Development of a lithium hydride powered hydrogen generator for use in long life, low power PEM fuel cell power supplies

This thesis studies a hybrid PEM fuel cell system for use in low power, long life sensor networks. PEM fuel cells offer high efficiency and environmental friendliness but have not been widely adopted due to cost, reliability, and the problem of hydrogen storage. This thesis focuses on the problem of hydrogen storage. Lithium hydride is selected for study because of its high hydrogen content and because it produces hydrogen through a chemical reaction with water. Control of the lithium hydride hydrolysis reaction is investigated. Active and passivelycontrolled hydrogen generators that rely on lithium hydride are designed and experimentally studied. A model is created to explain the system's pressure response. The passive hydrogen generator is experimentally tested in a 2 month benchtop fuel cell experiment. The results of the study suggest that it is possible to design a simple, passive generator that controls the hydrogen pressure at an operating point. However, over longer time periods of 1-3 months, the rate of reaction slows significantly and byproduct formation prevents full utilization of the lithium hydride. These limits complicate the design of a power supply relying on lithium hydride.

[1]  Roger Smith,et al.  A literature review of reactions and kinetics of lithium hydride hydrolysis , 2006 .

[2]  Thomas I. Valdez,et al.  High-Energy Portable Fuel Cell Power Sources , 2008 .

[3]  L. Greenspan.  Humidity Fixed Points of Binary Saturated Aqueous Solutions , 1977, Journal of Research of the National Bureau of Standards. Section A, Physics and Chemistry.

[4]  R. Hanrahan,et al.  Hydrolysis studies of polycrystalline lithium hydride , 2007 .

[5]  J. Weidner,et al.  Diffusion of water in Nafion 115 membranes , 2000 .

[6]  Kavya Kamal Manyapu.  Feasibility study of long-life micro fuel cell power supply for sensor networks for space and terrestrial applications , 2010 .

[7]  N. Nachtrieb,et al.  Principles of Modern Chemistry , 1986 .

[8]  S. Chan,et al.  Feasibility study of hydrogen generation from sodium borohydride solution for micro fuel cell applications , 2005 .

[9]  Jason B. Siegel,et al.  Nitrogen Front Evolution in Purged Polymer Electrolyte Membrane Fuel Cell with Dead-Ended Anode , 2010 .

[10]  Ian F. Akyildiz,et al.  Sensor Networks , 2002, Encyclopedia of GIS.

[11]  B. Miles.  An American experience. , 1976, The New Zealand nursing journal. Kai tiaki.

[12]  Thomas P J Crompton Mbbs BSc Mrcs.  Battery Reference Book , 2000 .

[13]  H. Abruña,et al.  Fuel cells and hydrogen storage , 2011 .

[14]  A. G. Ritchie,et al.  Recent developments and likely advances in lithium rechargeable batteries , 2004 .

[15]  Michael P Marder,et al.  Rubber and Rubber Balloons: Paradigms of Thermodynamics , 2005 .

[16]  F. R. Foulkes,et al.  Development of hydrogen storage for fuel cell generators II: utilization of calcium hydride and lithium hydride , 2003 .

[17]  M. Armand,et al.  Issues and challenges facing rechargeable lithium batteries , 2001, Nature.

[18]  S. Kocha,et al.  Characterization of gas crossover and its implications in PEM fuel cells , 2006 .

[19]  G. K. Pitcher.  Solid lithium hydride as a hydrogen source for fuel cells , 1996, Proceedings of Symposium on Autonomous Underwater Vehicle Technology.

[20]  F. R. Foulkes,et al.  Development of hydrogen storage for fuel cellgenerators. i: Hydrogen generation using hydrolysishydrides , 1999 .

[21]  J. O'm. Bockris,et al.  Energy, the solar hydrogen alternative , 1975 .

[22]  A. Züttel,et al.  Hydrogen-storage materials for mobile applications , 2001, Nature.

[23]  M. Hirscher,et al.  Metal hydride materials for solid hydrogen storage: a review , 2007 .

[24]  Anna G. Stefanopoulou,et al.  Correlating Nitrogen Accumulation With Temporal Fuel Cell Performance , 2010 .

[25]  Jan M. Rabaey,et al.  Power Sources for Wireless Sensor Networks , 2004, EWSN.

[26]  Gavin Walker,et al.  Solid-state hydrogen storage : materials and chemistry , 2008 .

[27]  Jekan Thangavelautham,et al.  On the Catalytic Degradation in Fuel Cell Power Supplies for Long‐Life Mobile Field Sensors , 2013 .

[28]  M. Balooch,et al.  The reaction kinetics of lithium salt with water vapor , 2002 .

[29]  Ronald W. Breault,et al.  HYDROGEN TRANSMISSION/STORAGE WITH METAL HYDRIDE-ORGANIC SLURRY AND ADVANCED CHEMICAL HYDRIDE/HYDROGEN FOR PEMFC VEHICLES , 2000 .

[30]  T. Sakai,et al.  The state of research and development for applications of metal hydrides in Japan , 1997 .

[31]  J. Westwater,et al.  The Mathematics of Diffusion. , 1957 .