Effects of heat treatment and concentration on the luminescence properties of erbium-doped silica sol–gel films

Abstract Erbium-doped sol–gel films with different Er concentrations were formed by spin-coating a solution of erbium-nitrate, tetra-ethoxy-silane (TEOS), ethanol, water and HCl on a Si substrate. Refractive index, film thickness and composition were measured as a function of Er concentration. The Er/Si ratio in the film is roughly proportional to the Er/Si ratio in solution, while the Si/O ratio varies with the Er concentration. The film thickness increases with increasing Er concentration, which is attributed to the increased viscosity of the spin-coat solution compared to pure SiO 2 . All films show a lower refractive index and atomic density than pure SiO 2 , which is ascribed to a slightly porous structure. After annealing at 750 °C in vacuum the films show clear room-temperature luminescence at 1.53 μm from Er 3+ . The luminescence lifetime is rather constant (10–12 ms) up to Er concentrations of 1.0 at.%. The luminescence lifetime reduces significantly if annealing is performed in air rather than in vacuum.

[1]  Hyungsoo Choi,et al.  Fabrication of highly concentrated Er3+ doped aluminosilicate films via sol‐gel processing , 1995 .

[2]  V. Gapontsev,et al.  BRIEF COMMUNICATIONS: Mechanism and parameters of the quenching of luminescence of rare-earth ions by hydroxyl impurity groups in laser phosphate glass , 1981 .

[3]  S. Tero-Kubota,et al.  Photo-properties of rare earth ion (Er3+, Eu3+ and Sm3+)-doped alumina films prepared by the sol–gel method , 1998 .

[4]  Pieter G. Kik,et al.  Erbium-Doped Optical-Waveguide Amplifiers on Silicon , 1998 .

[5]  V. Dierolf,et al.  Combined excitation-emission spectroscopy of Er 3¿ ions in stoichiometric LiNbO 3 : The site selectivity of direct and up conversion excitation processes , 2000 .

[6]  Polman,et al.  Measuring and modifying the spontaneous emission rate of erbium near an interface. , 1995, Physical review letters.

[7]  Pieter G. Kik,et al.  Concentration quenching in erbium implanted alkali silicate glasses , 1996 .

[8]  Pieter G. Kik,et al.  Strong exciton-erbium coupling in Si nanocrystal-doped SiO2 , 2000 .

[9]  L. Klein.  Sol-Gel Processing of Silicates , 1985 .

[10]  L. H. Slooff,et al.  Erbium-implanted silica colloids with 80% luminescence quantum efficiency , 2000 .

[11]  S. Bruynooghe,et al.  Preparation and characterization of Nd 3+ and Er 3+ -doped silica sol-gel coatings by Rutherford backscattering spectroscopy and spectroscopic ellipsometry , 1997 .

[12]  A. Polman,et al.  Erbium implanted thin film photonic materials , 1997 .

[13]  Salvatore Lombardo,et al.  Room‐temperature luminescence from Er‐implanted semi‐insulating polycrystalline silicon , 1993 .

[14]  Morio Kobayashi,et al.  Amplification in erbium-doped silica-based planar lightwave circuits , 1992 .

[15]  Rui M. Almeida,et al.  Fabrication and characterization of sol‐gel planar waveguides doped with rare‐earth ions , 1996 .

[16]  Yingchao Yan,et al.  Luminescence quenching by OH groups in highly Er-doped phosphate glasses , 1995 .

[17]  Keiichi Yamamoto,et al.  1.54 μm photoluminescence of Er3+ doped into SiO2 films containing Si nanocrystals: Evidence for energy transfer from Si nanocrystals to Er3+ , 1997 .

[18]  Min-quan Wang,et al.  Spectroscopic studies of rare earth ions in silica glasses prepared by the sol-gel process , 1996 .

[19]  Jean-Pierre Vilcot,et al.  Preparation and characterization of sol-gel derived Er3+: Al2O3–SiO2 planar waveguides , 1997 .

[20]  T. Kitagawa,et al.  Erbium-doped phosphosilicate glass waveguide amplifier fabricated by PECVD , 1993 .

[21]  R R Syms,et al.  Fabrication of buried channel waveguides on silicon substrates using spin-on glass. , 1993, Applied optics.

[22]  B. Stone,et al.  Fluorescence properties of Er3+-doped sol—gel glasses , 1996 .