Interaction between CO2-mass transfer, light availability, and hydrodynamic stress in the growth of phaeodactylum tricornutum in a concentric tube airlift photobioreactor

The microalga Phaeodactylum tricornutum was grown in a concentric tube airlift photobioreactor. A maximum specific growth rate of 0. 023 h-1 was obtained using a superficial gas velocity around 0.055 m/s. Lower or higher gas flow rates limited the culture performance. To establish if the observed limitation was due to CO2 or to the photosynthetically active irradiance, characteristic times for mixing, mass transfer and CO2 consumption, and the photon flux absorbed by the culture were analyzed. The CO2-gradients in the culture were shown to be responsible for the limitation during the exponential growth phase, and both CO2 and light irradiance were limiting in the linear growth phase. The decrease in specific growth rate relative to the maximum was found to be related to the specific gas-liquid interfacial area, the length scale of the microeddies and the shear rate. Copyright 1998 John Wiley & Sons, Inc.

[1]  D. J. Pollard,et al.  Saccharomyces cerevisiae fermentations in a pilot scale airlift bioreactor: Comparison of air sparger configurations , 1996 .

[2]  Raymond E. Spier,et al.  Effect of gas—liquid interfaces on the growth of suspended mammalian cells: mechanisms of cell damage by bubbles , 1989 .

[3]  A. Schumpe,et al.  Gas holdups, specific interfacial areas, and mass transfer coefficients of aerated carboxymethyl cellulose solutions in a bubble column , 1982 .

[4]  C. Wilke,et al.  Mathematical representation of batch culture data , 1968 .

[5]  K. Ohtaguchi,et al.  Gas‐Sparged bioreactors for CO2 fixation by Dunaliella tertiolecta , 1995 .

[6]  N. Wang,et al.  Cell inactivation in the presence of sparging and mechanical agitation , 1992, Biotechnology and bioengineering.

[7]  Daniel I. C. Wang,et al.  Viscous reduction of turbulent damage in animal cell culture , 1989, Biotechnology and bioengineering.

[8]  F. G. Fernández,et al.  Evaluation of photosynthetic efficiency in microalgal cultures using averaged irradiance , 1997 .

[9]  SPLIT-CYLINDER AIRLIFT REACTORS: HYDRAULICS AND HYDRODYNAMICS OF A NEW MODE OF OPERATION , 1996 .

[10]  Robert S. Cherry,et al.  Hydrodynamic effects on cells in agitated tissue culture reactors , 1986 .

[11]  G. Torzillo,et al.  A two‐plane tubular photobioreactor for outdoor culture of Spirulina , 1993, Biotechnology and bioengineering.

[12]  Daniel Chaumont,et al.  Cell fragility — The key problem of microalgae mass production in closed photobioreactors , 1991 .

[13]  J. Chalmers,et al.  Quantification of damage to suspended insect cells as a result of bubble rupture , 1994, Biotechnology and bioengineering.

[14]  Yusuf Chisti,et al.  Characterization of shear rates in airlift bioreactors for animal cell culture , 1997 .

[15]  J. E. Mann,et al.  ON PIGMENTS, GROWTH, AND PHOTOSYNTHESIS OF PHAEODACTYLUM TRICORNUTUM 1 2 , 1968, Journal of phycology.

[16]  Alvin W. Nienow,et al.  Influence of Agitation and Sparging on the Growth Rate and Infection of Insect Cells in Bioreactors and a Comparison with Hybridoma Culture , 1996 .

[17]  Arvo Lannus,et al.  Gas‐Liquid Reactions , 1970 .

[18]  J Tramper,et al.  Lethal events during gas sparging in animal cell culture , 1991, Biotechnology and bioengineering.

[19]  Jose C. Merchuk,et al.  Distribution of energy dissipation in airlift reactors , 1995 .

[20]  R. Cherry,et al.  Cell Death in the Thin Films of Bursting Bubbles , 1992, Biotechnology progress.

[21]  Toshiro Maruyama,et al.  The flow transition in a bubble column. , 1981 .

[22]  D D Ryu,et al.  Effects of rheological properties and mass transfer on plant cell bioreactor performance: Production of tropane alkaloids , 1993, Biotechnology and bioengineering.

[23]  A. Fischer,et al.  Cultivation of photoautotrophic plant cell suspensions in the bioreactor: Influence of culture conditions☆ , 1995 .

[24]  E. Molina Grima,et al.  A mathematical model of microalgal growth in light-limited chemostat culture , 1994 .

[25]  C. D. de Gooijer,et al.  Hydrodynamics and mixing in a multiple air‐lift loop reactor , 1993, Biotechnology and bioengineering.

[26]  F. G. Fernández,et al.  A model for light distribution and average solar irradiance inside outdoor tubular photobioreactors for the microalgal mass culture. , 1997, Biotechnology and bioengineering.

[27]  Cells and bubbles in sparged bioreactors , 1994 .

[28]  J. M. Vlak,et al.  Bubble-column design for growth of fragile insect cells , 1988 .

[29]  R. Calabrese,et al.  Unified modeling framework of cell death due to bubbles in agitated and sparged bioreactors. , 1994, Journal of biotechnology.

[30]  Maria Gavrilescu,et al.  Cultivation of a filamentous mould in an airlift bioreactor , 1995 .

[31]  J. Merchuk,et al.  On the first-order approximation to the response of dissolved oxygen electrodes for dynamic KLa estimation. , 1990, Biotechnology and bioengineering.

[32]  Yoshitomo Watanabe,et al.  Photosynthetic performance of a helical tubular photobioreactor incorporating the cyanobacterium spirulina platensis , 1995, Biotechnology and bioengineering.

[33]  M. Moo-young,et al.  Effects of the hydrodynamic environment and shear protectants on survival of erythrocytes in suspension. , 1995, Journal of biotechnology.

[34]  J. Whyte.  Biochemical composition and energy content of six species of phytoplankton used in mariculture of bivalves , 1987 .

[35]  N. H. Thomas,et al.  Liquid-phase properties and sparger design effects in an external-loop airlift reactor , 1995 .

[36]  Jose C. Merchuk,et al.  Gas hold-up and liquid velocity in a two-dimensional air lift reactor , 1986 .

[37]  E. Molina Grima,et al.  Outdoor chemostat culture of Phaeodactylum tricornutum UTEX 640 in a tubular photobioreactor for the production of eicosapentaenoic acid , 1994, Biotechnology and Applied Biochemistry.