Structural, electrical and optical properties of aluminum doped zinc oxide films prepared by radio frequency magnetron sputtering

Aluminum doped zinc oxide (AZO) films are prepared by rf magnetron sputtering on glass or Si substrates using specifically designed ZnO targets containing different amount of Al2O3 powder as the Al doping source. The structural, electrical, and optical properties of the AZO films are investigated in terms of the preparation conditions, such as the Al2O3 content in the target, rf power, substrate temperature and working pressure. The crystal structure of the AZO films is hexagonal wurtzite. The orientation, regardless of the Al content, is along the c axis perpendicular to the substrate. The doping concentration in the film is 1.9 at. % for 1 wt % Al2O3 target, 4.0 at. % for 3 wt % Al2O3 target, and 6.2 at. % for 5 wt % Al2O3 target. The resistivity of the AZO film prepared with the 3 wt % Al2O3 target is ∼4.7×10−4 Ω cm, and depends mainly on the carrier concentration. The optical transmittance of a 1500-A-thick film at 550 nm is ∼90%. The optical band gap depends on the Al doping level and on the microstr...

[1]  Yasuhiro Igasaki,et al.  The effects of deposition rate on the structural and electrical properties of ZnO:Al films deposited on (112̄0) oriented sapphire substrates , 1991 .

[2]  Bruce E. Gnade,et al.  Mechanisms behind green photoluminescence in ZnO phosphor powders , 1996 .

[3]  Takashi Mouri,et al.  Preparations of ZnO:Al transparent conducting films by d.c. magnetron sputtering , 1990 .

[4]  Claes-Goeran Granqvist,et al.  Window coatings for the future , 1990 .

[5]  K. Chopra,et al.  Transparent conductors—A status review , 1983 .

[6]  H. Nanto,et al.  Optical Properties of Aluminum Doped Zinc Oxide Thin Films Prepared by RF Magnetron Sputtering , 1985 .

[7]  S. Takada.  Relation between optical property and crystallinity of ZnO thin films prepared by rf magnetron sputtering , 1993 .

[8]  H. Nanto,et al.  The stability of aluminium-doped ZnO transparent electrodes fabricated by sputtering , 1986 .

[9]  I. Mori,et al.  Transparent ZnO:Al films prepared by co-sputtering of ZnO:Al with either a Zn or an Al target , 1996 .

[10]  Shinzo Takata,et al.  Highly Conductive and Transparent Aluminum Doped Zinc Oxide Thin Films Prepared by RF Magnetron Sputtering , 1984 .

[11]  J. Lodder,et al.  R.f.-sputtered Co-Cr layers for perpendicular magnetic recording I: Structural properties , 1983 .

[12]  S. Chaudhuri,et al.  Grain boundary scattering in aluminium-doped ZnO films , 1991 .

[13]  Y. Igasaki,et al.  Substrate temperature dependence of electrical properties of ZnO:Al epitaxial films on sapphire (12̄10) , 1991 .

[14]  F.C.M. van de Pol,et al.  R.f. planar magnetron sputtered ZnO films I: Structural properties , 1991 .

[15]  H. Nanto,et al.  Highly Conductive and Transparent Silicon Doped Zinc Oxide Thin Films Prepared by RF Magnetron Sputtering , 1986 .

[16]  F.C.M. van de Pol,et al.  R.F. planar magnetron sputtered ZnO films II: Electrical properties , 1991 .

[17]  I. Hamberg,et al.  Optical properties of sputter-deposited ZnO:Al thin films , 1988 .

[18]  Shinzo Takata,et al.  Group III Impurity Doped Zinc Oxide Thin Films Prepared by RF Magnetron Sputtering , 1985 .

[19]  Sernelius.  Self-energy shifts in heavily doped, polar semiconductors. , 1987, Physical review. B, Condensed matter.

[20]  A. Heinrich,et al.  Electrical properties and non‐stoichiometry in ZnO single crystals , 1981 .

[21]  John A. Thornton,et al.  Influence of apparatus geometry and deposition conditions on the structure and topography of thick sputtered coatings , 1974 .

[22]  J. McKittrick,et al.  Synthesis and optelectronic characterization of gallium doped zinc oxide transparent electrodes , 1996 .

[23]  K. Yoon,et al.  Optical and electrical properties of Ga2O3-doped ZnO films prepared by r.f. sputtering , 1990 .

[24]  G. H. Bauer,et al.  Studies on the interface between novel type ZnO and p-a-SiC:H in 1.5 eV a-SiGe:H pin diodes in comparison to SnOx and ITO , 1992 .

[25]  D. Grempel,et al.  Electronic specific-heat anomalies in two-dimensional systems , 1982 .

[26]  P. A. Wolff,et al.  Theory of the Band Structure of Very Degenerate Semiconductors , 1962 .