A thermodynamic study of waste heat recovery from GT-MHR using organic Rankine cycles

This paper presents an investigation on the utilization of waste heat from a gas turbine-modular helium reactor (GT-MHR) using different arrangements of organic Rankine cycles (ORCs) for power production. The considered organic Rankine cycles were: simple organic Rankine cycle (SORC), ORC with internal heat exchanger (HORC) and regenerative organic Rankine cycle (RORC). The performances of the combined cycles were studied from the point of view of first and second-laws of thermodynamics. Individual models were developed for each component and the effects of some important parameters such as compressor pressure ratio, turbine inlet temperature, and evaporator and environment temperatures on the efficiencies and on the exergy destruction rate were studied. Finally the combined cycles were optimized thermodynamically using the EES (Engineering Equation Solver) software. Based on the identical operating conditions for the GT-MHR cycle, a comparison between the three combined cycles and a simple GT-MHR cycle is also were made. This comparison was also carried out from the point of view of economics. The GT-MHR/SORC combined cycle proved to be the best among all the cycles from the point of view of both thermodynamics and economics. The efficiency of this cycle was about 10% higher than that of GT-MHR alone.

[1]  Yanhua Zheng,et al.  Post-test analysis of helium circulator trip without scram at 3 MW power level on the HTR-10 , 2009 .

[2]  S. Jayaraj,et al.  Environment friendly alternatives to halogenated refrigerants—A review , 2009 .

[3]  Mohamed S. El-Genk,et al.  Properties of noble gases and binary mixtures for closed Brayton Cycle applications , 2008 .

[4]  Ibrahim Dincer,et al.  Exergy: Energy, Environment and Sustainable Development , 2007 .

[5]  George Papadakis,et al.  Exergy analysis of micro-organic Rankine power cycles for a small scale solar driven reverse osmosis desalination system , 2010 .

[6]  Vittorio Verda,et al.  Solid Oxide Fuel Cell System Configurations for Distributed Generation , 2008 .

[7]  J. Warner,et al.  Combined - Cycle Gas & Steam Turbine Power Plants , 1999 .

[8]  Saied Dardour,et al.  Utilisation of waste heat from GT–MHR and PBMR reactors for nuclear desalination , 2007 .

[9]  Jiangfeng Wang,et al.  Parametric optimization and comparative study of organic Rankine cycle (ORC) for low grade waste heat recovery , 2009 .

[10]  Ulli Drescher,et al.  Fluid selection for the Organic Rankine Cycle (ORC) in biomass power and heat plants , 2007 .

[11]  Feridun Hamdullahpur,et al.  Exergy analysis of an integrated solid oxide fuel cell and organic Rankine cycle for cooling, heating and power production , 2010 .

[12]  J. I. Linares,et al.  Power cycle assessment of nuclear high temperature gas-cooled reactors , 2009 .

[13]  H V Álvaro Restrepo,et al.  Estudio y analisis de estrategias de ahorro de energía usando el software ees (engineering equation solver) para la empresa frigorifico de pereira s.a. , 2007 .

[14]  Mohamed S. El-Genk,et al.  Noble gas binary mixtures for gas-cooled reactor power plants , 2008 .

[15]  R. Kehlhofer,et al.  Combined-cycle gas and steam turbine power plants. 2. edition , 1991 .

[16]  M. J. Moran,et al.  Thermal design and optimization , 1995 .

[17]  Hoseyn Sayyaadi,et al.  Various approaches in optimization of a typical pressurized water reactor power plant , 2009 .

[18]  Hoseyn Sayyaadi,et al.  Exergoeconomic optimization of a 1000 MW light water reactor power generation system , 2009 .

[19]  Mortaza Yari,et al.  Utilization of waste heat from GT-MHR for power generation in organic Rankine cycles. , 2010 .

[20]  Mohamed S. El-Genk,et al.  Performance analyses of VHTR plants with direct and indirect closed Brayton cycles and different working fluids , 2009 .

[21]  Mortaza Yari.  Waste Heat Recovery From Closed Brayton Cycle Using Organic Rankine Cycle: Thermodynamic Analysis , 2009 .

[22]  Y. Nomoto,et al.  Study of steam, helium and supercritical CO2 turbine power generations in prototype fusion power reactor , 2008 .

[23]  George Kosmadakis,et al.  Parametric theoretical study of a two-stage solar organic Rankine cycle for RO desalination , 2010 .

[24]  Mortaza Yari,et al.  Performance analysis of the different Organic Rankine Cycles (ORCs) using dry fluids , 2009 .

[25]  Mohamed Darwish,et al.  Combining the nuclear power plant steam cycle with gas turbines , 2010 .

[26]  Pedro J. Mago,et al.  An examination of regenerative organic Rankine cycles using dry fluids , 2008 .

[27]  Mortaza Yari,et al.  Exergetic analysis of various types of geothermal power plants , 2010 .

[28]  N. Lai,et al.  Working fluids for high-temperature organic Rankine cycles , 2007 .

[29]  P. Mago,et al.  Performance analysis of different working fluids for use in organic Rankine cycles , 2007 .

[30]  Mohamed S. El-Genk,et al.  On the use of noble gases and binary mixtures as reactor coolants and CBC working fluids , 2008 .

[31]  Paolo Iora,et al.  Bottoming micro-Rankine cycles for micro-gas turbines , 2007 .

[32]  J. Horlock,et al.  Advanced Gas Turbine Cycles , 2003 .

[33]  Alberto Coronas,et al.  Modelling and optimisation of solar organic rankine cycle engines for reverse osmosis desalination , 2008 .

[34]  S. Nisan,et al.  Economic evaluation of nuclear desalination systems , 2007 .

[35]  Maria Jonsson,et al.  Advanced power cycles with mixture as the working fluid , 2003 .

[36]  S. E. Belov,et al.  Evaluation of alternate power conversion unit designs for the GT-MHR , 2008 .

[37]  Mehmet Kanoglu,et al.  Performance and parametric investigation of a binary geothermal power plant by exergy , 2008 .

[38]  Jiang Wang,et al.  Performance evaluation of a low-temperature solar Rankine cycle system utilizing R245fa , 2010 .

[39]  D. Sánchez,et al.  Alternative ORC bottoming cycles FOR combined cycle power plants , 2009 .

[40]  Michael Bartlett.  Developing Humidified Gas Turbine Cycles , 2002 .

[41]  Agostino Gambarotta,et al.  Internal Combustion Engine (ICE) bottoming with Organic Rankine Cycles (ORCs) , 2010 .

[42]  K. C. Midkiff,et al.  Improving the Efficiency of the Advanced Injection Low Pilot Ignited Natural Gas Engine Using Organic Rankine Cycles , 2008 .

[43]  Costante Mario Invernizzi,et al.  Heat recovery from Diesel engines: A thermodynamic comparison between Kalina and ORC cycles , 2010 .

[44]  Andreas Schuster,et al.  Energetic and economic investigation of Organic Rankine Cycle applications , 2009 .