Design and performance improvement of a solar desalination system by using solar air heater: Experimental and theoretical approach

Abstract This paper focuses on the design and performance improvement of a recently developed solar humidification-dehumidification (HDH) desalination system comprising centrifugal air blower, humidification chamber equipped with two electric water heaters (500 W each) and a condenser. To improve the design and performance of this desalination system, a solar air heater was used before the humidification chamber to pre-heat the induced ambient air. Two sets of experiments (I and II) were performed in January 2015 under the similar ambient conditions for all the test days in Madinah (24° 28′ 06″ N, 39° 36′ 51″ E), Saudi Arabia. Experiment set-I was performed without solar air heater and with two electric water heaters whereas experiment set-II was performed with solar air heater and one electric water heater. The results show that daily productivity and Gained Output Ratio (GOR) significantly increased in experiment set-II compared to experiment set-I whereas the Specific Energy Consumption (SEC) and cost per liter of fresh water produced in experiment set-II was greatly reduced compared to that of experiment set-I for the studied range of induced air flow rates.

[1]  Salah Abdallah,et al.  Sun tracking system for productivity enhancement of solar still , 2008 .

[2]  Fahad A. Al-Sulaiman,et al.  Humidification dehumidification desalination system using parabolic trough solar air collector , 2015 .

[3]  Amimul Ahsan,et al.  Parameters affecting the performance of a low cost solar still , 2014 .

[4]  Hiroshi Tanaka,et al.  Increase in distillate productivity by inclining the flat plate external reflector of a tilted-wick solar still in winter , 2009 .

[5]  Abdul Jabbar N. Khalifa,et al.  Performance correlations for basin type solar stills , 2009 .

[6]  K. Kalidasa Murugavel,et al.  An experimental study on single basin double slope simulation solar still with thin layer of water in the basin , 2008 .

[7]  A. E. Kabeel,et al.  Cost analysis of different solar still configurations , 2010 .

[8]  Noreddine Ghaffour,et al.  Renewable energy-driven innovative energy-efficient desalination technologies , 2014 .

[9]  Shahid Rabbani,et al.  Design and Cost Analysis of a Solar Photovoltaic Powered Reverse Osmosis Plant for Masdar Institute , 2015 .

[10]  Nader Rahbar,et al.  Experimental study of a novel portable solar still by utilizing the heatpipe and thermoelectric module , 2012 .

[11]  Khosrow Jafarpur,et al.  Experimental investigation of a multi-effect active solar still: The effect of the number of stages , 2015 .

[12]  Guillermo Zaragoza,et al.  Efficiency in the use of solar thermal energy of small membrane desalination systems for decentralized water production , 2014 .

[13]  Nader Rahbar,et al.  Utilization of thermoelectric cooling in a portable active solar still — An experimental study on winter days , 2011 .

[14]  Govind,et al.  Economic analysis of some solar energy systems , 1984 .

[15]  Sabah A. Abdul-Wahab,et al.  Performance study of the inverted absorber solar still with water depth and total dissolved solid , 2011 .

[16]  A. E. Kabeel,et al.  A hybrid solar desalination system of air humidification–dehumidification and water flashing evaporation , 2013 .

[17]  Scott W. Tyler,et al.  Renewable water: Direct contact membrane distillation coupled with solar ponds , 2015 .

[18]  M. Naim,et al.  Non-conventional solar stills Part 2. Non-conventional solar stills with energy storage element , 2003 .

[19]  Omar Badran,et al.  Experimental study of the enhancement parameters on a single slope solar still productivity , 2007 .

[20]  Frank P. Incropera,et al.  Fundamentals of Heat and Mass Transfer , 1981 .

[21]  Habib Ben Bacha,et al.  Dynamic modeling and experimental validation of a water desalination prototype by solar energy using humidification dehumidification process , 2013 .

[22]  Nabil A.S. Elminshawy,et al.  Experimental and analytical study on productivity augmentation of a novel solar humidification–dehumidification (HDH) system , 2015 .

[23]  T. Höpner,et al.  Environmental impact and impact assessment of seawater desalination , 2008 .

[24]  Majid Amidpour,et al.  Experimental investigation of a two-stage solar humidification- dehumidification desalination process , 2014 .

[25]  K. Srithar,et al.  Solar stills integrated with a mini solar pond — analytical simulation and experimental validation , 2007 .

[26]  S. A. El-Agouz,et al.  A new process of desalination by air passing through seawater based on humidification–dehumidification process , 2010 .

[27]  Majid Amidpour,et al.  Performance optimization of the humidification–dehumidification desalination process using mathematical programming , 2009 .

[28]  A. S. Abdullah.  Improving the performance of stepped solar still , 2013 .

[29]  S. A. Nada,et al.  Performance analysis of proposed hybrid air conditioning and humidification–dehumidification systems for energy saving and water production in hot and dry climatic regions , 2015 .

[30]  Varun,et al.  Solar stills: A review , 2010 .

[31]  A. H. El-Shazly,et al.  Productivity intensification of humidification–dehumidification desalination unit by using pulsed water flow regime , 2012 .

[32]  Rahul Dev,et al.  Characteristic equation of a passive solar still , 2009 .

[33]  Robert F. Mudde,et al.  Maximized production of water by increasing area of condensation surface for solar distillation , 2015 .

[34]  K. Srithar,et al.  SINGLE BASIN SOLAR STILL WITH FIN FOR ENHANCING PRODUCTIVITY , 2008 .

[35]  A. E. Kabeel,et al.  Experimental study of a humidification-dehumidification solar technique by natural and forced air circulation , 2014 .

[36]  Abdulhaiy M. Radhwan,et al.  Transient performance of a stepped solar still withbuilt-in latent heat thermal energy storage , 2005 .

[37]  Ahmed Ouammi,et al.  An optimization model for a mechanical vapor compression desalination plant driven by a wind/PV hybrid system , 2011 .

[38]  Guofeng Yuan,et al.  Mathematical modeling of a closed circulation solar desalination unit with humidification-dehumidification , 2007 .

[39]  Walid A. Abderrahman,et al.  Urban Water Management in Developing Arid Countries , 2000 .

[40]  Ahmed A. Al-Ghamdi,et al.  Active single basin solar still with a sensible storage medium , 2009 .

[41]  Hassan E.S. Fath,et al.  Thermal-economic analysis and comparison between pyramid-shaped and single-slope solar still configurations , 2003 .

[42]  Ruzhu Wang,et al.  Parametric analysis to improve the performance of a solar desalination unit with humidification and dehumidification , 2002 .