Susceptibility of Smart Power ICs to Radio Frequency Interference

This paper deals with the susceptibility to radio frequency interference (RFI) of the analog front ends embedded in smart power integrated circuits. The case of RFI injected in the power transistor terminals that propagates to the analog front ends of the same integrated circuit is investigated using equivalent circuits that include the silicon substrate. The demodulation of the interference that takes place in the analog front-end circuits is evaluated by means of an approximate nonlinear method. In particular, it is shown that the demodulation of the substrate interference in a MOS differential input stage depends on the asymmetry of the circuits connected to the input terminals. Based on this, a simple method to increase the immunity to such interference is presented and its effectiveness is proved through computer simulations and through measurements carried out on a test chip.

[1]  Anna Richelli.  EMI susceptibility of DTMOS opamps , 2013 .

[2]  Franco Fiori,et al.  Complementary differential pair with high immunity to RFI , 2002 .

[3]  Michiel Steyaert,et al.  Kuijk Bandgap Voltage Reference With High Immunity to EMI , 2010, IEEE Transactions on Circuits and Systems II: Express Briefs.

[4]  Franco Fiori,et al.  Nonlinear effects of radio-frequency interference in operational amplifiers , 2002 .

[5]  David J. Allstot,et al.  Simulation techniques and solutions for mixed-signal coupling in integrated circuits , 1994 .

[6]  F. Fiori.  Susceptibility of CMOS Voltage Comparators to Radio Frequency Interference , 2012, IEEE Transactions on Electromagnetic Compatibility.

[7]  Ali Haidar,et al.  A comprehensive simulation model for immunity prediction in integrated circuits with respect to substrate injection , 2009, Microelectron. J..

[8]  T.M. Jahns,et al.  Development of an Active dv/dt Control Algorithm for Reducing Inverter Conducted EMI with Minimal Impact on Switching Losses , 2007, 2007 IEEE Power Electronics Specialists Conference.

[9]  M. Steyaert,et al.  An EMI Resisting LIN Driver in 0.35-micron High-Voltage CMOS , 2007, IEEE Journal of Solid-State Circuits.

[10]  Piet Wambacq,et al.  Distortion analysis of analog integrated circuits , 1998 .

[11]  D. Magnon,et al.  Conducted EMI Reduction in Power Converters by Means of Periodic Switching Frequency Modulation , 2007, IEEE Transactions on Power Electronics.

[12]  F. Klotz,et al.  Improving the immunity of smart power integrated circuits by controlling RF substrate coupling , 2011, 2011 IEEE International Symposium on Electromagnetic Compatibility.

[13]  T.H. Hubing,et al.  The Electromagnetic Compatibility of Integrated Circuits—Past, Present, and Future , 2009, IEEE Transactions on Electromagnetic Compatibility.

[14]  H. De Man,et al.  Substrate noise generation in complex digital systems: efficient modeling and simulation methodology and experimental verification , 2001, 2001 IEEE International Solid-State Circuits Conference. Digest of Technical Papers. ISSCC (Cat. No.01CH37177).

[15]  Yamarita Villavicencio,et al.  Electrical Model of Microcontrollers for the Prediction of Electromagnetic Emissions , 2011, IEEE Transactions on Very Large Scale Integration (VLSI) Systems.

[16]  Bo Zhang,et al.  An Advanced Spread Spectrum Architecture Using Pseudorandom Modulation to Improve EMI in Class D Amplifier , 2011, IEEE Transactions on Power Electronics.

[17]  Guido Masetti,et al.  Criteria to reduce failures induced from conveyed electromagnetic interferences on CMOS operational amplifiers , 1997 .

[18]  F. Fiori,et al.  MOS power transistor model for Electromagnetic Susceptibility analysis , 2011, Microelectron. Reliab..

[19]  Anna Richelli.  Increasing EMI Immunity in Novel Low-Voltage CMOS OpAmps , 2012, IEEE Transactions on Electromagnetic Compatibility.

[20]  P.S. Crovetti,et al.  A Linear Voltage Regulator Model for EMC Analysis , 2007, IEEE Transactions on Power Electronics.

[21]  Anna Richelli.  Measurements of EMI susceptibility in ultra-low-voltage OpAmps , 2011, 2011 8th Workshop on Electromagnetic Compatibility of Integrated Circuits.

[22]  Safwat G. Zaky,et al.  On the prediction of digital circuit susceptibility to radiated EMI , 1995 .

[23]  Franco Fiori.  A new nonlinear model of EMI-induced distortion phenomena in feedback CMOS operational amplifiers , 2002 .

[24]  Jonghoon J. Kim,et al.  Spread spectrum clock Generator with delay cell array to reduce electromagnetic interference , 2005 .

[25]  Robert G. Meyer,et al.  Modeling and analysis of substrate coupling in integrated circuits , 1996 .

[26]  T. Steinecke,et al.  Generic IC EMC Test Specification , 2012, 2012 Asia-Pacific Symposium on Electromagnetic Compatibility.

[27]  Calogero Bona,et al.  A New Filtering Technique That Makes Power Transistors Immune to EMI , 2011, IEEE Transactions on Power Electronics.

[28]  F. Fiori,et al.  A New Grounding Scheme to Reduce the Electromagnetic Emission of Smart-Power System-on-Chips , 2012, IEEE Transactions on Power Electronics.