Investigations on plasma-polymer-coated SAW and STW resonators for chemical gas-sensing applications

Results from gas probing with various analyte vapors on high-Q low-loss surface transverse wave (STW) and surface acoustic wave (SAW) resonators coated with thin plasma-polymer films of hexamethyldisiloxane (HMDSO), styrene, and allyl alcohol at different polymerization conditions are presented in this paper. At the same acoustic wavelength of 7.22 /spl mu/m and identical film thicknesses, HMDSO-coated STW devices feature substantially higher relative sensitivities to all analytes compared to their SAW counterparts. When operated in a microwave oscillator loop, plasma-poly-styrene and allyl-alcohol-coated STW devices generate strong sensor signals, even at low analyte concentrations, retaining an oscillator short-term stability in the 1/spl times/10/sup -9//s to 1/spl times/10/sup -8//s range. A 250 kHz sensor signal with 7/spl times/10/sup -9//s stability was obtained from a styrene coated 700 MHz STW resonator oscillator at a 1400 parts per million concentration of xylene vapor, which results in a measurement resolution of less than 40 parts per billion for xylene in the ambient air. It is shown that, with respect to sensitivity and stability over long probing periods, plasma-polymer films may become a serious competitor to the more or less unstable soft polymer coatings currently used in SAW-based gas sensors for applications in wireless systems for environmental control and protection.

[1]  W. Buff,et al.  Passive remote sensing for temperature and pressure using SAW resonator devices , 1998, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[2]  A. Pohl,et al.  Wireless sensing using oscillator circuits locked to remote high-Q SAW resonators , 1998, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[3]  G.C. Frye,et al.  Dual output acoustic wave sensors for molecular identification , 1991, TRANSDUCERS '91: 1991 International Conference on Solid-State Sensors and Actuators. Digest of Technical Papers.

[4]  M. Rapp,et al.  On-line monitoring of process HPLC by sensors. , 2000 .

[5]  G. Sauerbrey.  Verwendung von Schwingquarzen zur Wägung dünner Schichten und zur Mikrowägung , 1959 .

[6]  G. C. Frye,et al.  Surface acoustic wave response to changes in viscoelastic film properties , 1990 .

[7]  M. Rapp,et al.  Optimization of an analytical SAW microsystem for organic gas detection , 1995, 1995 IEEE Ultrasonics Symposium. Proceedings. An International Symposium.

[8]  S. Shiokawa,et al.  Simulation of Viscoelastic Effects of Polymer Coatings on Surface Acoustic Wave Gas Sensor under Consideration of Film Thickness. , 1998 .

[9]  Michael Rapp,et al.  Comparative studies on polymer coated SAW and STW resonators for chemical gas sensor applications , 2000, Proceedings of the 2000 IEEE/EIA International Frequency Control Symposium and Exhibition (Cat. No.00CH37052).

[10]  G. Scholl,et al.  Theory and application of passive SAW radio transponders as sensors , 1998, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[11]  J. Reibel,et al.  SAGAS: gas analyzing sensor systems based on surface acoustic wave devices-an issue of commercialization of SAW sensor technology , 1997, Proceedings of International Frequency Control Symposium.

[12]  R. Baer,et al.  STW chemical sensors , 1992, IEEE 1992 Ultrasonics Symposium Proceedings.

[13]  F. Dickert,et al.  Sensor materials for solvent vapor detection—donor–acceptor and host–guest interactions , 1993 .

[14]  Nicole Barié,et al.  UV crosslinked polysiloxanes as new coating materials for SAW devices with high long-term stability , 1998 .

[15]  J. Hilborn,et al.  Detection of deposition rate of plasma-polymerized films by quartz crystal microbalance , 2000 .

[16]  E. Radeva,et al.  High-resolution humidity measurements with surface transverse wave based resonant devices. Applications to wireless remote sensing , 2000 .

[17]  H. Wohltjen,et al.  Elastic Properties of Thin Polymer Films Investigated with Surface Acoustic Wave Devices , 1989 .

[18]  J. Grate,et al.  The fractional free volume of the sorbed vapor in modeling the viscoelastic contribution to polymer-coated surface acoustic wave vapor sensor responses. , 2000, Analytical chemistry.

[19]  Portable acoustic wave sensor systems , 1991, IEEE 1991 Ultrasonics Symposium,.

[20]  E. Radeva,et al.  Effect of plasma polymerization conditions on the humidity sorptive properties of thin films obtained from hexamethyldisiloxane in glow discharge , 1998 .

[21]  C. Hamann,et al.  Glow discharge polymeric films: preparation, structure, properties and applications , 1984 .

[22]  Franz L. Dickert,et al.  Mass‐sensitive detection of solvent vapors: Predicting sensor effects , 1996 .

[23]  R. A. McGill,et al.  Performance optimization of surface acoustic wave chemical sensors , 1997, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[24]  A. Venema,et al.  Love waves for (bio)-chemical sensing in liquids , 1992, IEEE 1992 Ultrasonics Symposium Proceedings.

[25]  Russell Chung,et al.  Performance of an embedded SAW sensor for filter bed monitor and the development of a wireless monitoring prototype system , 1998, Proceedings of the 1998 IEEE International Frequency Control Symposium (Cat. No.98CH36165).