Catalyst-Free, Selective Growth of ZnO Nanowires on SiO2 by Chemical Vapor Deposition for Transfer-Free Fabrication of UV Photodetectors.

Catalyst-free, selective growth of ZnO nanowires directly on the commonly used dielectric SiO2 layer is of both scientific significance and application importance, yet it is still a challenge. Here, we report a facile method to grow single-crystal ZnO nanowires on a large scale directly on SiO2/Si substrate through vapor-solid mechanism without using any predeposited metal catalyst or seed layer. We found that a rough SiO2/Si substrate surface created by the reactive ion etching is critical for ZnO growth without using catalyst. ZnO nanowire array exclusively grows in area etched by the reactive ion etching method. The advantages of this method include facile and safe roughness-assisted catalyst-free growth of ZnO nanowires on SiO2/Si substrate and the subsequent transfer-free fabrication of electronic or optoelectronic devices. The ZnO nanowire UV photodetector fabricated by a transfer-free process presented high performance in responsivity, quantum efficiency and response speed, even without any post-treatments. The strategy shown here would greatly reduce the complexity in nanodevice fabrication and give an impetus to the application of ZnO nanowires in nanoelectronics and optoelectronics.

[1]  Shang Gao,et al.  Performance enhancement of ZnO UV photodetectors by surface plasmons. , 2014, ACS applied materials & interfaces.

[2]  Yue Zhang,et al.  Transverse piezoelectric field-effect transistor based on single ZnO nanobelts. , 2010, Physical chemistry chemical physics : PCCP.

[3]  G. Shen,et al.  Vertically aligned ZnO nanowires produced by a catalyst-free thermal evaporation method and their field emission properties , 2005 .

[4]  B. Tell,et al.  Raman Effect in Zinc Oxide , 1966 .

[5]  Sang Han Park,et al.  Temperature-dependent catalyst-free growth of ZnO nanostructures on Si and SiO2/Si substrates via thermal evaporation , 2012 .

[6]  M. Meyyappan,et al.  Single Crystal Nanowire Vertical Surround-Gate Field-Effect Transistor , 2004 .

[7]  Peidong Yang,et al.  Nanowire ultraviolet photodetectors and optical switches , 2002 .

[8]  Muhammad Riaz,et al.  Miniaturized pH Sensors Based on Zinc Oxide Nanotubes/Nanorods , 2009, Sensors.

[9]  Peidong Yang,et al.  Nanowire dye-sensitized solar cells , 2005, Nature materials.

[10]  Chunxiang Xu,et al.  Improved UV photoresponse of ZnO nanorod arrays by resonant coupling with surface plasmons of Al nanoparticles. , 2015, Nanoscale.

[11]  E. Monroy,et al.  Wide-bandgap semiconductor ultraviolet photodetectors , 2003 .

[12]  C. Pantano,et al.  Reactive ion etching of glasses: Composition dependence , 2003 .

[13]  J. J. Lee,et al.  Tailoring the coercivity in ferromagnetic ZnO thin films by 3d and 4f elements codoping , 2014 .

[14]  Zhong Lin Wang,et al.  Gigantic enhancement in response and reset time of ZnO UV nanosensor by utilizing Schottky contact and surface functionalization. , 2009, Applied physics letters.

[15]  Pei Lin,et al.  Enhanced performance of ZnO piezotronic pressure sensor through electron-tunneling modulation of MgO nanolayer. , 2015, ACS applied materials & interfaces.

[16]  Sean Li,et al.  Emergent ferromagnetism in ZnO/Al2O3 core-shell nanowires: Towards oxide spinterfaces , 2013 .

[17]  Bo Liang,et al.  Metal oxide nanowire transistors , 2012 .

[18]  Heh-Nan Lin,et al.  Catalyst-free selective-area growth of vertically aligned zinc oxide nanowires , 2008 .

[19]  Photoresponse of multi-walled carbon nanotube-copper sulfide (MWNT-CuS) hybrid nanostructures. , 2011, Physical chemistry chemical physics : PCCP.

[20]  Cesare Soci,et al.  Nanowire photodetectors. , 2010, Journal of nanoscience and nanotechnology.

[21]  Dapeng Yu,et al.  Growth and formation mechanism of c-oriented ZnO nanorod arrays deposited on glass , 2004 .

[22]  Joshua E. Goldberger,et al.  Low‐Temperature Wafer‐Scale Production of ZnO Nanowire Arrays. , 2003 .

[23]  Sean Li,et al.  Ferromagnetic (Mn, N)-codoped ZnO nanopillars array: Experimental and computational insights , 2014 .

[24]  Weiming Du,et al.  Piezotronic effect on ZnO nanowire film based temperature sensor. , 2014, ACS applied materials & interfaces.

[25]  Chengming Jiang,et al.  Significant photoelectric property change caused by additional nano-confinement: a study of half-dimensional nanomaterials. , 2014, Small.

[26]  S. Pennycook,et al.  ZnO Nanoneedles Grown Vertically on Si Substrates by Non‐Catalytic Vapor‐Phase Epitaxy , 2002 .

[27]  Handong Sun,et al.  Surface plasmon enhanced band edge luminescence of ZnO nanorods by capping Au nanoparticles , 2010 .

[28]  Yuan Zhang,et al.  Self-assemblies of Pd nanoparticles on the surfaces of single crystal ZnO nanowires for chemical sensors with enhanced performances , 2009 .

[29]  M. Zacharias,et al.  Reactive VLS and the Reversible Switching between VS and VLS Growth Modes for ZnO Nanowire Growth , 2010 .

[30]  Hyunsung Ko,et al.  Synthesis of nanograined ZnO nanowires and their enhanced gas sensing properties. , 2012, ACS applied materials & interfaces.

[31]  Y. G. Wang,et al.  Adsorption and desorption of oxygen probed from ZnO nanowire films by photocurrent measurements , 2005 .

[32]  C. B. Carter,et al.  Photosensitization of ZnO nanowires with CdSe quantum dots for photovoltaic devices. , 2007, Nano letters.

[33]  Magnus Willander,et al.  ZnO nanorods as an intracellular sensor for pH measurements , 2007 .

[34]  Zhong Lin Wang,et al.  Piezoelectric field effect transistor and nanoforce sensor based on a single ZnO nanowire. , 2006, Nano letters.

[35]  Chengming Jiang,et al.  The smallest resonator arrays in atmosphere by chip-size-grown nanowires with tunable Q-factor and frequency for subnanometer thickness detection. , 2015, Nano letters.

[36]  Fanli Meng,et al.  Catalyst-free growth of one-dimensional ZnO nanostructures on SiO2 substrate and in situ investigation of their H2 sensing properties , 2015 .

[37]  Zhong Lin Wang,et al.  Large-Scale Hexagonal-Patterned Growth of Aligned ZnO Nanorods for Nano-optoelectronics and Nanosensor Arrays. , 2004, Nano letters.

[38]  Eicke R. Weber,et al.  Catalytic Growth of Zinc Oxide Nanowires by Vapor Transport , 2001 .

[39]  Heon-Jin Choi,et al.  Controlled growth of ZnO nanowires and their optical properties , 2002 .

[40]  S. Chua,et al.  Correlating the enhancement of UV luminescence from solution-grown ZnO nanorods with hydrogen doping , 2012 .

[41]  C. Soci,et al.  ZnO nanowire UV photodetectors with high internal gain. , 2007, Nano letters.

[42]  Jun Liu,et al.  Fabrication of fully transparent nanowire transistors for transparent and flexible electronics. , 2007, Nature nanotechnology.

[43]  W. Zhang,et al.  Enhanced UV photoresponse from heterostructured Ag–ZnO nanowires , 2009 .

[44]  Chengming Jiang,et al.  Shear modulus property characterization of nanorods. , 2013, Nano letters.

[45]  Chengming Jiang,et al.  Controllable growth of laterally aligned zinc oxide nanorod arrays on a selected surface of the silicon substrate by a catalyst-free vapor solid process--a technique for growing nanocircuits. , 2013, Physical chemistry chemical physics : PCCP.

[46]  Lianxi Zheng,et al.  Three-dimensional plasmonic photoanodes based on Au-embedded TiO(2) structures for enhanced visible-light water splitting. , 2014, ACS applied materials & interfaces.

[47]  Jun Zhang,et al.  3D hierarchically porous ZnO structures and their functionalization by Au nanoparticles for gas sensors , 2011 .

[48]  M. Jeong,et al.  Catalyst-free growth of ZnO nanowires by metal-organic chemical vapour deposition (MOCVD) and thermal evaporation , 2004 .

[49]  S. Dhara,et al.  Enhanced UV photosensitivity from rapid thermal annealed vertically aligned ZnO nanowires , 2011, Nanoscale research letters.

[50]  Zhong Lin Wang.  Zinc oxide nanostructures: growth, properties and applications , 2004 .

[51]  Gottlieb S. Oehrlein,et al.  Chemical dry etching of silicon nitride and silicon dioxide using CF4/O2/N2 gas mixtures , 1996 .

[52]  M. Willander,et al.  ZnO nanorods as an intracellular sensor for pH measurements. , 2009, Methods in molecular biology.

[53]  T. Venkatesan,et al.  Universal photoluminescence evolution of solution-grown ZnO nanorods with annealing: important role of hydrogen donor , 2011 .

[54]  Li Dongmei,et al.  Synthesizing of ZnO Micro/Nanostructures at Low Temperature with New Reducing Agents , 2008 .

[55]  Lianxi Zheng,et al.  Self-powered, visible-light photodetector based on thermally reduced graphene oxide–ZnO (rGO–ZnO) hybrid nanostructure , 2012 .