A Novel Fuel Performance Index for Low-Temperature Combustion Engines Based on Operating Envelopes in Light-Duty Driving Cycle Simulations

Low-temperature combustion (LTC) engine concepts such as homogeneous charge compression ignition (HCCI) offer the potential of improved efficiency and reduced emissions of nitrogen oxide (NOx) and particulates. However, engines can only successfully operate in HCCI mode for limited operating ranges that vary depending on the fuel composition. Unfortunately, traditional ratings such as octane number (ON) poorly predict the auto-ignition behavior of fuels in such engine modes, and metrics recently proposed for HCCI engines have areas of improvement when wide ranges of fuels are considered. In this study, a new index for ranking fuel suitability for LTC engines was defined, based on the fraction of potential fuel savings achieved in the federal test procedure (FTP-75) light-duty vehicle driving cycle. Driving cycle simulations were performed using a typical light-duty passenger vehicle, providing pairs of engine speed and load points. Separately, single-zone naturally aspirated HCCI engine simulations were performed for a variety of fuels in order to determine the operating envelopes for each. These results were combined to determine the varying improvement in fuel economy offered by fuels, forming the basis for a fuel performance index. Results showed that, in general, lower octane fuels performed better, resulting in higher LTC fuel index values; however, ON alone did not predict fuel performance.

[1]  Erik Hellström,et al.  Influence of transitions between SI and HCCI combustion on driving cycle fuel consumption , 2013, 2013 European Control Conference (ECC).

[2]  Robert M. Wagner,et al.  DRIVE CYCLE EFFICIENCY AND EMISSIONS ESTIMATES FOR REACTIVITY CONTROLLED COMPRESSION IGNITION IN A MULTI-CYLINDER LIGHT-DUTY DIESEL ENGINE , 2011 .

[3]  Robert W. Dibble,et al.  Predicting Fuel Performance for Future HCCI Engines , 2013 .

[4]  Bengt Johansson,et al.  Demonstrating the Multi Fuel Capability of a Homogeneous Charge Compression Ignition Engine with Variable Compression Ratio , 1999 .

[5]  M. Zheng,et al.  Fuel suitability for low temperature combustion in compression ignition engines , 2013 .

[6]  J.-Y. Chen,et al.  Modeling of emissions from HCCI engines using a consistent 3-zone model with applications to validation of reduced chemistry , 2011 .

[7]  Daniel L. Flowers,et al.  An accelerated multi-zone model for engine cycle simulation of homogeneous charge compression ignition combustion , 2013 .

[8]  Scott B. Fiveland,et al.  Development of a Two-Zone HCCI Combustion Model Accounting for Boundary Layer Effects , 2001 .

[9]  Bertrand Lecointe,et al.  Impact of fuel characteristics on HCCI combustion: Performances and emissions , 2010 .

[10]  William H. Green,et al.  Prediction of the Knock Limit and Viable Operating Range for a Homogeneous-Charge Compression-Ignition (HCCI) Engine , 2003 .

[11]  Gen Shibata,et al.  Auto-Ignition Characteristics of Hydrocarbons and Development of HCCI Fuel Index , 2007 .

[12]  Aristotelis Babajimopoulos,et al.  A comprehensive engine to drive-cycle modelling framework for the fuel economy assessment of advanced engine and combustion technologies , 2012 .

[13]  Patrick G. Szymkowicz,et al.  Effects of Advanced Fuels on the Particulate and NOx Emissions from an Optimized Light-Duty CIDI Engine , 2001 .

[14]  S. H. Jo,et al.  Active Thermo-Atmosphere Combustion (ATAC) - A New Combustion Process for Internal Combustion Engines , 1979 .

[15]  Tony Markel,et al.  ADVISOR: A SYSTEMS ANALYSIS TOOL FOR ADVANCED VEHICLE MODELING , 2002 .

[16]  Robert W. Dibble,et al.  A Multi-Zone Model for Prediction of HCCI Combustion and Emissions , 2000 .

[17]  Hua Zhao,et al.  Performance and analysis of a 4-stroke multi-cylinder gasoline engine with CAI combustion , 2002 .

[18]  Donald J. Reilly,et al.  Saturn DOHC and SOHC Four Cylinder Engines , 1991 .

[19]  Mingfa Yao,et al.  Progress and recent trends in homogeneous charge compression ignition (HCCI) engines , 2009 .

[20]  D. Foster,et al.  Compression-Ignited Homogeneous Charge Combustion , 1983 .

[21]  Yukiyasu Tanaka,et al.  A Study on Gasoline Engine Combustion by Observation of Intermediate Reactive Products during Combustion , 1979 .

[22]  Mingfa Yao,et al.  Influence of Fuel and Operating Conditions on Combustion Characteristics of a Homogeneous Charge Compression Ignition Engine , 2009 .

[23]  C. S. Daw,et al.  A proposed methodology for estimating transient engine-out temperature and emissions from steady-state maps , 2010 .

[24]  Robert M. Wagner,et al.  Reactivity controlled compression ignition combustion on a multi-cylinder light-duty diesel engine , 2012 .

[25]  John B. Heywood,et al.  Internal combustion engine fundamentals , 1988 .

[26]  D. Splitter,et al.  Experiments and Modeling of Dual-Fuel HCCI and PCCI Combustion Using In-Cylinder Fuel Blending , 2009 .

[27]  William J. Pitz,et al.  Oxidation of automotive primary reference fuels at elevated pressures , 1999 .

[28]  David E. Smith,et al.  Simulating the impact of premixed charge compression ignition on light-duty diesel fuel economy and emissions of particulates and NOx , 2013 .

[29]  Timothy P. Gardner,et al.  Overall Results: Phase I Ad Hoc Diesel Fuel Test Program , 2001 .

[30]  D. Splitter,et al.  Fuel reactivity controlled compression ignition (RCCI): a pathway to controlled high-efficiency clean combustion , 2011 .

[31]  C. Westbrook,et al.  A Comprehensive Modeling Study of iso-Octane Oxidation , 2002 .

[32]  D. Splitter,et al.  Fuel reactivity effects on the efficiency and operational window of dual-fuel compression ignition engines , 2014 .

[33]  Sebastian Mosbach,et al.  HCCI Combustion Control Using Dual-Fuel Approach: Experimental and Modeling Investigations , 2012 .

[34]  K. B. Wipke,et al.  ADVISOR 2.1: a user-friendly advanced powertrain simulation using a combined backward/forward approach , 1999 .

[35]  William H. Green,et al.  Primary Reference Fuel Behavior in a HCCI Engine near the Low-Load Limit , 2008 .

[36]  William H. Green,et al.  PREDICTION OF PERFORMANCE MAPS FOR HOMOGENEOUS-CHARGE COMPRESSION-IGNITION ENGINES , 2004 .

[37]  Panos Y. Papalambros,et al.  Homogeneous charge compression ignition technology implemented in a hybrid electric vehicle: System optimal design and benefit analysis for a power-split architecture , 2013 .

[38]  Ali Emadi,et al.  Modeling and Simulation of Electric and Hybrid Vehicles , 2007, Proceedings of the IEEE.

[39]  William Cannella,et al.  HCCI Operability Limits: The Impact of Refinery Stream Gasoline Property Variation , 2012 .

[40]  Robert M. Wagner,et al.  Simulating Study of Premixed Charge Compression Ignition on Light-Duty Diesel Fuel Economy and Emissions Control , 2012 .

[41]  Gautam Kalghatgi,et al.  Auto-Ignition Quality of Practical Fuels and Implications for Fuel Requirements of Future SI and HCCI Engines , 2005 .

[42]  Tanet Aroonsrisopon,et al.  An Investigation Into the Effect of Fuel Composition on HCCI Combustion Characteristics , 2002 .

[43]  T. Tsurushima.  A new skeletal PRF kinetic model for HCCI combustion , 2009 .

[44]  Charles Robert Koch,et al.  The effect of fuel octane and dilutent on homogeneous charge compression ignition combustion , 2005 .

[45]  Fuquan Zhao,et al.  Homogeneous charge compression ignition (HCCI) engines : key research and development issues , 2003 .