Experimental study of TiO2–water nanofluid flow and heat transfer characteristics in a multiport minichannel flat tube

Abstract This study experimentally investigated TiO 2 –water nanofluid single-phase flow and heat transfer characteristics in a multiport minichannel flat tube with a 1.65 mm hydraulic diameter. TiO 2 nanoparticles with nominal diameters of 10, 30, and 50 nm were dispersed in water at various volume concentrations ranging from 0.005% to 1%. The friction factor and Nusselt number of the nanofluids were tested and compared with those of the base fluid, the Reynolds number of which varied from 100 to 6100. Results indicated that friction factor and Nusselt number of the nanofluids were higher than those of water. Both nanofluid density and particle migration significantly affected friction factor. Meanwhile, a slightly earlier laminar-turbulent transition was found for the nanofluids. Nu did not increase with increasing volume concentration and decreased with increasing particle diameter ( d p ). The effects of thermal conductivity, viscosity, and chaotic movement of nanoparticles on heat transfer were discussed in this study. Nanofluids at 0.01% concentration with d p  = 10 nm exhibited the best performance on the basis of the evaluation criterion, which considered heat transfer enhancement at the consequence of increased friction factor.

[1]  Rouhollah Bagheri,et al.  Experimental heat transfer of nanofluid through an annular duct , 2011 .

[2]  Xianfan Xu,et al.  Thermal Conductivity of Nanoparticle -Fluid Mixture , 1999 .

[3]  T. Ala‐Nissila,et al.  Influence of particle size and shape on turbulent heat transfer characteristics and pressure losses in water-based nanofluids , 2013 .

[4]  A. Bontemps,et al.  Effects of Geometrical and Thermophysical Parameters on Heat Transfer Measurements in Small-Diameter Channels , 2006 .

[5]  J. Eastman,et al.  Measuring Thermal Conductivity of Fluids Containing Oxide Nanoparticles , 1999 .

[6]  R. Shah,et al.  Handbook of single-phase convective heat transfer , 1987 .

[7]  Young I Cho,et al.  HYDRODYNAMIC AND HEAT TRANSFER STUDY OF DISPERSED FLUIDS WITH SUBMICRON METALLIC OXIDE PARTICLES , 1998 .

[8]  W. Roetzel,et al.  TEMPERATURE DEPENDENCE OF THERMAL CONDUCTIVITY ENHANCEMENT FOR NANOFLUIDS , 2003 .

[9]  Dong Liu,et al.  Single-Phase Thermal Transport of Nanofluids in a Minichannel , 2011 .

[10]  William W. Yu,et al.  ANOMALOUSLY INCREASED EFFECTIVE THERMAL CONDUCTIVITIES OF ETHYLENE GLYCOL-BASED NANOFLUIDS CONTAINING COPPER NANOPARTICLES , 2001 .

[11]  Jeff Punch,et al.  Friction factor and heat transfer in multiple microchannels with uniform flow distribution , 2008 .

[12]  Stephen U. S. Choi.  Enhancing thermal conductivity of fluids with nano-particles , 1995 .

[13]  B. Sahin,et al.  Experimental investigation of heat transfer and pressure drop characteristics of Al2O3–water nanofluid , 2013 .

[14]  Saeed Zeinali Heris,et al.  Experimental investigation of oxide nanofluids laminar flow convective heat transfer , 2006 .

[15]  S. Wongwises,et al.  An experimental study on the heat transfer performance and pressure drop of TiO2-water nanofluids flowing under a turbulent flow regime , 2010 .

[16]  Yulong Ding,et al.  Experimental investigation into convective heat transfer of nanofluids at the entrance region under laminar flow conditions , 2004 .

[17]  Haisheng Chen,et al.  Heat transfer and flow behaviour of aqueous suspensions of TiO2 nanoparticles (nanofluids) flowing upward through a vertical pipe , 2007 .

[18]  W. Chen,et al.  An experimental study on thermal performance of Al2O3/water nanofluid in a minichannel heat sink , 2013 .

[19]  R. Shah.  Laminar Flow Forced convection in ducts , 1978 .

[20]  Jules Thibault,et al.  Convective heat transfer of non-Newtonian nanofluids through a uniformly heated circular tube , 2011 .

[21]  K. V. Sharma,et al.  Experimental investigation of forced convection heat transfer and friction factor in a tube with Fe3O4 magnetic nanofluid , 2012 .

[22]  Yulong Ding,et al.  Particle migration in a flow of nanoparticle suspensions , 2005 .

[23]  V. Gnielinski.  New equations for heat and mass transfer in turbulent pipe and channel flow , 1976 .

[24]  Y. Xuan,et al.  Investigation on Convective Heat Transfer and Flow Features of Nanofluids , 2003 .

[25]  Debjyoti Banerjee,et al.  Experimental study of forced convective heat transfer of nanofluids in a microchannel , 2012 .

[26]  Yulong Ding,et al.  Heat transfer of aqueous suspensions of carbon nanotubes (CNT nanofluids) , 2006 .

[27]  Farshad Kowsary,et al.  Experimental study of convective heat transfer and pressure drop of TiO2/water nanofluid☆ , 2012 .

[28]  Y. Xuan,et al.  Convective heat transfer and flow characteristics of Cu-water nanofluid , 2002, Science China Technological Sciences.

[29]  Wenhua Yu,et al.  The Role of Interfacial Layers in the Enhanced Thermal Conductivity of Nanofluids: A Renovated Maxwell Model , 2003 .

[30]  Seok Pil Jang,et al.  Flow and convective heat transfer characteristics of water-based Al2O3 nanofluids in fully developed laminar flow regime , 2009 .

[31]  W. Roetzel,et al.  Conceptions for heat transfer correlation of nanofluids , 2000 .

[32]  Karl Stephan,et al.  Wärmeübergang und maximale Wärmestromdichte beim Behältersieden binärer und ternärer Flüssigkeitsgemische , 1979 .

[33]  Wei Liu,et al.  Enhancing heat transfer in the core flow by using porous medium insert in a tube , 2010 .

[34]  Ali Akbar Abbasian Arani,et al.  Experimental investigation of diameter effect on heat transfer performance and pressure drop of TiO2–water nanofluid , 2013 .

[35]  Sarit K. Das,et al.  Effect of particle size on the convective heat transfer in nanofluid in the developing region , 2009 .

[36]  M. Esfahany,et al.  Experimental study of turbulent convective heat transfer and pressure drop of dilute CuO/water nanofluid inside a circular tube , 2010 .

[37]  F. White.  Viscous Fluid Flow , 1974 .

[38]  G. Batchelor.  The effect of Brownian motion on the bulk stress in a suspension of spherical particles , 1977, Journal of Fluid Mechanics.