Synthesis and surface acoustic wave properties of AlN films deposited on LiNbO/sub 3/ substrates

The c-axis-oriented aluminum nitride (AlN) films were deposited on z-cut lithium niobate (LiNbO/sub 3/) substrates by reactive RF magnetron sputtering. The crystalline orientation of the AlN film determined by x-ray diffraction (XRD) was found to be dependent on the deposition conditions such as substrate temperature, N/sub 2/ concentration, and sputtering pressure. Highly c-axis-oriented AlN films to fabricate the AlN/LiNbO/sub 3/-based surface acoustic wave (SAW) devices were obtained under a sputtering pressure of 3.5 mTorr, N/sub 2/ concentration of 60%, RF power of 165 W, and substrate temperature of 400/spl deg/C. A dense pebble-like surface texture of c-axis-oriented AlN film was obtained by scanning electron microscopy (SEM). The phase velocity and the electromechanical coupling coefficient (K/sup 2/) of SAW were measured to be about 4200 m/s and 1.5%, respectively. The temperature coefficient of frequency (TCF) of SAW was calculated to be about -66 ppm//spl deg/C.

[1]  Kenneth Meade Lakin,et al.  Low‐temperature coefficient bulk acoustic wave composite resonators , 1982 .

[2]  K. W. Hipps,et al.  Morphology and orientation of nanocrystalline AlN thin films , 1994 .

[3]  E. Lai,et al.  Growth of c-axis oriented aluminum nitride films on GaAs substrates by reactive rf magnetron sputtering , 1998 .

[4]  D. Búc,et al.  Reactive unbalanced magnetron sputtering of AIN thin films , 1998 .

[5]  D. Karpuzov,et al.  Investigation of d.c.-reactive magnetron-sputtered AlN thin films by electron microprobe analysis, X-ray photoelectron spectroscopy and polarised infra-red reflection , 1998 .

[6]  Jai-Young Lee,et al.  Characteristics of hydrogenated aluminum nitride films prepared by radio frequency reactive sputtering and their application to surface acoustic wave devices , 1997 .

[7]  G. Eesley,et al.  Measurement of intrinsic stresses during growth of aluminum nitride thin films by reactive sputter deposition , 1993 .

[8]  K. Kao,et al.  PIEZOELECTRIC, DIELECTRIC, AND INTERFACIAL PROPERTIES OF ALUMINUM NITRIDE FILMS , 1998 .

[9]  J. W. Rogers,et al.  Initial stages of AlN thin‐film growth on alumina using trimethylamine alane and ammonia precursors , 1994 .

[10]  K. Wang,et al.  Aluminum Nitride on Sapphire , 1974 .

[11]  H. M. Liaw,et al.  The characterization of sputtered polycrystalline aluminum nitride on silicon by surface acoustic wave measurements , 1995, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[12]  Dao Wang,et al.  Structures and Electric Characteristics of Al–N Thin Films Prepared by RF Sputtering , 1997 .

[13]  H. Okano,et al.  Preparation of c-Axis Oriented AlN Thin Films by Low-Temperature Reactive Sputtering , 1992 .

[14]  K. Tsubouchi,et al.  Zero-Temperature-Coefficient SAW Devices on AlN Epitaxial Films , 1985, IEEE Transactions on Sonics and Ultrasonics.

[15]  Akira Kawabata,et al.  Low‐temperature growth of piezoelectric AlN film by rf reactive planar magnetron sputtering , 1980 .

[16]  H. Pulker,et al.  Properties of reactively d.c.-magnetron-sputtered A1N thin films , 1993 .

[17]  Y. Ishikawa,et al.  Growth of Aluminum Nitride Films on Silicon by Electron-Cyclotron-Resonance-Assisted Molecular Beam Epitaxy , 1992 .

[18]  B. Aspar,et al.  Influence of the experimental conditions on the morphology of CVD AIN films , 1993 .

[19]  K. Shibata,et al.  Preparation of aluminum nitride thin films by reactive sputtering and their applications to GHz‐band surface acoustic wave devices , 1994 .

[20]  K. Nonaka,et al.  Statistical approach for optimizing sputtering conditions of highly oriented aluminum nitride thin films , 1998 .

[21]  E. Monroy,et al.  GROWTH KINETICS AND MORPHOLOGY OF HIGH QUALITY ALN GROWN ON SI(111) BY PLASMA-ASSISTED MOLECULAR BEAM EPITAXY , 1997 .

[22]  T. Hirai,et al.  Synthesis and Surface Acoustic Wave Properties of AlN Thin Films Fabricated on (001) and (110) Sapphire Substrates Using Chemical Vapor Deposition of AlCl3–NH3 System , 1997 .

[23]  H. Okano,et al.  Orientation Control of AlN Film by Electron Cyclotron Resonance Ion Beam Sputtering , 1992 .

[24]  Proton-exchanged Z-cut LiNbO/sub 3/ waveguides for surface acoustic waves , 1996 .

[25]  A. J. Shuskus,et al.  rf‐sputtered aluminum nitride films on sapphire , 1974 .

[26]  W. Westwood,et al.  Stress control in reactively sputtered AlN and TiN films , 1987 .

[27]  M. Niigaki,et al.  Growth of AlN films by magnetron sputtering , 1998 .

[28]  Sunil Kumar,et al.  Low-Temperature Growth and Measurement of Oxygen in Reactively Sputtered AlN Thin Films , 1995 .

[29]  S. Oktyabrsky,et al.  Characteristics of stacking faults in AlN thin films , 1997 .

[30]  R. Beresford,et al.  Demonstration of a silicon field‐effect transistor using AlN as the gate dielectric , 1995 .

[31]  Kazuo Tsubouchi,et al.  AlN Material Constants Evaluation and SAW Properties on AlN/Al 2 O 3 and AlN/Si , 1981 .

[32]  Bai-xin Liu,et al.  Polycrystalline AlN films of fine crystallinity prepared by ion‐beam assisted deposition , 1993 .

[33]  Y. Ide,et al.  Control of preferential orientation of AlN films prepared by the reactive sputtering method , 1998 .

[34]  R. Vispute,et al.  High quality epitaxial aluminum nitride layers on sapphire by pulsed laser deposition , 1995 .

[35]  Wen-Tai Lin,et al.  Epitaxial growth of cubic AlN films on (100) and (111) silicon by pulsed laser ablation , 1995 .

[36]  H. Okano,et al.  Characteristics of Surface Acoustic Wave on AlN Thin Films , 1995 .