Importance of feed recirculation for the overall energy consumption in membrane distillation systems

Abstract Membrane distillation (MD) has received significant interest for treating high salinity wastewaters, particularly when reverse osmosis is not feasible. MD has low single pass water recovery, which necessitates feed recirculation to achieve a desired overall water recovery. Feed recirculation increases turbulence in the feed channel to reduce polarization effects and membrane fouling. However, it increases the thermal and electrical energy requirements of the system. This study emphasizes the importance of recirculation and demonstrates its impact on the energy consumption of MD, which can be an order of magnitude greater when compared with calculations based on a single pass recovery. For instance, an increase in water recovery in a DCMD module from 10 to 50% for a feed solution containing 100 g/L of NaCl would increase the required recycle ratio by 633% (i.e., from 3 to 22) with a corresponding increase in thermal energy required to heat the recycle stream by 556% (i.e., from 39 to 256 kWh/m3 of feed). While the electrical energy required for feed recirculation is only a few percent of thermal energy requirements, it may be a significant factor when considering the overall life cycle impacts of the MD process.

[1]  John H. Lienhard,et al.  Simple method for balancing direct contact membrane distillation , 2016 .

[2]  Andrzej G. Chmielewski,et al.  Concentration of radioactive components in liquid low-level radioactive waste by membrane distillation , 1999 .

[3]  V. M. Nikulin,et al.  Treatment of waste water for removing heavy metals by membrane distillation , 1994 .

[4]  Nidal Hilal,et al.  Concentration of apple juice using direct contact membrane distillation , 2006 .

[5]  Guangzhi Zuo,et al.  Energy efficiency evaluation and economic analyses of direct contact membrane distillation system using Aspen Plus , 2011 .

[6]  Omkar R. Lokare,et al.  Laboratory and Pilot-Scale Nanofiltration Treatment of Abandoned Mine Drainage for the Recovery of Products Suitable for Industrial Reuse , 2017 .

[7]  Mikel Duke,et al.  Integration of membrane distillation into heat paths of industrial processes , 2012 .

[8]  M. Gryta,et al.  Study on the concentration of acids by membrane distillation , 1995 .

[9]  Enrico Drioli,et al.  Membrane distillation-crystallization of seawater reverse osmosis brines , 2010 .

[10]  Hongwei Fan,et al.  Application of PVDF membranes in desalination and comparison of the VMD and DCMD processes , 2012 .

[11]  Tieyuan Zhang,et al.  Origin and fate of radium in flowback and produced water from Marcellus Shale gas exploration , 2015 .

[12]  M. Qtaishat,et al.  Heat and mass transfer analysis in direct contact membrane distillation , 2008 .

[13]  Ying Xu,et al.  Pilot test of vacuum membrane distillation for seawater desalination on a ship , 2006 .

[14]  E. Drioli,et al.  Potential of membrane distillation in seawater desalination: Thermal efficiency, sensitivity study and cost estimation , 2008 .

[15]  Liming Song,et al.  Pilot plant studies of novel membranes and devices for direct contact membrane distillation-based desalination , 2008 .

[16]  Omkar R. Lokare,et al.  Fouling in direct contact membrane distillation of produced water from unconventional gas extraction , 2017 .

[17]  Ludovic F. Dumée,et al.  Advances in Membrane Distillation for Water Desalination and Purification Applications , 2013 .

[18]  S. T. Hsu,et al.  Seawater desalination by direct contact membrane distillation , 2002 .

[19]  S. Adham,et al.  Field evaluation of membrane distillation followed by humidification/dehumidification crystallizer for inland desalination of saline groundwater , 2016 .

[20]  L. Martinez-diez,et al.  A method to evaluate coefficients affecting flux in membrane distillation , 2000 .

[21]  Tzahi Y. Cath,et al.  Experimental study of desalination using direct contact membrane distillation: a new approach to flux enhancement , 2004 .

[22]  Julián Blanco,et al.  Experimental analysis of an air gap membrane distillation solar desalination pilot system , 2011 .

[23]  Maria Vahdati,et al.  Improved process topology for membrane distillation , 2001 .

[24]  Rong Wang,et al.  Evaluation of heat utilization in membrane distillation desalination system integrated with heat recovery , 2015 .

[25]  Radisav D. Vidic,et al.  Integrating membrane distillation with waste heat from natural gas compressor stations for produced water treatment in Pennsylvania , 2017 .

[26]  Enrico Drioli,et al.  Evaluation of energy requirements in membrane distillation , 2008 .

[27]  Anthony G. Fane,et al.  The efficient use of energy in membrane distillation , 1987 .

[28]  Jun-de Li,et al.  Modelling heat and mass transfers in DCMD using compressible membranes , 2012 .

[29]  Subrata Mondal,et al.  Produced water treatment by nanofiltration and reverse osmosis membranes , 2008 .

[30]  Enrico Drioli,et al.  Theoretical and Experimental Study on Membrane Distillation in the Concentration of Orange Juice , 1994 .

[31]  Jack Gilron,et al.  Design for Cascade of Crossflow Direct Contact Membrane Distillation , 2007 .

[32]  Allan R. Chivas,et al.  Treatment of RO brine from CSG produced water by spiral-wound air gap membrane distillation — A pilot study , 2015 .

[33]  Fawzi Banat,et al.  Desalination by Membrane Distillation: A Parametric Study , 1998 .

[34]  Menachem Elimelech,et al.  Direct contact membrane distillation with heat recovery: Thermodynamic insights from module scale modeling , 2014 .

[35]  M. Khayet,et al.  Experimental and theoretical investigations on water desalination using direct contact membrane distillation , 2017 .

[36]  S. Adham,et al.  Treatment of Produced Water from Unconventional Resources by Membrane Distillation , 2014 .

[37]  Isabel M. Coelhoso,et al.  Orange juice concentration by osmotic evaporation and membrane distillation: A comparative study , 2006 .

[38]  C. W. Leung,et al.  Theoretical and experimental studies on air gap membrane distillation , 1998 .

[39]  Jack Gilron,et al.  Desalination with a Cascade of Cross-Flow Hollow Fiber Membrane Distillation Devices Integrated with a Heat Exchanger , 2011 .

[40]  A. E. Jansen,et al.  Development and pilot testing of full-scale membrane distillation modules for deployment of waste heat , 2013 .

[41]  M. Khayet.  Membranes and theoretical modeling of membrane distillation: a review. , 2011, Advances in colloid and interface science.

[42]  Yoram Cohen,et al.  High-recovery reverse osmosis desalination using intermediate chemical demineralization , 2007 .

[43]  Yingjin Yuan,et al.  A continuous‐effect membrane distillation process based on hollow fiber AGMD module with internal latent‐heat recovery , 2013 .