols , 2015 .

[23]  Francesco A Aprile,et al.  Microfluidic Diffusion Viscometer for Rapid Analysis of Complex Solutions. , 2016, Analytical chemistry.

[24]  Seung Bae Lee,et al.  Analysis of Urine Flow in Three Different Ureter Models , 2017, Comput. Math. Methods Medicine.

[25]  Mark A Burns,et al.  Viscosity Measurements Using Microfluidic Droplet Length. , 2017, Analytical chemistry.

[26]  Yongming Hu,et al.  Self-Powered Viscosity and Pressure Sensing in Microfluidic Systems Based on the Piezoelectric Energy Harvesting of Flowing Droplets. , 2017, ACS applied materials & interfaces.

[27]  J. Josserand,et al.  Mixing processes in a zigzag microchannel: finite element simulations and optical study. , 2002, Analytical chemistry.

[28]  Mark A Burns,et al.  Nanoliter viscometer for analyzing blood plasma and other liquid samples. , 2005, Analytical chemistry.

[29]  Akio Funakubo,et al.  Blood viscometer applying electromagnetically spinning method , 2013, Journal of Artificial Organs.

[30]  S. Vanapalli,et al.  Microfluidic viscometers for shear rheology of complex fluids and biofluids. , 2016, Biomicrofluidics.

[31]  N. Jeon,et al.  Biological applications of microfluidic gradient devices. , 2010, Integrative biology : quantitative biosciences from nano to macro.

[32]  Yang Jun Kang,et al.  Integrated microfluidic viscometer equipped with fluid temperature controller for measurement of viscosity in complex fluids , 2013 .

[33]  Jia-Kun Chen,et al.  Electroosmotic flow mixing in zigzag microchannels , 2007, Electrophoresis.

[34]  Kai-Yin Lo,et al.  A microfluidic device for studying the production of reactive oxygen species and the migration in lung cancer cells under single or coexisting chemical/electrical stimulation , 2016 .