Nanopillars array for surface enhanced Raman scattering

We present a new class of surface-enhanced Raman scattering (SERS) substrates based on lithographically-defined two-dimensional rectangular array of nanopillars. Two types of nanopillars within this class are discussed: vertical pillars and tapered pillars. For the vertical pillars, the gap between each pair of nanopillars is small enough (< 50 nm) such that highly confined plasmonic cavity resonances are supported between the pillars when light is incident upon them, and the anti-nodes of these resonances act as three-dimensional hotspots for SERS. For the tapered pillars, SERS enhancement arises from the nanofocusing effect due to the sharp tip on top. SERS experiments were carried out on these substrates using various concentrations of 1,2 bis-(4-pyridyl)-ethylene (BPE), benzenethiol (BT) monolayer and toluene vapor. The results show that SERS enhancement factor of over 0.5 x 109 can be achieved, and BPE can be detected down to femto-molar concentration level. The results also show promising potential for the use of these substrates in environmental monitoring of gases and vapors such as volatile organic compounds.

[1]  C. A. Murray,et al.  Silver-Molecule Separation Dependence of Surface-Enhanced Raman Scattering , 1981 .

[2]  E. A. Wachter,et al.  Hybrid Substrates for Real-Time SERS-Based Chemical Sensors , 1995 .

[3]  R. Dasari,et al.  Single Molecule Detection Using Surface-Enhanced Raman Scattering (SERS) , 1997 .

[4]  Kathy L. Rowlen,et al.  Quantitative Comparison of Five SERS Substrates: Sensitivity and Limit of Detection , 1997 .

[5]  Steven R. Emory,et al.  Probing Single Molecules and Single Nanoparticles by Surface-Enhanced Raman Scattering , 1997, Science.

[6]  Michael D. Perry,et al.  Use of interference lithography to pattern arrays of submicron resist structures for field emission flat panel displays , 1997 .

[7]  Tuan Vo-Dinh,et al.  NEAR-FIELD SURFACE-ENHANCED RAMAN SPECTROSCOPY OF DYE MOLECULES ADSORBED ON SILVER ISLAND FILMS , 1998 .

[8]  C. Haynes,et al.  Nanosphere Lithography: A Versatile Nanofabrication Tool for Studies of Size-Dependent Nanoparticle Optics , 2001 .

[9]  Bruce Mayer,et al.  Transient analysis of carrier gas saturation in liquid source vapor generators , 2001 .

[10]  S. Lieberman,et al.  Detection of volatile organic compounds using surface enhanced Raman spectroscopy substrates mounted on a thermoelectric cooler , 2003 .

[11]  M. Stockman,et al.  Nanofocusing of optical energy in tapered plasmonic waveguides. , 2004, Physical review letters.

[12]  Thomas R Huser,et al.  Surface-enhanced Raman scattering from individual au nanoparticles and nanoparticle dimer substrates. , 2005, Nano letters.

[13]  Jeffrey N. Anker,et al.  Surface-enhanced Raman spectroscopy of benzenethiol adsorbed from the gas phase onto silver film over nanosphere surfaces: determination of the sticking probability and detection limit time. , 2009, The journal of physical chemistry. A.

[14]  Roshan L. Aggarwal,et al.  Measurement of the absolute Raman scattering cross section of the 1584-cm−1 band of benzenethiol and the surface-enhanced Raman scattering cross section enhancement factor for femtosecond laser-nanostructured substrates , 2009 .

[15]  Imran Khan,et al.  Surface enhanced Raman spectroscopy (SERS) sensors for gas analysis. , 2010, The Analyst.

[16]  Mihail Bora,et al.  Plasmon resonant cavities in vertical nanowire arrays. , 2010, Nano letters.

[17]  R Stanley Williams,et al.  Cones fabricated by 3D nanoimprint lithography for highly sensitive surface enhanced Raman spectroscopy , 2010, Nanotechnology.

[18]  Hoang T. Nguyen,et al.  Rigorous surface enhanced Raman spectral characterization of large-area high-uniformity silver-coated tapered silica nanopillar arrays , 2010, Nanotechnology.

[19]  Hyungsoon Im,et al.  Vertically oriented sub-10-nm plasmonic nanogap arrays. , 2010, Nano letters.

[20]  Wen-Di Li,et al.  Three-dimensional cavity nanoantenna coupled plasmonic nanodots for ultrahigh and uniform surface-enhanced Raman scattering over large area. , 2011, Optics express.

[21]  Manas Ranjan Gartia,et al.  Metal-molecule Schottky junction effects in surface enhanced Raman scattering. , 2010, The journal of physical chemistry. A.