A low cost seasonal solar soil heat storage system for greenhouse heating: Design and pilot study

A low cost Seasonal Solar Soil Heat Storage (SSSHS) system used for greenhouse heating was invented and investigated. With soil heat storage technology, the solar energy stored in soil under greenhouse can be utilized to reduce the energy demand of extreme cold and consecutive overcast weather in winter. Unlike conventional underground heat systems, heat pumps are not needed in this system and so the cost is drastically reduced. After the tests, the system proved that seasonal thermal energy storage (STES) is feasible and can partially solve the solar heat demand and supply imbalance problem between summer and winter. TRNSYS is used to simulate the process and effect of solar energy collection and soil heat storage, and the model is calibrated by operational data in a full season. Energy consumption of the SSSHS system and conventional solar heating system have been compared under the same condition: when the indoor air temperature of the greenhouse is kept above 12°C throughout the year, the energy saving in Shanghai was 27.8kWh/(m2 typical greenhouse area⋅year). In the end, the paper discusses the system optimization, including the optimized solar collector area and depth of buried U-pipes, and the results of a pilot test.

[1]  Kadir Bakirci,et al.  Experimental thermal performance of a solar source heat-pump system for residential heating in cold climate region , 2011 .

[2]  Sanford Sillman.  Performance and economics of annual storage solar heating systems , 1981 .

[3]  Z. Fang,et al.  Heat transfer in ground heat exchangers with groundwater advection , 2004 .

[4]  M Inalli,et al.  A computational model of a domestic solar heating system with underground spherical thermal storage , 1997 .

[5]  Mustafa Inalli,et al.  A thermo-economical optimization of a domestic solar heating plant with seasonal storage , 2007 .

[6]  M. Reuss,et al.  Design of a seasonal thermal energy storage in the ground , 1997 .

[7]  Jan-Olof Dalenbäck,et al.  Swedish solar heated residential area with seasonal storage in rock : Initial evaluation , 2008 .

[8]  Ruzhu Wang,et al.  A review of available technologies for seasonal thermal energy storage , 2014 .

[9]  Marshall L. Sweet,et al.  Numerical simulation of underground Seasonal Solar Thermal Energy Storage (SSTES) for a single family dwelling using TRNSYS , 2012 .

[10]  D. Rees.  The onset of Darcy–Brinkman convection in a porous layer: an asymptotic analysis , 2002 .

[11]  Hans Müller-Steinhagen,et al.  Central solar heating plants with seasonal heat storage , 2010 .

[12]  J. Dalenbäck,et al.  A REVIEW OF LARGE-SCALE SOLAR HEATING SYSTEMS IN EUROPE , 1998 .

[13]  Abdelhamid Farhat,et al.  Improvement of the greenhouse climate using a solar air heater with latent storage energy , 2014 .

[14]  Ruzhu Wang,et al.  Performance investigation of a solar heating system with underground seasonal energy storage for greenhouse application , 2014 .

[15]  Hans Müller-Steinhagen,et al.  A thermodynamic and kinetic study of the de- and rehydration of Ca(OH)2 at high H2O partial pressures for thermo-chemical heat storage , 2012 .

[16]  Göran Hellström,et al.  High temperature solar heated seasonal storage system for low temperature heating of buildings , 2000 .

[17]  Tao Yang,et al.  Experimental study of a solar-assisted ground-coupled heat pump system with solar seasonal thermal storage in severe cold areas , 2010 .

[18]  Drury B. Crawley,et al.  EnergyPlus: Energy simulation program , 2000 .

[19]  E. Beshada,et al.  Winter performance of a solar energy greenhouse in southern Manitoba , 2006 .

[20]  Hüseyin Benli,et al.  Evaluation of ground-source heat pump combined latent heat storage system performance in greenhouse heating , 2009 .

[21]  Peter Lund,et al.  A numerical model for seasonal storage of solar heat in the ground by vertical pipes , 1985 .

[22]  V. P. Sethi,et al.  Survey and evaluation of heating technologies for worldwide agricultural greenhouse applications , 2008 .

[23]  Bill Wong,et al.  The Performance of a High Solar Fraction Seasonal Storage District Heating System – Five Years of Operation☆ , 2012 .

[24]  El Khadir Lakhal,et al.  Thermal performance of a greenhouse with a phase change material north wall , 2011 .

[25]  Afif Hasan,et al.  Modeling of greenhouse with PCM energy storage , 2008 .

[26]  Luisa F. Cabeza,et al.  Materials used as PCM in thermal energy storage in buildings: A review , 2011 .

[27]  Amir Vadiee,et al.  Thermal energy storage strategies for effective closed greenhouse design , 2013 .

[28]  G. Hellström.  Ground heat storage : thermal analyses of duct storage systems , 1991 .

[29]  Göran Hellström,et al.  CFD-modelling of natural convection in a groundwater-filled borehole heat exchanger , 2010 .

[30]  Yunfei Dai,et al.  Optimal study of a solar air heating system with pebble bed energy storage , 2011 .

[31]  Jeffrey D. Spitler,et al.  A computationally efficient hybrid time step methodology for simulation of ground heat exchangers , 2011 .

[32]  J. Ni,et al.  Performance evaluation of ground source heat pump system for greenhouse heating in northern China , 2012 .

[33]  R. Tamme,et al.  High Temperature Thermochemical Heat Storage for Concentrated Solar Power Using Gas–Solid Reactions , 2011 .