Experimental study of wood downdraft gasification for an improved producer gas quality through an innovative two-stage air and premixed air/gas supply approach.

This study conducted experiments on three different downdraft gasification approaches: single stage, conventional two-stage, and an innovative two-stage air and premixed air/gas supply approach. The innovative two-stage approach has two nozzle locations, one for air supply at combustion zone and the other located at the pyrolysis zone for supplying the premixed gas (air and producer gas). The producer gas is partially bypassed to mix with air and supplied to burn at the pyrolysis zone. The result shows that producer gas quality generated by the innovative two-stage approach improved as compared to conventional two-stage. The higher heating value (HHV) increased from 5.4 to 6.5 MJ/Nm(3). Tar content in producer gas reduced to less than 45 mg/Nm(3). With this approach, gas can be fed directly to an internal combustion engine. Furthermore, the gasification thermal efficiency also improved by approximately 14%. The approach gave double benefits on gas qualities and energy savings.

[1]  H. Hofbauer,et al.  Biomass steam gasification--an extensive parametric modeling study. , 2001, Bioresource technology.

[2]  H. S. Mukunda,et al.  Biomass gasification—a substitute to fossil fuel for heat application , 2003 .

[3]  S. Bhattacharya,et al.  A study on a multi-stage hybrid gasifier-engine system , 2001 .

[4]  Theodoros Damartzis,et al.  Thermochemical conversion of biomass to second generation biofuels through integrated process design—A review , 2011 .

[5]  D. E. Beasley,et al.  Theory and design for mechanical measurements , 1991 .

[6]  X. L. Zhang,et al.  Experimental study on air-stream gasification of biomass micron fuel (BMF) in a cyclone gasifier. , 2009, Bioresource Technology.

[7]  T B Reed,et al.  Handbook of biomass downdraft gasifier engine systems , 1988 .

[8]  Ajay Kumar,et al.  Optimization and economic evaluation of industrial gas production and combined heat and power generation from gasification of corn stover and distillers grains. , 2010, Bioresource technology.

[9]  Elfinn Larsen,et al.  High tar reduction in a two-stage gasifier , 2000 .

[10]  Roger Frost,et al.  International Organization for Standardization (ISO) , 2004 .

[11]  T. A. Milne,et al.  Biomass Gasifier "Tars": Their Nature, Formation, and Conversion , 1998 .

[12]  E Kantarelis,et al.  Valorization of cotton stalks by fast pyrolysis and fixed bed air gasification for syngas production as precursor of second generation biofuels and sustainable agriculture. , 2009, Bioresource technology.

[13]  Avdhesh Kr. Sharma,et al.  Experimental study on 75 kWth downdraft (biomass) gasifier system , 2009 .

[14]  G. A. Quadir,et al.  Experimental investigation of a downdraft biomass gasifier , 2002 .

[15]  Peter McKendry,et al.  Energy production from biomass (Part 3): Gasification technologies. , 2002, Bioresource technology.

[16]  Kj Krzysztof Ptasinski,et al.  A review of the primary measures for tar elimination in biomass gasification processes , 2003 .

[17]  S. Turns.  An Introduction to Combustion: Concepts and Applications , 2000 .

[18]  Xiaorong Xu,et al.  Development of a supported tri-metallic catalyst and evaluation of the catalytic activity in biomass steam gasification. , 2009, Bioresource technology.

[19]  S. Kumar,et al.  Numerical simulation of the pyrolysis zone in a downdraft gasification process. , 2009, Bioresource technology.

[20]  Leonard Steinborn,et al.  International Organization for Standardization ISO/IEC 17025 General Requirements for the Competence of Testing and Calibration Laboratories , 2004 .