Feedback control of acoustic disturbance transient growth in triggering thermoacoustic instability

Abstract Transient growth of acoustic disturbances could trigger thermoacoustic instability in a combustion system with non-orthogonal eigenmodes, even with stable eigenvalues. In this work, feedback control of transient growth of flow perturbations in a Rijke-type combustion system is considered. For this, a generalized thermoacoustic model with distributed monopole-like actuators is developed. The model is formulated in state-space to gain insights on the interaction between various eigenmodes and the dynamic response of the system to the actuators. Three critical parameters are identified: (1) the mode number, (2) the number of actuators, and (3) the locations of the actuators. It is shown that in general the number of the actuators K is related to the mode number N as K = N 2 . For simplicity in illustrating the main results of the paper, two different thermoacoustic systems are considered: system (a) with one mode and system (b) that involves two modes. The actuator location effect is studied in system (a) and it is found that the actuator location plays an important role in determining the control effort. In addition, sensitivity analysis of pressure- and velocity-related control parameters is conducted. In system (b), when the actuators are turned off (i.e., open-loop configuration), it is observed that acoustic energy transfers from the high frequency mode to the lower frequency mode. After some time, the energy is transferred back. Moreover, the high frequency oscillation grows into nonlinear limit cycle with the low frequency oscillation amplified. As a linear-quadratic regulator (LQR) is implemented to tune the actuators, both systems become asymptotically stable. However, the LQR controller fails in eliminating the transient growth, which may potentially trigger thermoacoustic instability. In order to achieve strict dissipativity (i.e., unity maximum transient growth), a transient growth controller is systematically designed and tested in both systems. Comparison is then made between the performance of the LQR controller and that of the transient growth controller. It is found in both systems that the transient growth controller achieves both exponential decay of the flow disturbance energy and unity maximum transient growth.

[1]  S. Candel,et al.  A review of active control of combustion instabilities , 1993 .

[2]  Claude Sensiau,et al.  Assessing non-normal effects in thermoacoustic systems with mean flow , 2011 .

[3]  Maria A. Heckl,et al.  Active Control of the Noise from a Rijke Tube , 1988 .

[4]  Konstantin I. Matveev,et al.  A study of the transition to instability in a Rijke tube with axial temperature gradient , 2003 .

[5]  Bruno Schuermans,et al.  Theoretical and experimental investigations on damper performance for suppression of thermoacoustic oscillations , 2010 .

[6]  Ephraim Gutmark,et al.  Online prediction of the onset of combustion instability based on the computation of damping ratios , 2008 .

[7]  G. S. Copeland,et al.  Combustion System Damping Augmentation With Helmholtz Resonators , 1998 .

[8]  Dan Zhao,et al.  Transient growth of flow disturbances in triggering a Rijke tube combustion instability , 2012 .

[9]  James F. Whidborne,et al.  On the Minimization of Maximum Transient Energy Growth , 2007, IEEE Transactions on Automatic Control.

[10]  A. Dowling.  A kinematic model of a ducted flame , 1999, Journal of Fluid Mechanics.

[11]  M. Mettenleiter,et al.  ADAPTIVE CONTROL OF AEROACOUSTIC INSTABILITIES , 2000 .

[12]  Jorg Schluter,et al.  Static control of combustion oscillations by coaxial flows: a large-eddy-simulations investigation , 2004 .

[13]  T. Schuller,et al.  Modeling the damping properties of perforated screens traversed by a bias flow and backed by a cavity at low Strouhal number , 2012 .

[14]  Michael S. Howe,et al.  Stability analysis of the Rijke tube with a Green's function approach , 2007 .

[15]  Thierry Poinsot,et al.  Transfer function measurements in a model combustor: Application to adaptive instability control , 2003 .

[16]  M. E. Lores,et al.  Application of the Galerkin Method in the Solution of Non-linear Axial Combustion Instability Problems in Liquid Rockets , 1971 .

[17]  Ann P. Dowling,et al.  Tuned Passive Control of Acoustic Damping of Perforated Liners , 2011 .

[18]  S. Candel,et al.  Nonlinear combustion instability analysis based on the flame describing function applied to turbulent premixed swirling flames , 2011 .

[19]  S. Hochgreb,et al.  Measurements of triggering and transient growth in a model lean-premixed gas turbine combustor , 2012 .

[20]  Dan Zhao,et al.  Time-domain characterization of the acoustic damping of a perforated liner with bias flow. , 2012, The Journal of the Acoustical Society of America.

[21]  Joerg R. Seume,et al.  Application of Active Combustion Instability Control to a Heavy Duty Gas Turbine , 1998 .

[22]  M. Juniper.  Triggering in the horizontal Rijke tube: non-normality, transient growth and bypass transition , 2010, Journal of Fluid Mechanics.

[23]  Raman Sujith,et al.  Characterizing energy growth during combustion instabilities: Singularvalues or eigenvalues? , 2009 .

[24]  Dan Zhao,et al.  Waste thermal energy harvesting from a convection-driven Rijke–Zhao thermo-acoustic-piezo system , 2013 .

[25]  Dan Zhao,et al.  Energy harvesting from a convection-driven Rijke-Zhao thermoacoustic engine , 2012 .

[26]  P. Langhorne.  Reheat buzz: an acoustically coupled combustion instability. Part 1. Experiment , 1988, Journal of Fluid Mechanics.

[27]  William R. Saunders,et al.  On the spectral characteristics of a self-excited Rijke tube combustor—numerical simulation and experimental measurements , 2005 .

[28]  Dan Zhao,et al.  Tuned passive control of combustion instabilities using multiple Helmholtz resonators , 2009 .

[29]  Ann P. Dowling,et al.  Sound and Sources of Sound , 1983 .

[30]  Ann P. Dowling,et al.  FEEDBACK CONTROL OF COMBUSTION OSCILLATIONS , 2005 .

[31]  Dan Zhao,et al.  Transmission Loss Analysis of a Parallel-Coupled Helmholtz Resonator Network , 2012 .

[32]  A. Dowling,et al.  Experimental investigation of the nonlinear response of turbulent premixed flames to imposed inlet velocity oscillations , 2005 .

[33]  Dan Zhao,et al.  Feedback Control of Combustion Instabilities Using a Helmholtz Resonator with an Oscillating Volume , 2012 .

[34]  Fred E. C. Culick,et al.  Combustion dynamics of an acoustically forced flame , 2003 .

[35]  Dan Zhao,et al.  A real-time plane-wave decomposition algorithm for characterizing perforated liners damping at multiple mode frequencies. , 2011, The Journal of the Acoustical Society of America.

[36]  Daniel U. Campos-Delgado,et al.  Active control of combustion instabilities using model-based controllers , 2003 .

[37]  J. Daily,et al.  Low-frequency pressure oscillations in a model ramjet combustor , 1991, Journal of Fluid Mechanics.

[38]  Anuradha M. Annaswamy,et al.  The Origin of Secondary Peaks with Active Control of Thermoacoustic Instability , 1998 .

[39]  Yedidia Neumeier,et al.  Sub-Scale Demonstration of the Active Feedback Control of Gas-Turbine Combustion Instabilities , 2000 .

[40]  Raman Sujith,et al.  Non-normality and its consequences in active control of thermoacoustic instabilities , 2011, Journal of Fluid Mechanics.

[41]  Anuradha M. Annaswamy,et al.  Thermoacoustic instability: model-based optimal control designs and experimental validation , 2000, IEEE Trans. Control. Syst. Technol..

[42]  Christian Oliver Paschereit,et al.  Active control of the acoustic boundary conditions of combustion test rigs , 2008 .

[43]  Konstantin I. Matveev,et al.  Energy consideration of the nonlinear effects in a Rijke tube , 2003 .

[44]  Dan Zhao,et al.  Acoustic Damping of a Helmholtz Resonator with an Oscillating Volume , 2008 .

[45]  Anuradha M. Annaswamy,et al.  Impact of Linear Coupling on the Design of Active Controllers for the Thermoacoustic Instability , 1997 .

[46]  Ann P. Dowling,et al.  Model-based control of combustion instabilities , 2007 .

[47]  Douglas L. Straub,et al.  Passive Control of Combustion Dynamics in Stationary Gas Turbines , 2003 .

[48]  Merrill W. Beckstead,et al.  A REVIEW OF RIJKE TUBES, RIJKE BURNERS AND RELATED DEVICES , 1993 .

[49]  Peter J. Schmid,et al.  Non-normality of thermoacoustic interactions: an experimental investigation , 2011 .

[50]  V. Yang,et al.  Dynamics and stability of lean-premixed swirl-stabilized combustion , 2009 .

[51]  Raman Sujith,et al.  Thermoacoustic instability in a Rijke tube: non-normality and nonlinearity , 2007 .

[52]  Dan Zhao,et al.  Experimental evaluation of anti-sound approach in damping self-sustained thermoacoustics oscillations , 2013 .