Evaluation of MSW organic fraction for composting: Separate collection or mechanical sorting

Abstract Organic fraction (OF) from municipal solid waste (MSW) was sampled from several Spanish composting facilities just before the composting process began, considering the two groups of OF treated at the current time: OF from source sorted collection (SC) and OF from non-source sorted collection but selected in the plant by mechanical devices (MS). Moisture content (MC), pH, electric conductivity (EC), total organic matter (TOM), resistant organic matter (ROM), organic nitrogen (org-N), resistant organic nitrogen (nh-N), and soluble inorganic nitrogen (NH4+-N) were analysed from both samples. These parameters are significant in the composting process and have environmental implications. Most of the Spanish composting facilities treat MS from the MSW collected in mass. This study was carried out to assess and underline the variation in the composition of OF depending on the sorting system. Significant differences were detected between the two groups. SC showed higher values for MC, TOM, org-N than MS which resulted in the highest pH and EC values. No differences were detected for ROM and nh-N, indicating a similar degradable potential. Based on the results of this study, it is recommended that the composting process be carried out in a way that reflects the category of OF treated as well as considering the addition of yard trimmings to avoid leachates formation, balance the C/N ratio and improve aeration.

[1]  Trine Lund Hansen,et al.  Assessment of sampling and chemical analysis of source-separated organic household waste. , 2004, Waste management.

[2]  Bestamin Ozkaya,et al.  Addressing the operational problems in a composting and recycling plant. , 2006, Waste management.

[3]  S. Smårs,et al.  Improvement of the composting time for household waste during an initial low pH phase by mesophilic temperature control. , 2002, Bioresource technology.

[4]  E. Superior,et al.  ORGANIC WASTE IN SPAIN: A PROBLEM THAT SHOULD BE A RESOURCE , 2004 .

[5]  Håkan Jönsson,et al.  SE—Structures and Environment , 2001 .

[6]  S. Mor,et al.  Municipal solid waste characterization and its assessment for potential methane generation: a case study. , 2006, The Science of the total environment.

[7]  Kiril Hristovski,et al.  The municipal solid waste system and solid waste characterization at the municipality of Veles, Macedonia. , 2007, Waste Management.

[8]  Jacques G. Fuchs,et al.  Compost and digestate sustainability, benefits, impacts for the environment and for plant production Proceedings of the International Congress CODIS 2008, Solothurn, Switzerland, 27-29 February, 2008 , 2008 .

[9]  T. Manios,et al.  The composting potential of different organic solid wastes: experience from the island of Crete. , 2004, Environment international.

[10]  M. Álvarez,et al.  Factors that affect the quality of the bio-waste fraction of selectively collected solid waste in Catalonia. , 2008, Waste management.

[11]  R. Haug.  The Practical Handbook of Compost Engineering , 1993 .

[12]  Bo H. Svensson,et al.  CHEMICAL CHARACTERIZATION OF SOURCE-SEPARATED ORGANIC HOUSEHOLD WASTES , 1997 .

[13]  M. Bertoldi,et al.  Compost: Production, Quality, and Use , 1987 .

[14]  Francesc Giró,et al.  Situation of the source separated collection of Biowaste in Catalunya. Balance of one decade (1993-2003). , 2003 .

[15]  Suzelle Barrington,et al.  Characterization of food waste and bulking agents for composting. , 2008, Waste management.

[16]  H. Kirchmann,et al.  Separately collected organic household wastes. Chemical composition and composting characteristics , 1994 .

[17]  C. Sundberg,et al.  Higher pH and faster decomposition in biowaste composting by increased aeration. , 2008, Waste management.

[18]  M. Hamoda,et al.  Evaluation of municipal solid waste composting kinetics , 1998 .

[19]  F. Pomares,et al.  Changes in physical, chemical and physico-chemical parameters during the composting of municipal solid wastes in two plants in Valencia , 1995 .

[20]  Robert K Ham,et al.  Carbon dioxide and ammonia emissions during composting of mixed paper, yard waste and food waste. , 2006, Waste management.

[21]  A P Gomes,et al.  Separate collection of the biodegradable fraction of MSW: an economic assessment. , 2008, Waste management.

[22]  H. Hoitink,et al.  Science and Engineering of Composting , 1993 .

[23]  Kiyohiko Nakasaki,et al.  Effects of pH Control On Composting of Garbage , 1993 .

[24]  James I. Chang,et al.  Effects of compositions on food waste composting. , 2008, Bioresource technology.

[25]  Montserrat Soliva Torrentó,et al.  Organic wastes as a resource for Mediterranean soils , 2002 .

[26]  H. Kirchmann,et al.  Composting and storage of organic household waste with different litter amendments. I: carbon turnover , 2000 .

[27]  Håkan Jönsson,et al.  Composting of Source-Separated Household Organics At Different Oxygen Levels: Gaining an Understanding of the Emission Dynamics , 2003 .

[28]  S. M. Schaub,et al.  Composting: An alternative waste management option for food processing industries , 1996 .

[29]  Assessment of heavy metal removal technologies for biowaste by physico‐chemical fractionation , 2003, Environmental technology.

[30]  B. Hamelers,et al.  Advanced bioconversion of biowaste for production of a peat substitute and renewable energy. , 2004, Bioresource technology.

[31]  B. Hamelers,et al.  Sources of Cd, Cu, Pb and Zn in biowaste. , 2002, The Science of the total environment.

[32]  M. Statheropoulos,et al.  A study of volatile organic compounds evolved in urban waste disposal bins , 2005 .

[33]  C. Sundberg,et al.  Low pH as an inhibiting factor in the transition from mesophilic to thermophilic phase in composting. , 2004, Bioresource technology.

[34]  M. Switzenbaum,et al.  Effect of Amendment on Nitrogen Conservation in Wastewater Biosolids Composting , 1994 .

[35]  Carlos García,et al.  Characterization of Urban Wastes According To Fertility and Phytotoxicity Parameters , 1997 .

[36]  Jes la Cour Jansen,et al.  Composition of source-sorted municipal organic waste collected in Danish cities. , 2007, Waste management.

[37]  P. Ramos,et al.  Biodegradable municipal solid waste: characterization and potential use as animal feedstuffs. , 2005, Waste management.

[38]  H. Kirchmann,et al.  Composting and storage of organic household waste with different litter amendments. II: nitrogen turnover and losses. , 2000 .

[39]  H. B. Gotaas,et al.  Composting; sanitary disposal and reclamation of organic wastes. , 1956, Monograph series. World Health Organization.

[40]  Robert K Ham,et al.  The effect of lignin and sugars to the aerobic decomposition of solid wastes. , 2003, Waste management.

[41]  Jes la Cour Jansen,et al.  Effects of pre-treatment technologies on quantity and quality of source-sorted municipal organic waste for biogas recovery. , 2007, Waste management.