Transport analysis of air-gap membrane distillation

The air gap membrane distillation process has been modeled as a two-dimensional conjugate problem in which a simultaneous numerical solution of the momentum, energy and diffusion equations of the feed and cold solutions have been carried out. The results were validated in comparison with available experimental results. The modeling and sensitivity analyses provide useful basic detailed information about the nature of the process, and are helpful for process improvement and optimization. Some of the principal conclusions are: (1) the air/vapor gap has the major role in reducing the parasitic heat loss in the process, (2) the gap width has an important effect: decreasing it five-fold increases the permeate flux 2.6-fold, but the thermal efficiency improves only slightly because the conductive heat loss increases too, (3) increasing the inlet temperature of the hot solution has a major effect on the permeate flux and also increase the thermal efficiency, while decreasing the coolant temperature has a lesser effect on the flux increase, and even slightly reduces the efficiency, (4) the feedwater salt concentration has a very small effect on the permeate flux and thermal efficiency, (5) the inlet velocities of the hot and cold solutions have a relatively small effect, (6) reducing the thermal conductivity of the membrane material improves the process thermal efficiency somewhat, and the permeate flux more strongly.

[1]  Ratana Jiraratananon,et al.  Direct contact membrane distillation: effect of mass transfer on heat transfer , 2001 .

[2]  Mohamed Khayet,et al.  Nature of flow on sweeping gas membrane distillation , 2000 .

[3]  Ashley F. Emery,et al.  Free Convection Through Vertical Plane Layers—Moderate and High Prandtl Number Fluids , 1969 .

[4]  George L. Pickard,et al.  CHAPTER THREE – Physical Properties of Sea-Water , 1982 .

[5]  Noam Lior,et al.  Membrane-distillation desalination: Status and potential , 2005 .

[6]  J. M. Coulson,et al.  Heat Transfer , 2018, Finite Element Method for Solids and Structures.

[7]  Allen M. Rowe,et al.  Enthalpies of aqueous sodium chloride solutions from 32 to 350°F , 1969 .

[8]  Giulio C. Sarti,et al.  Separation efficiency in vacuum membrane distillation , 1992 .

[9]  Shoji Kimura,et al.  Transport phenomena in membrane distillation , 1987 .

[10]  Giulio C. Sarti,et al.  Low energy cost desalination processes using hydrophobic membranes , 1985 .

[11]  A. F. Mills.  Basic Heat and Mass Transfer , 1999 .

[12]  Giulio C. Sarti,et al.  Extraction of organic components from aqueous streams by vacuum membrane distillation , 1993 .

[13]  D. R. Lloyd,et al.  Membrane distillation. II. Direct contact MD , 1996 .

[14]  Mohamed Khayet,et al.  Theory and experiments on sweeping gas membrane distillation , 2000 .

[15]  Chen Huanlin,et al.  Review of membrane distillation , 2007 .

[16]  Sankichi Takahashi,et al.  Vapor Permeate Characteristics of Membrane Distillation , 1990 .

[17]  A. B. Haan,et al.  Modelling of a transmembrane evaporation module for desalination of seawater , 1999 .

[18]  Giulio C. Sarti,et al.  A desalination process through sweeping gas membrane distillation , 1987 .

[19]  S F Chen,et al.  Viscosity of sea water solutions , 1973 .

[20]  T. Hodgkiess,et al.  Membrane distillation - an assessment , 1985 .

[21]  R. Chouikh,et al.  Numerical study of the coupled heat and mass transfer in membrane distillation , 2003 .

[22]  F. J. Florido-Díaz,et al.  Theoretical and experimental studies on desalination using membrane distillation , 2001 .

[23]  G. Wytze Meindersma,et al.  Modelling temperature and salt concentration distribution in membrane distillation feed channel , 2003 .

[24]  M. C. García-Payo,et al.  Separation of binary mixtures by thermostatic sweeping gas membrane distillation: I. Theory and simulations , 2002 .

[25]  C. W. Leung,et al.  Theoretical and experimental studies on air gap membrane distillation , 1998 .

[26]  Giulio C. Sarti,et al.  Role of heat and mass transfer in membrane distillation process , 1991 .

[27]  Roland Wimmerstedt,et al.  Membrane distillation - a theoretical study of evaporation through microporous membranes , 1985 .

[28]  H. G. Drickamer.  The Properties of Gases and Liquids. Their Estimation and Correlation. , 1958 .

[29]  D. T. Jamieson,et al.  Physical properties of sea water solutions: thermal conductivity , 1970 .

[30]  Anthony G. Fane,et al.  Heat and mass transfer in membrane distillation , 1987 .

[31]  M. C. García-Payo,et al.  Separation of binary mixtures by thermostatic sweeping gas membrane distillation: II. Experimental results with aqueous formic acid solutions , 2002 .