Turbulence modelling of low Reynolds number flow effects around a vertical axis turbine at a range of tip-speed ratios

Abstract This paper presents a two-dimensional numerical investigation of a vertical axis turbine with focus on the prediction from two different turbulence modelling schemes. The three bladed turbine configuration tested is that of Roa et al. (2010) which has a high solidity of 1.1 and is tested at a chord-based Reynolds number of 1.5 × 105. Results are provided at three different tip speed ratios: the optimal value, and values 25% higher and lower. A detailed investigation of the flow ensues and results are presented as obtained from the original SST model and a modified version for low Reynolds number effects, recently tested by Wang et al. (2010) for a similar flow. Post-processing includes the evolution of the skin-friction coefficient over the blade throughout a cycle which enables a better understanding of the flow structure and the dynamic stall effects, as well as blade–vortex interaction. The low Reynolds number version of the model acts to reduce turbulence viscosity, leading to laminar flow at various parts of the cycle, which is seen to correctly enable the formation of leading edge vortices observed in the literature.

[1]  Tim Lee,et al.  Investigation of flow over an oscillating airfoil , 2004, Journal of Fluid Mechanics.

[2]  Shengyi Wang,et al.  Numerical investigations on dynamic stall of low Reynolds number flow around oscillating airfoils , 2010 .

[3]  Carlos Simao Ferreira,et al.  2D CFD Simulation of Dynamic Stall on a Vertical Axis Wind Turbine: Verification and Validation with PIV Measurements , 2007 .

[4]  D. Wilcox.  Reassessment of the scale-determining equation for advanced turbulence models , 1988 .

[5]  B. Launder,et al.  Application of the energy-dissipation model of turbulence to the calculation of flow near a spinning disc , 1974 .

[6]  Thierry Maître,et al.  Modeling of the flow in a Darrieus water turbine: Wall grid refinement analysis and comparison with experiments , 2013 .

[7]  Peter Stansby,et al.  A simple sliding‐mesh interface procedure and its application to the CFD simulation of a tidal‐stream turbine , 2014 .

[8]  C. Rhie,et al.  Numerical Study of the Turbulent Flow Past an Airfoil with Trailing Edge Separation , 1983 .

[9]  A. Elmiligui,et al.  Numerical Study of Flow Past a Circular Cylinder Using RANS, Hybrid RANS/LES and PANS Formulations , 2004 .

[10]  Ning Qin,et al.  Wind tunnel and numerical study of a small vertical axis wind turbine , 2008 .

[11]  J. Achard,et al.  2D Numerical Simulations of Blade-Vortex Interaction in a Darrieus Turbine , 2009 .

[12]  Werner Haase,et al.  Progress in computational flow-structure interaction : results of the project UNSI, supported by the European Union 1998-2000 , 2003 .

[13]  W. Jones,et al.  The prediction of laminarization with a two-equation model of turbulence , 1972 .

[14]  M. Leschziner,et al.  Modelling Bypass Transition with Low-Reynolds-Number Nonlinear Eddy-Viscosity Closure , 2004 .

[15]  Thierry Maître,et al.  Numerical and experimental analysis of a darrieus-type cross flow water turbine in bare and shrouded configurations , 2010 .

[16]  David C. Wilcox,et al.  The remarkable ability of turbulence model equations to describe transition , 1992 .

[17]  S. Orszag,et al.  Development of turbulence models for shear flows by a double expansion technique , 1992 .

[18]  F. Archambeau,et al.  Code Saturne: A Finite Volume Code for the computation of turbulent incompressible flows - Industrial Applications , 2004 .

[19]  K. Chien,et al.  Predictions of Channel and Boundary-Layer Flows with a Low-Reynolds-Number Turbulence Model , 1982 .

[20]  C. Moulinec,et al.  Optimizing Code_Saturne computations on Petascale systems , 2011 .

[21]  Arne V. Johansson,et al.  An explicit algebraic Reynolds stress model for incompressible and compressible turbulent flows , 2000, Journal of Fluid Mechanics.

[22]  Flavien Billard,et al.  A robust k − ε − v2¯/k elliptic blending turbulence model applied to near-wall, separated and buoyant flows , 2012 .

[23]  Chao Li,et al.  2.5D large eddy simulation of vertical axis wind turbine in consideration of high angle of attack flow , 2013 .

[24]  P. Spalart.  A One-Equation Turbulence Model for Aerodynamic Flows , 1992 .

[25]  X. Q. Wang,et al.  Dynamic stall behavior from unsteady force measurements , 2008 .

[26]  Yannick Hoarau,et al.  Turbulence modelling of the flow past a pitching NACA0012 airfoil at 105 and 106 Reynolds numbers , 2008 .