In situ visualization of the performance of a supercritical-water salt separator using neutron radiography

Abstract Salt separation from supercritical water has been identified as a key issue in the deployment of supercritical-water technologies, particularly in the supercritical-water gasification of biomass. In order to better understand salt separation, neutron radiography has been employed to allow visualization of the transport phenomena associated with the separation of salt from supercritical D2O in a reverse-flow vessel. D2O was used as a surrogate for H2O because of its low neutron-attenuation coefficient and similar physical properties. Salts that formed a brine as a second phase, such as Na2B4O7 and K3PO4, performed well in the separator. Na2SO4, which forms a solid precipitate, created more issues and caused blockage of the separator under certain conditions.

[1]  G. Jacobs,et al.  Supercritical water oxidation: An emerging technology , 1992 .

[2]  M. Urquidi-Macdonald,et al.  The electrochemistry of zirconium in aqueous solutions at elevated temperatures and pressures , 2006 .

[3]  P. Vontobel,et al.  PROPERTIES OF THE RADIOGRAPHY FACILITY NEUTRA AT SINQ AND ITS POTENTIAL FOR USE AS EUROPEAN REFERENCE FACILITY , 2001 .

[4]  Andrei V. Bandura,et al.  The Ionization Constant of Water over Wide Ranges of Temperature and Density , 2006 .

[5]  F. Krumeich,et al.  Synthetic natural gas by hydrothermal gasification of biomass: Selection procedure towards a stable catalyst and its sodium sulfate tolerance , 2007 .

[6]  W. Wagner,et al.  The IAPWS Formulation 1995 for the Thermodynamic Properties of Ordinary Water Substance for General and Scientific Use , 2002 .

[7]  Jefferson W. Tester,et al.  Solubility of sodium chloride and sulfate in sub- and supercritical water vapor from 450–550°C and 100–250 bar , 1993 .

[8]  Kenneth A. Smith,et al.  Salt precipitation and scale control in supercritical water oxidation—Part A: fundamentals and research , 2004 .

[9]  F. J. Armellini,et al.  Experimental methods for studying salt nucleation and growth from supercritical water , 1991 .

[10]  E. Gloyna,et al.  Solubility of potassium hydroxide and potassium phosphate in supercritical water , 1995 .

[11]  Kenneth A. Smith,et al.  Salt precipitation and scale control in supercritical water oxidation—part B: commercial/full-scale applications , 2004 .

[12]  M. Waldner,et al.  Renewable Production of Methane from Woody Biomass by Catalytic Hydrothermal Gasification , 2005 .

[13]  Jefferson W. Tester,et al.  Ternary phase equilibria for the sodium chloride–sodium sulfate–water system at 200 and 250 bar up to 400°C , 1999 .

[14]  Manuel Dierick,et al.  New features in cold neutron radiography and tomography Part I: thinner scintillators and a neutron velocity selector to improve the spatial resolution , 2002 .

[15]  G. W. Morey.  The solubility of solids in gases , 1957 .

[16]  D. G. Archer,et al.  The Dielectric Constant of Water and Debye‐Hückel Limiting Law Slopes , 1990 .

[17]  C. Oh,et al.  Thermal-Hydraulic Modeling of Supercritical Water Oxidation of Ethanol , 1996 .

[18]  Mark H. Engelhard,et al.  Chemical Processing in High-Pressure Aqueous Environments. 7. Process Development for Catalytic Gasification of Wet Biomass Feedstocks , 2004 .

[19]  D. Shoesmith,et al.  The ionization constant of heavy water (D2O) in the temperature range 298 to 523 K , 1976 .

[20]  C. Martino,et al.  Reactions at supercritical conditions: Applications and fundamentals , 1995 .

[21]  Jefferson W. Tester,et al.  Precipitation of sodium chloride and sodium sulfate in water from sub- to supercritical conditions: 150 to 550 °C, 100 to 300 bar , 1994 .