Determination of acoustic speed for improving leak detection and location in gas pipelines.

The commonly used cross-correlation technique for leak location requires that the acoustic speed is known and invariable. In practice, the gas leakage-induced acoustic waves propagate along multiple paths including in-pipe gas and pipe wall, and the acoustic waves in different transmission paths exhibit different acoustic speeds and different dispersive behaviors, which bring a great challenge for leak detection and location in the gas pipelines. In this study, based on the vibration theory of cylindrical elastic thin shell, the wavenumber formulae in different transmission paths are derived to predict the acoustic speeds and the acoustical coupling between the in-pipe gas and the pipe wall is analyzed to determine the dominant transmission path. In addition, the velocity dispersions in the dominant transmission path are suppressed by selection of a characteristic frequency band of the gas leakage-induced acoustic waves. The theoretical predictions are verified in the experiment and the results show that the theoretical acoustic speed is slightly larger than the measured acoustic speed. Thus, the theoretical acoustic speed formula is modified considering the effect of the structural loss factor and consequently the location error using the modified acoustic speed is reduced by two times compared to that using the theoretical acoustic speed.

[1]  G. W. Morgan,et al.  WAVE PROPAGATION THROUGH FLUID CONTAINED IN A CYLINDRICAL, ELASTIC SHELL , 1956 .

[2]  Li Yuxing,et al.  Experimental study on leak detection and location for gas pipeline based on acoustic method , 2012 .

[3]  Michael J. Brennan,et al.  Axisymmetric wave propagation in fluid-filled pipes: wavenumber measurements in in vacuo and buried pipes , 2004 .

[4]  Peter Cawley,et al.  Guided Waves in Fluid-Filled Pipes Surrounded by Different Fluids: Prediction and Measurement , 1999 .

[5]  T. Plona,et al.  Axisymmetric wave propagation in fluid‐loaded cylindrical shells. I: Theory , 1992 .

[6]  G. Carter,et al.  The generalized correlation method for estimation of time delay , 1976 .

[7]  Ping Li,et al.  A new method for unbiased time‐delay estimation in noisy environments , 2007 .

[8]  Ping Li,et al.  Study on an improved acoustic leak detection method for water distribution systems , 2013 .

[9]  D. Gazis.  Three‐Dimensional Investigation of the Propagation of Waves in Hollow Circular Cylinders. I. Analytical Foundation , 1959 .

[10]  L. Lafleur,et al.  LOW-FREQUENCY PROPAGATION MODES IN A LIQUID-FILLED ELASTIC TUBE WAVEGUIDE , 1995 .

[11]  F. Fahy,et al.  Characteristics of wave propagation and energy distributions in cylindrical elastic shells filled with fluid , 1982 .

[12]  A. Safaai-Jazi,et al.  Cutoff Conditions in an Acoustic Fiber with Infinitely Thick Cladding , 1986, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[13]  Jin Yang,et al.  Adaptive Leak Detection and Location in Underground Buried Pipelines , 2004, Int. J. Inf. Acquis..

[14]  C. K. Jen,et al.  Leaky torsional acoustic modes in infinite clad rods , 1994 .

[15]  Wei Liang,et al.  Gas pipeline leakage detection based on acoustic technology , 2013 .

[16]  R. N. Thurston.  Elastic waves in rods and clad rods , 1978 .

[17]  Michael J. Brennan,et al.  Wavenumber prediction of waves in buried pipes for water leak detection , 2002 .

[18]  W. Jacobi.  Propagation of Sound Waves along Liquid Cylinders , 1949 .

[19]  L. Elvira-Segura.  Acoustic wave dispersion in a cylindrical elastic tube filled with a viscous liquid. , 2000, Ultrasonics.

[20]  Ping Li,et al.  Leak location using blind system identification in water distribution pipelines , 2008 .

[21]  H. V. Fuchs,et al.  Ten years of experience with leak detection by acoustic signal analysis , 1991 .

[22]  R. J. Pinnington,et al.  Externally Applied Sensor for Axisymmetric Waves in a Fluid Filled Pipe , 1994 .

[23]  Ping Li,et al.  Dynamic discrimination of convergence of the LMS time delay estimation in complicated noisy environments , 2007 .

[24]  R. L. Brown,et al.  Measurement of Acoustic Impedances of Surfaces in Water , 1947 .

[25]  Ping Li,et al.  The genetic-algorithm-enhanced blind system identification for water distribution pipeline leak detection , 2007 .

[26]  M. Lighthill.  On sound generated aerodynamically I. General theory , 1952, Proceedings of the Royal Society of London. Series A. Mathematical and Physical Sciences.

[27]  Peter Cawley,et al.  Guided waves in fluid-filled pipes surrounded by different fluids , 2001 .

[28]  Jennifer M. Muggleton,et al.  Wavenumber prediction and measurement of axisymmetric waves in buried fluid-filled pipes: Inclusion of shear coupling at a lubricated pipe/soil interface , 2013 .

[29]  Arthur H. Fitch,et al.  Observation of Elastic‐Pulse Propagation in Axially Symmetric and Nonaxially Symmetric Longitudinal Modes of Hollow Cylinders , 1963 .

[30]  Maurice A. Biot,et al.  Propagation of elastic waves in a cylindrical bore containing a fluid , 1952 .