A Comparative Assessment of Hydroponically Grown Cereal Crops for the Purification of Aquaculture Wastewater and the Production of Fish Feed

Hydroponically grown wheat, barley and oats were examined for their ability to remove nutrients from aquaculture wastewater. Wheat, barley and oats seeds were germinated in water in a hydroponics system. The seedlings then received wastewater from an aquaculture system stocked with Arctic charr. During the experiment, the crops grew rapidly and fairly uniformly and showed no signs of mineral deficiency although fungal growth was evident. The average crop heights and yields at harvest were 19.0, 25.5 and 25.2 cm and 64, 59 and 42 t ha-1 for wheat, barley and oats, respectively. The hydroponically grown wheat, barley and oats were able to significantly reduce the pollution load of the aquaculture wastewater. The TS, COD, NH4+-N, NO2--N, NO3--N and PO43--P reductions ranged from 53.3 to 57.7%, from 55.7 to 78.7%, from 76.0 to 80.0% from 85.1 to 92.9%, from 62.1 to 79.3% and from 74.1 to 93.0%, respectively. The compartments containing barley produced the highest quality effluent, which was suitable for reuse in aquaculture operations. The average TS, COD, NH4+-N, NO2--N, NO3--N and PO43--P concentrations and pH of the final effluent from the compartments containing barley were 442, 64, 0.50, 0.02, 5.89 and 0.61 mg L-1 and 6.65, respectively. The nutritive value of the three wastewater grown crops was assessed to determine the suitability of using the plants as a component in fish feed. The three terrestrial crops meet the energy, fat, Ca, Mg, P, Na, S and Mn dietary requirements of aquatic animals, exceed the carbohydrate, crude fiber, Cl, K, Cu, Fe, Se and Zn requirements of fish and shellfish and do not contain sufficient amounts of protein to meet the dietary requirements of fish and shellfish. The crops will require supplementation with a high protein source that contains low concentrations of carbohydrates, crude fiber, Cl, K, Cu, Fe, Se and Zn. Common protein sources that could be used for supplementation included fishmeal, bone meal and blood meal.

[1]  W. Horwitz,et al.  Official methods of analysis of AOAC International , 2010 .

[2]  Michael H. Schwarz,et al.  Understanding Fish Nutrition, Feeds, and Feeding , 2009 .

[3]  A. Ghaly,et al.  Use of Barley for the Purification of Aquaculture Wastewater in a Hydroponics System , 2008 .

[4]  W. Verstraete,et al.  Nitrogen removal techniques in aquaculture for a sustainable production , 2007 .

[5]  D. Smith,et al.  Digestibility of lupin kernel meals in feeds for the black tiger shrimp, Penaeus monodon , 2007 .

[6]  E. McLean,et al.  The effects of organic protein supplementation upon growth, feed conversion and texture quality parameters of juvenile cobia (Rachycentron canadum) , 2007 .

[7]  M. Lenzi,et al.  Reduction of land based fish-farming impact by phytotreatment pond system in a marginal lagoon area , 2006 .

[8]  S. Shiau,et al.  Dietary selenium requirements of juvenile grouper, Epinephelus malabaricus , 2005 .

[9]  Roger C. Viadero,et al.  Effluent and production impacts of flow-through aquaculture operations in West Virginia , 2005 .

[10]  James M. Ebeling,et al.  Screening and evaluation of polymers as flocculation aids for the treatment of aquacultural effluents , 2005 .

[11]  John Davidson,et al.  Solids removal from a coldwater recirculating system—comparison of a swirl separator and a radial-flow settler , 2005 .

[12]  A. Ghaly,et al.  Phytoremediation of aquaculture wastewater for water recycling and production of fish feed. , 2005, Environment international.

[13]  M. Islam,et al.  Nitrogen and phosphorus budget in coastal and marine cage aquaculture and impacts of effluent loading on ecosystem: review and analysis towards model development. , 2005, Marine pollution bulletin.

[14]  Shu-lin Chen,et al.  Reducing phosphorus discharge from flow-through aquaculture: III: assessing high-rate filtration media for effluent solids and phosphorus removal , 2004 .

[15]  E. Awuah,et al.  COMPARATIVE PERFORMANCE STUDIES OF WATER LETTUCE, DUCKWEED, AND ALGAL-BASED STABILIZATION PONDS USING LOW-STRENGTH SEWAGE , 2004, Journal of toxicology and environmental health. Part A.

[16]  T. Kanabkaew,et al.  Aquatic plants for domestic wastewater treatment: Lotus (Nelumbo nucifera) and Hydrilla (Hydrilla verticillata) systems , 2004 .

[17]  R. Arlinghaus,et al.  Coupling insights from a carp, Cyprinus carpio, angler survey with feeding experiments to evaluate composition, quality and phosphorus input of groundbait in coarse fishing , 2004 .

[18]  Ann C. Wilkie,et al.  Nutrient removal by floating aquatic macrophytes cultured in anaerobically digested flushed dairy manure wastewater , 2004 .

[19]  E. Gomes,et al.  Growth of rainbow trout fed a diet supplemented with earthworms, after chemical treatment , 1995, Aquaculture International.

[20]  M. A. Alam,et al.  Performance of plastic biofilter media with different configuration in a water recirculation system for the culture of Nile tilapia (Oreochromis niloticus) , 2003 .

[21]  C. Duarte,et al.  Biogeochemical conditions in sediments enriched by organic matter from net-pen fish farms in the Bolinao area, Philippines. , 2003, Marine pollution bulletin.

[22]  Paul C. Southgate,et al.  Feeds and feed production , 2003 .

[23]  Ying‐Feng Lin,et al.  The potential use of constructed wetlands in a recirculating aquaculture system for shrimp culture. , 2003, Environmental pollution.

[24]  F. Monnet,et al.  Treatment of domestic wastewater by an hydroponic NFT system. , 2003, Chemosphere.

[25]  D. Randall,et al.  Ammonia toxicity in fish. , 2002, Marine pollution bulletin.

[26]  A. Maage,et al.  Zinc gluconate and zinc sulphate as dietary zinc sources for Atlantic salmon , 2001 .

[27]  B. Finstad,et al.  The effects of dietary NaCl supplement on hypo‐osmoregulatory ability and sea water performance of Arctic charr (Salvelinus alpinus L.) smolts , 2000 .

[28]  F. Takeda,et al.  Economic Evaluation of Hydroponics and Other Treatment Options for Phosphorus Removal in Aquaculture Effluent , 2000 .

[29]  O. Lekang,et al.  An integrated wastewater treatment system for land-based fish-farming , 2000 .

[30]  A. Bergheim,et al.  Solids management and removal for intensive land-based aquaculture production systems , 2000 .

[31]  S. L. Steinberg,et al.  Wheat response to differences in water and nutritional status between zeoponic and hydroponic growth systems. , 2000, Agronomy journal.

[32]  N. Ashbolt,et al.  Innovative production treatment hydroponic farm for primary municipal sewage utilisation , 2000 .

[33]  C. Barrias,et al.  The use of locally produced fish meal and other dietary manipulations in practical diets for rainbow trout Oncorhynchus mykiss (Walbaum) , 2000 .

[34]  A. Maage,et al.  Toxic levels of dietary copper in Atlantic salmon (Salmo salar L.) parr , 1999 .

[35]  H. Ngo,et al.  Effluent recycle and waste minimization in prawn farm effluent , 1999 .

[36]  J. Tiedje,et al.  Effects of pH and Oxygen and Ammonium Concentrations on the Community Structure of Nitrifying Bacteria from Wastewater , 1998, Applied and Environmental Microbiology.

[37]  A. Maage,et al.  Supplementing copper to a fish meal based diet fed to Atlantic salmon parr affects liver copper and selenium concentrations , 1998 .

[38]  P. Martin,et al.  Ingestion of sub-lethal levels of iron sulphate by African catfish affects growth and tissue lipid peroxidation , 1997 .

[39]  S. Todd,et al.  The Treatment of Aquaculture Wastewaters—A Botanical Approach , 1997 .

[40]  R M Wheeler,et al.  Excess nutrients in hydroponic solutions alter nutrient content of rice, wheat, and potato. , 1996, Advances in space research : the official journal of the Committee on Space Research.

[41]  P. Bienfang.  Aquaculture water reuse systems: Engineering design and management , 1996 .

[42]  Y. Wu,et al.  Evaluation of Corn Gluten Meal as a Protein Source in Tilapia Diets , 1995 .

[43]  R. Wu.  The environmental impact of marine fish culture: Towards a sustainable future , 1995 .

[44]  Thomas B. Lawson,et al.  Fundamentals of Aquacultural Engineering , 1995, Springer US.

[45]  H. Ackefors,et al.  Introduction to the General Principles of Aquaculture , 1994 .

[46]  A. Eid,et al.  Dietary zinc requirement of fingerling Oreochromis niloticus , 1994 .

[47]  Michael B. Timmons,et al.  Aquaculture water reuse systems: engineering design and management. , 1994 .

[48]  R. F. Malone,et al.  Suspended solids control in recirculating aquaculture systems , 1994 .

[49]  R. Stickney,et al.  Principles of aquaculture , 1994 .

[50]  M. Besner,et al.  The effect of salty diets and gradual transfer to sea water on osmotic adaptation, gill Na+, K+-ATPase activation, and survival of brook charr, Salvelinus fontinalis, Mitchill , 1992 .

[51]  T. Pillay.  Aquaculture and the Environment , 1992 .

[52]  G. Czapar,et al.  [Water quality]. , 1992, Verhandelingen - Koninklijke Academie voor Geneeskunde van Belgie.

[53]  S. Lane,et al.  Use of a small‐scale nutrient‐film hydroponic technique to reduce mineral accumulation in aquarium water , 1991 .

[54]  C. Mackowiak,et al.  Continuous hydroponic wheat production using a recirculating system , 1989 .

[55]  F. Eddy,et al.  Effect of dietary sodium chloride on growth, food intake and conversion efficiency in rainbow trout (Salmo gairdneri Richardson) , 1988 .

[56]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[57]  B. W. Pettersen.  The Ability of Lettuce, Rye Grass and Barley to Reduce the Nutrient Salt Content of Wastewater from Fish Farming , 1987 .

[58]  K. Thompson,et al.  Seeds: Physiology of Development and Germination , 1986 .

[59]  S. J. Slinger,et al.  Maximum tolerable and toxicity levels of dietary copper in rainbow trout (Salmo gairdneri Richardson) , 1985 .

[60]  M. Poxton,et al.  Water quality criteria for marine fisheries , 1982 .

[61]  R. Miller,et al.  Chemical and microbiological properties , 1982 .

[62]  D. Porath,et al.  Ammonia stripping by duckweed and its feasibility in circulating aquaculture , 1982 .

[63]  A. Page.  Methods of soil analysis. Part 2. Chemical and microbiological properties. , 1982 .

[64]  W. Horwitz.  Official Methods of Analysis , 1980 .

[65]  W. M. Lewis,et al.  Use of Hydroponics to Maintain Quality of Recirculated Water in a Fish Culture System , 1978 .

[66]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater. 14th edition. , 1976 .

[67]  D. Barber,et al.  THE RELEASE OF ORGANIC SUBSTANCES BY CEREAL ROOTS INTO SOIL , 1976 .