Fuel consumption and emissions from a vehicle operating with ethanol, gasoline and hydrogen produced on-board

Abstract This paper investigates fuel consumption and pollutant emissions from a vehicle operating with gasoline-ethanol blend (E22), hydrous ethanol (E100) and hydrogen produced on-board. The study aims to find out if hydrogen can contribute to reduce fuel consumption and emissions. Hydrogen was produced by a hydrolytic cell adapted to the vehicle, and was mixed to the air charge in the intake pipe. A production automobile powered by a 1.0-L flexible fuel engine was used in the tests. The vehicle was tested on a chassis dynamometer, with the engine operating at idle speed and at 1400 rev/min. The results show that small amounts of hydrogen can provide stable engine operation with lean fuel-air mixture and, thus, reduce fuel consumption without compromising exhaust emission levels. Reductions of up to 11.8% and 13.1% on fuel consumption were obtained for E22 and E100, respectively.

[1]  Shuofeng Wang,et al.  Cyclic variation in a hydrogen-enriched spark-ignition gasoline engine under various operating conditions , 2012 .

[2]  Xiaohong Gao,et al.  Effects of hydrogen addition on the premixed laminar-flames of ethanol–air gaseous mixtures: An experimental study , 2012 .

[3]  Shuofeng Wang,et al.  Effect of hydrogen addition on combustion and emissions performance of a spark ignition gasoline engine at lean conditions , 2009 .

[4]  Bo Zhang,et al.  Effect of hydrogen addition on combustion and emissions performance of a spark-ignited ethanol engine at idle and stoichiometric conditions , 2010 .

[5]  J. Yamin,et al.  The effect of hydrogen addition on premixed laminar acetylene–hydrogen–air and ethanol–hydrogen–air flames , 2013 .

[6]  José Ricardo Sodré,et al.  Hydrous ethanol vs. gasoline-ethanol blend: Engine performance and emissions , 2010 .

[7]  S. J. Kline,et al.  Describing Uncertainties in Single-Sample Experiments , 1953 .

[8]  Syed Yousufuddin,et al.  Effect of ignition timing and compression ratio on the performance of a hydrogen–ethanol fuelled engine , 2009 .

[9]  Carlos Rodríguez Monroy,et al.  Critical analysis on hydrogen as an alternative to fossil fuels and biofuels for vehicles in Europe , 2010 .

[10]  John B. Heywood,et al.  Internal combustion engine fundamentals , 1988 .

[11]  Shuofeng Wang,et al.  Combustion and emissions performance of a hybrid hydrogen–gasoline engine at idle and lean conditions , 2010 .

[12]  M. A. Ceviz,et al.  Thermal balance of a four stroke SI engine operating on hydrogen as a supplementary fuel , 2003 .

[13]  Zunhua Zhang,et al.  A novel strategy for hydrous-ethanol utilization: Demonstration of a spark-ignition engine fueled with hydrogen-rich fuel from an onboard ethanol/steam reformer , 2013 .

[14]  G. Marbán,et al.  Towards the hydrogen economy , 2007 .

[15]  Zunhua Zhang,et al.  Experimental determination of laminar burning velocities and Markstein lengths for 75% hydrous-ethan , 2011 .

[16]  A. Ota,et al.  The Effect of Ethanol Fuel on a Spark Ignition Engine , 2006 .

[17]  V. Balasubramanian,et al.  Hydrogen fueled spark ignition engine with electronically controlled manifold injection: An experimental study , 2008 .

[18]  A. Sen,et al.  Engine performance, exhaust emissions, and cyclic variations in a lean-burn SI engine fueled by gasoline–hydrogen blends , 2012 .

[19]  Jian Zhang,et al.  Improving the performance of a gasoline engine with the addition of hydrogen–oxygen mixtures , 2011 .

[20]  Paul A. Erickson,et al.  Experimental results of hydrogen enrichment of ethanol in an ultra-lean internal combustion engine , 2014 .

[21]  Shuofeng Wang,et al.  Strategies for improving the idle performance of a spark-ignited gasoline engine , 2012 .

[22]  José Ricardo Sodré,et al.  An Improved Model for Spark Ignition Engine Exhaust Hydrocarbons , 1997 .

[23]  James Turner,et al.  Alcohol-based fuels in high performance engines , 2007 .

[24]  Maher A.R. Sadiq Al-Baghdadi.  Hydrogen–ethanol blending as an alternative fuel of spark ignition engines , 2003 .

[25]  J. Sodré,et al.  Further Improvements on a HC Emissions Model: Partial Burn Effects , 1999 .