Thermal behaviour during the pyrolysis of low rank perhydrous coals

Abstract Perhydrous coals are characterised by high H/C atomic ratios and so their chemical structure is substantially modified with respect to that of conventional coals. As a result, perhydrous coals show different physico-chemical properties to common coals (i.e. higher volatile matter content, enhancement of oil/tar potential, relatively lower porosity and higher fluidity during carbonisation). However, there is little information about thermal behaviour during the pyrolysis of this type of coal. In this work, six perhydrous coals (H/C ratio between 0.83 and 1.07) were pyrolysed and analysed by simultaneous thermogravimetry/mass spectrometry. The results of this work have revealed the influence of high H/C values on the thermal behaviour of the coals studied. During pyrolysis the perhydrous coals exhibit very well defined, symmetrical peaks in the mass loss rate profiles, while normal coals usually show a broader peak. The shape of such curves suggests that in perhydrous coals fragmentation processes prevailed over condensation reactions. The high hydrogen content of perhydrous coals may stabilise the free radicals formed during heat treatment, increasing the production of light components.

[1]  J. J. Pis,et al.  Simultaneous thermogravimetric–mass spectrometric study on the pyrolysis behaviour of different rank coals , 1999 .

[2]  R. Lin,et al.  Studying individual macerals using i.r. microspectrometry, and implications on oil versus gas/condensate proneness and “low-rank” generation , 1993 .

[3]  R. Littke,et al.  Structural modifications of vitrinite and alginite concentrates during pyrolitic maturation at different heating rates. A combined infrared, 13C NMR and microscopical study , 1990 .

[4]  J. C. Río,et al.  Control of the chemical structure of perhydrous coals; FTIR and Py-GC/MS investigation , 2002 .

[5]  E. Jakab,et al.  Thermogravimetric-mass spectrometric study on the low temperature oxidation of coals , 1991 .

[6]  A. Tomita,et al.  Effect of temperature on the flash pyrolysis of various coals , 1987 .

[7]  C. Boreham,et al.  Small angle neutron scattering signature of oil generation in artificially and naturally matured hydrocarbon source rocks , 2000 .

[8]  Michael A. Wilson,et al.  13C n.m.r. aromaticity balance on the products from flash pyrolysis of five Australian coals , 1987 .

[9]  Covadonga Pevida,et al.  A comparison of different methods for predicting coal devolatilisation kinetics , 2001 .

[10]  Mohamed Pourkashanian,et al.  Modelling NOx formation in coal particle combustion at high temperature: an investigation of the devolatilisation kinetic factors , 1999 .

[11]  A. Oberlin,et al.  Influence of elemental composition on carbonization: Pyrolysis of kerosene shale and kuckersite , 1980 .

[12]  L. J. Bellamy.  The infra-red spectra of complex molecules , 1962 .

[13]  A. Oberlin,et al.  Influence of elemental composition on carbonization pyrolysis of sporopollenin and lignite as models of kerogens , 1979 .

[14]  Peter R. Solomon,et al.  Progress in coal pyrolysis , 1993 .

[15]  R. Elofson.  THE INFRARED SPECTRA OF HUMIC ACIDS AND RELATED MATERIALS , 1957 .

[16]  K. H. van Heek,et al.  Structure and pyrolysis behaviour of different coals and relevant model substances , 1994 .

[17]  K. Heek,et al.  Reactions of oxygen containing structures in coal pyrolysis , 1991 .

[18]  J. J. Pis,et al.  A study of the self-heating of fresh and oxidized coals by differential thermal analysis , 1996 .

[19]  Mustafa Versan Kok,et al.  PYROLYSIS AND COMBUSTION STUDIES OF FOSSIL FUELS BY THERMAL ANALYSIS METHODS , 1995 .

[20]  J. C. Río,et al.  Molecular characterisation of vitrinite in relation to natural hydrogen enrichment and depositional environment , 2000 .

[21]  R. P. Gaikwad,et al.  FT-i.r. spectroscopic analysis of coals and coal extracts , 1986 .

[22]  B. Durand.  Kerogen: Insoluble Organic Matter from Sedimentary Rocks , 1980 .

[23]  R. Kandiyoti,et al.  Combustion reactivity and morphological change in coal chars: Effect of pyrolysis temperature, heating rate and pressure , 1996 .

[24]  F. Laggoun‐Défarge,et al.  Study of physical and chemical properties of vitrinites. Inferences on depositional and coalification controls , 1998 .

[25]  P. Rosenberg,et al.  REFLECTANCE RETARDATION (SUPPRESSION) AND SOURCE ROCK PROPERTIES RELATED TO HYDROGEN‐ENRICHED VITRINITE IN MIDDLE JURASSIC COALS, DANISH NORTH SEA , 1998 .

[26]  F. Laggoun‐Défarge,et al.  Influence of Resinite on Huminite Properties , 1994 .

[27]  S. Niksa.  Flashchain Theory for Rapid Coal Devolatilization Kinetics. 7. Predicting the Release of Oxygen Species from Various Coals , 1996 .

[28]  F. Laggoun‐Défarge,et al.  FTIR Study of Pure Vitrains and Associated Coals , 1995 .