Sub-ppb-level CH4 detection by exploiting a low-noise differential photoacoustic resonator with a room-temperature interband cascade laser.

An ultra-highly sensitive and robust CH4 sensor is reported based on a 3.3 µm interband cascade laser (ICL) and a low-noise differential photoacoustic (PAS) cell. The ICL emission wavelength targeted a fundamental absorption line of CH4 at 2988.795 cm-1 with an intensity of 1.08 × 10-19 cm/molecule. The double-pass and differential design of the PAS cell effectively enhanced the PAS signal amplitude and decreased its background noise. The wavelength modulation depth, operating pressure and V-T relaxation promotion were optimized to maximize the sensor detection limit. With an integration time of 90 s, a detection limit of 0.6 ppb was achieved. No additional water or air laser cooling were required and thereby allowing the realization of a compact and robust CH4 sensor.

[1]  Huadan Zheng,et al.  Single-tube on-beam quartz-enhanced photoacoustic spectroscopy. , 2016, Optics letters.

[2]  D. Iannuzzi,et al.  A fiber-tip photoacoustic sensor for in situ trace gas detection. , 2019, The Review of scientific instruments.

[3]  Lei Dong,et al.  QEPAS spectrophones: design, optimization, and performance , 2010 .

[4]  M. Wolff,et al.  High resolution spectra of 13C ethane and propane isotopologues photoacoustically measured using interband cascade lasers near 3.33 and 3.38 µm, respectively , 2019, Journal of Quantitative Spectroscopy and Radiative Transfer.

[5]  Xukun Yin,et al.  Ppb-level QEPAS NO2 sensor by use of electrical modulation cancellation method with a high power blue LED , 2015 .

[6]  Frank K. Tittel,et al.  Allan Deviation Plot as a Tool for Quartz-Enhanced Photoacoustic Sensors Noise Analysis , 2016, IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control.

[7]  Zhan-Wei Song,et al.  Design of a novel gas sensor structure based on mid-infrared absorption spectrum , 2010 .

[8]  Frank K. Tittel,et al.  Development and field deployment of a mid-infrared methane sensor without pressure control using interband cascade laser absorption spectroscopy , 2017 .

[9]  Xin Yu,et al.  Ultra-high sensitive light-induced thermoelastic spectroscopy sensor with a high Q-factor quartz tuning fork and a multipass cell. , 2019, Optics letters.

[10]  F. Tittel,et al.  Sensitive methane detection based on quartz-enhanced photoacoustic spectroscopy with a high-power diode laser and wavelet filtering , 2020 .

[11]  Frank K. Tittel,et al.  Broadband detection of methane and nitrous oxide using a distributed-feedback quantum cascade laser array and quartz-enhanced photoacoustic sensing , 2019, Photoacoustics.

[12]  Frank K. Tittel,et al.  Nitrous oxide quartz-enhanced photoacoustic detection employing a broadband distributed-feedback quantum cascade laser array , 2018, Applied Physics Letters.

[13]  G. Wysocki,et al.  Multi-pass cell-assisted photoacoustic/photothermal spectroscopy of gases using quantum cascade laser excitation and heterodyne interferometric signal detection , 2018 .

[14]  Vincenzo Spagnolo,et al.  Atmospheric CH4 measurement near a landfill using an ICL-based QEPAS sensor with V-T relaxation self-calibration , 2019, Sensors and Actuators B: Chemical.

[15]  Ke Chen,et al.  High-sensitivity fiber-optic acoustic sensor for photoacoustic spectroscopy based traces gas detection , 2017 .

[16]  Frank K. Tittel,et al.  Ppb-level nitric oxide photoacoustic sensor based on a mid-IR quantum cascade laser operating at 52 °C , 2019, Sensors and Actuators B: Chemical.

[17]  A. Kosterev,et al.  Quartz-enhanced photoacoustic spectroscopy. , 2002, Optics letters.

[18]  Frank K. Tittel,et al.  Infrared Dual-Gas CH4/C2H6 Sensor Using Two Continuous-Wave Interband Cascade Lasers , 2016, IEEE Photonics Technology Letters.

[19]  Lei Zhang,et al.  External cavity quantum cascade laser-based QEPAS for chlorodifluoromethane spectroscopy and sensing , 2019, Applied Physics B.

[20]  J S Li,et al.  Contributed review: quantum cascade laser based photoacoustic detection of explosives. , 2015, The Review of scientific instruments.

[21]  Gottfried Strasser,et al.  Picosecond pulses from a mid-infrared interband cascade laser , 2019, Optica.

[22]  M. Sigrist.  Trace gas monitoring by laser photoacoustic spectroscopy and related techniques (plenary) , 2003 .

[23]  Huadan Zheng,et al.  Application of Micro Quartz Tuning Fork in Trace Gas Sensing by Use of Quartz-Enhanced Photoacoustic Spectroscopy , 2019, Sensors.

[24]  Laurent Lamard,et al.  Off-axis QEPAS using a pulsed nanosecond Mid-Infrared Optical Parametric Oscillator , 2016 .

[25]  Olivier Lartigue,et al.  Miniaturized differential Helmholtz resonators for photoacoustic trace gas detection , 2016 .

[26]  Huadan Zheng,et al.  Beat frequency quartz-enhanced photoacoustic spectroscopy for fast and calibration-free continuous trace-gas monitoring , 2017, Nature Communications.

[27]  M. Lassen,et al.  Photo-acoustic sensor for detection of oil contamination in compressed air systems , 2016, 2017 Conference on Lasers and Electro-Optics (CLEO).

[28]  Huadan Zheng,et al.  Quartz-enhanced photoacoustic spectroscopy employing pilot line manufactured custom tuning forks , 2019, Photoacoustics.

[29]  Benli Yu,et al.  Recent Progress on Infrared Photoacoustic Spectroscopy Techniques , 2011 .

[30]  N. P. Sanchez,et al.  Mid-infrared dual-gas sensor for simultaneous detection of methane and ethane using a single continuous-wave interband cascade laser. , 2016, Optics express.

[31]  Vincenzo Spagnolo,et al.  Environmental Monitoring of Methane with Quartz-Enhanced Photoacoustic Spectroscopy Exploiting an Electronic Hygrometer to Compensate the H2O Influence on the Sensor Signal , 2020, Sensors.

[32]  Xukun Yin,et al.  Ppb-level SO2 photoacoustic sensor with suppressed absorption-desorption effect by using a 7.41 μm external-cavity quantum cascade laser. , 2020, ACS sensors.

[33]  Markus W. Sigrist,et al.  Mid-Infrared Photoacoustic Detection of Glucose in Human Skin: Towards Non-Invasive Diagnostics , 2016, Sensors.

[34]  M. Vainio,et al.  Cavity-enhanced cantilever-enhanced photo-acoustic spectroscopy. , 2019, The Analyst.

[35]  Wei Ren,et al.  A portable low-power QEPAS-based CO2 isotope sensor using a fiber-coupled interband cascade laser , 2017 .

[36]  Wei Ren,et al.  Mid-infrared multimode fiber-coupled quantum cascade laser for off-beam quartz-enhanced photoacoustic detection. , 2016, Optics letters.

[37]  Rui Q. Yang.  Infrared laser based on intersubband transitions in quantum wells , 1995 .

[38]  A. Miklós,et al.  Application of acoustic resonators in photoacoustic trace gas analysis and metrology , 2001 .

[39]  F. Tittel,et al.  Quartz-tuning-fork enhanced photothermal spectroscopy for ultra-high sensitive trace gas detection. , 2018, Optics express.

[40]  Frank K. Tittel,et al.  Improved Tuning Fork for Terahertz Quartz-Enhanced Photoacoustic Spectroscopy , 2016, Sensors.

[41]  Differential, LED-excited, resonant NO2 photoacoustic system , 2010 .

[42]  T. Starecki.  Windowless Open Photoacoustic Helmholtz Cell , 2008 .

[43]  Max Deffenbaugh,et al.  Methane, ethane and propane detection using a compact quartz enhanced photoacoustic sensor and a single interband cascade laser , 2019, Sensors and Actuators B: Chemical.

[44]  Huadan Zheng,et al.  Impact of Humidity on Quartz-Enhanced Photoacoustic Spectroscopy Based CO Detection Using a Near-IR Telecommunication Diode Laser , 2016, Sensors.

[45]  Bernhard Lendl,et al.  Compact quantum cascade laser based quartz-enhanced photoacoustic spectroscopy sensor system for detection of carbon disulfide. , 2016, Optics express.

[46]  V. Spagnolo,et al.  Ultra-high sensitive trace gas detection based on light-induced thermoelastic spectroscopy and a custom quartz tuning fork , 2020 .

[47]  Vincenzo Spagnolo,et al.  Quartz-enhanced photoacoustic sensor for ethylene detection implementing optimized custom tuning fork-based spectrophone. , 2019, Optics express.

[48]  Yves Bidaux,et al.  Purely wavelength- and amplitude-modulated quartz-enhanced photoacoustic spectroscopy. , 2016, Optics express.

[49]  C. S. Kim,et al.  Interband Cascade Lasers , 2015, 2020 Conference on Lasers and Electro-Optics (CLEO).

[50]  W. Jin,et al.  Miniature fiber-tip photoacoustic spectrometer for trace gas detection. , 2013, Optics letters.

[51]  Ke Chen,et al.  Fast demodulated white-light interferometry-based fiber-optic Fabry-Perot cantilever microphone. , 2018, Optics letters.

[52]  Lauri Halonen,et al.  Broadband photoacoustic spectroscopy of CH414 with a high-power mid-infrared optical frequency comb. , 2019, Optics letters.

[53]  N. P. Sanchez,et al.  Hydrogen peroxide detection with quartz-enhanced photoacoustic spectroscopy using a distributed-feedback quantum cascade laser , 2014 .

[54]  G. Scamarcio,et al.  Part-per-trillion level SF6 detection using a quartz enhanced photoacoustic spectroscopy-based sensor with single-mode fiber-coupled quantum cascade laser excitation. , 2012, Optics letters.

[55]  Frank K. Tittel,et al.  Quartz-Enhanced Photoacoustic Spectroscopy: A Review , 2014, Sensors.

[56]  Gregor Langer,et al.  Remote mid-infrared photoacoustic spectroscopy with a quantum cascade laser. , 2015, Optics letters.

[57]  Frank K. Tittel,et al.  Compact CH4 sensor system based on a continuous-wave, low power consumption, room temperature interband cascade laser , 2016 .

[58]  V. Koskinen,et al.  Progress in cantilever enhanced photoacoustic spectroscopy , 2008 .

[59]  Jun Chang,et al.  Scanned-wavelength intra-cavity QEPAS sensor with injection seeding technique for C2H2 detection , 2019 .