On interface and oxide degradation in VLSI MOSFETs. II. Fowler-Nordheim stress regime

For pt. I see ibid., vol. 49, pp. 247-53 (2002).The assessment of the physical mechanisms governing the degradation of thin oxides is a very important and, unfortunately, elusive issue that has raised significant debate in recent literature. In this paper, we first use some of the results reported in Pt. I to estimate a reasonable boundary for the efficiency of a possible hydrogen release (HR) mechanism and argue that the HR appears too weak to explain our measurements of stress-induced leakage current (SILC) produced by Fowler-Nordheim (FN) tunneling stress measurements. Then, we present an in-depth investigation of the anode hole injection (AHI) mechanism at low stress gate voltages (V/sub G/). To this purpose, we used both previously discussed and ad hoc devised characterization techniques. Our results indicate that AHI is still operative at V/sub G/ lower than previously experimentally demonstrated. Furthermore, the correlation between the energy of holes at the anode, their injection into the oxide, and the eventual generation of SILC strongly indicate that AHI is the mechanism governing oxide degradation in the considered stress conditions.

[1]  Naohiro Matsukawa,et al.  A hot hole-induced low-level leakage current in thin silicon dioxide films , 1996 .

[2]  D. Frohman-Bentchkowsky,et al.  Dynamic model of trapping‐detrapping in SiO2 , 1985 .

[3]  M. Fischetti,et al.  The effect of gate metal and SiO2 thickness on the generation of donor states at the Si‐SiO2 interface , 1985 .

[4]  J. Stathis,et al.  Ultra-thin oxide reliability for ULSI applications , 2000 .

[5]  M. Bourcerie,et al.  Relaxable damage in hot-carrier stressing of n-MOS transistors-oxide traps in the near interfacial region of the gate oxide , 1990 .

[6]  Stathis,et al.  Atomic hydrogen reactions with Pb centers at the (100) Si/SiO2 interface. , 1994, Physical review letters.

[7]  Tahui Wang,et al.  Investigation of oxide charge trapping and detrapping in a MOSFET by using a GIDL current technique , 1998 .

[8]  J. Bude,et al.  Gate oxide reliability projection to the sub-2 nm regime , 2000 .

[9]  James H. Stathis,et al.  Interface states induced by the presence of trapped holes near the silicon–silicon‐dioxide interface , 1995 .

[10]  M. Ushiyama,et al.  Read-disturb degradation mechanism due to electron trapping in the tunnel oxide for low-voltage flash memories , 1994, Proceedings of 1994 IEEE International Electron Devices Meeting.

[11]  Gerard Ghibaudo,et al.  Analytical study of the contribution of fast and slow oxide traps to the charge pumping current in MOS structures , 1996 .

[12]  David L. Griscom,et al.  Hydrogen model for radiation-induced interface states in SiO2-on-Si Structures: A review of the evidence , 1992 .

[13]  Yuan Taur,et al.  Defect generation in 3.5 nm silicon dioxide films , 1994 .

[14]  M. Wada,et al.  Stress induced leakage current limiting to scale down EEPROM tunnel oxide thickness , 1988, Technical Digest., International Electron Devices Meeting.

[15]  Guido Groeseneken,et al.  New insights in the relation between electron trap generation and the statistical properties of oxide breakdown , 1998 .

[16]  E. Cartier,et al.  MECHANISM FOR STRESS-INDUCED LEAKAGE CURRENTS IN THIN SILICON DIOXIDE FILMS , 1995 .

[17]  Dirk Wellekens,et al.  SILC-related effects in flash E/sup 2/PROM's-Part I: A quantitative model for steady-state SILC , 1998 .

[18]  Dirk Wellekens,et al.  SILC-related effects in flash E/sup 2/PROM's-Part II: Prediction of steady-state SILC-related disturb characteristics , 1998 .

[19]  C. Viswanathan,et al.  Generation of hole traps in thin silicon oxide layers under high‐field electron injection , 1996 .

[20]  Masakazu Shimaya,et al.  Neutral electron trap generation in SiO2 by hot holes , 1990 .

[21]  W. R. Hunter,et al.  Experimental evidence for voltage driven breakdown models in ultrathin gate oxides , 2000, 2000 IEEE International Reliability Physics Symposium Proceedings. 38th Annual (Cat. No.00CH37059).

[22]  M. Lenzlinger,et al.  Fowler‐Nordheim Tunneling into Thermally Grown SiO2 , 1969 .

[23]  P. Lenahan,et al.  Nature of the E’ deep hole trap in metal‐oxide‐semiconductor oxides , 1987 .

[24]  Y. Maneglia,et al.  Extraction of slow oxide trap concentration profiles in metal–oxide–semiconductor transistors using the charge pumping method , 1996 .

[25]  E. Sangiorgi,et al.  Impact ionization and photon emission in MOS capacitors and FETs , 2000, International Electron Devices Meeting 2000. Technical Digest. IEDM (Cat. No.00CH37138).

[26]  J. Bude,et al.  Explanation of soft and hard breakdown and its consequences for area scaling , 1999, International Electron Devices Meeting 1999. Technical Digest (Cat. No.99CH36318).

[27]  C. Hu.  Gate oxide scaling limits and projection , 1996 .

[28]  N. Ajika,et al.  Influence of holes on neutral trap generation , 1997 .

[29]  D. Ielmini,et al.  Experimental and numerical analysis of the quantum yield [MOSFETs] , 2000, International Electron Devices Meeting 2000. Technical Digest. IEDM (Cat. No.00CH37138).

[30]  K. Hess,et al.  An alternative interpretation of hot electron interface degradation in NMOSFETs: isotope results irreconcilable with major defect generation by holes? , 1999 .

[31]  Z. Weinberg,et al.  The relation between positive charge and breakdown in metal‐oxide‐silicon structures , 1987 .

[32]  J. Stathis,et al.  Reliability projection for ultra-thin oxides at low voltage , 1998, International Electron Devices Meeting 1998. Technical Digest (Cat. No.98CH36217).

[33]  M.F. Li,et al.  Role of hole fluence in gate oxide breakdown , 1999, IEEE Electron Device Letters.

[34]  T. Lei,et al.  Monitoring trapped charge generation for gate oxide under stress [MOS capacitors] , 1997 .

[35]  R. Degraeve,et al.  Reliability: a possible showstopper for oxide thickness scaling? , 2000 .

[36]  N. Zamani,et al.  Behavior of the Si/SiO2 interface observed by Fowler-Nordheim tunneling , 1982 .

[37]  K. Eikyu,et al.  A quantitative analysis of time-decay reproducible stress-induced leakage current in SiO/sub 2/ films , 1997 .

[38]  K. R. Farmer,et al.  Time‐dependent positive charge generation in very thin silicon oxide dielectrics , 1992 .

[39]  R.-P. Vollertsen,et al.  Can macroscopic oxide thickness uniformity improve oxide reliability? , 2000, IEEE Electron Device Letters.

[40]  James H. Stathis,et al.  Passivation and depassivation of silicon dangling bonds at the Si/SiO2 interface by atomic hydrogen , 1993 .

[41]  Brower.  Dissociation kinetics of hydrogen-passivated (111) Si-SiO2 interface defects. , 1990, Physical review. B, Condensed matter.

[42]  K. Hess,et al.  Giant isotope effect in hot electron degradation of metal oxide silicon devices , 1998 .

[43]  Massimo V. Fischetti,et al.  SiO2‐induced substrate current and its relation to positive charge in field‐effect transistors , 1986 .

[44]  H. Miyoshi,et al.  Origin of positive charge generated in thin SiO/sub 2/ films during high-field electrical stress , 1999 .

[45]  Akira Toriumi,et al.  Stress‐induced leakage current in ultrathin SiO2 films , 1994 .

[46]  P.J. Silverman,et al.  Explanation of stress-induced damage in thin oxides , 1998, International Electron Devices Meeting 1998. Technical Digest (Cat. No.98CH36217).

[47]  A. Ghetti,et al.  Gate oxides in 50 nm devices: thickness uniformity improves projected reliability , 1999, International Electron Devices Meeting 1999. Technical Digest (Cat. No.99CH36318).

[48]  S. Kumashiro,et al.  Oxygen vacancy with large lattice distortion as an origin of leakage currents in SiO/sub 2/ , 1997, International Electron Devices Meeting. IEDM Technical Digest.

[49]  K. Okada.  Analysis of the relationship between defect site generation and dielectric breakdown utilizing A-mode stress induced leakage current , 2000 .

[50]  J. Bude,et al.  Stress induced leakage current analysis via quantum yield experiments , 2000 .

[51]  James Stasiak,et al.  Trap creation in silicon dioxide produced by hot electrons , 1989 .

[52]  N. K. Zous,et al.  Characterization of various stress-induced oxide traps in MOSFET's by using a subthreshold transient current technique , 1997 .

[53]  D. Dimaria,et al.  Electron energy dependence of metal-oxide-semiconductor degradation , 1999 .

[54]  Seiichi Aritome,et al.  Stress-induced leakage current of tunnel oxide derived from flash memory read-disturb characteristics , 1998 .

[55]  Luca Selmi,et al.  On interface and oxide degradation in VLSI MOSFETs. I. Deuterium effect in CHE stress regime , 2002 .

[56]  Y. Maneglia,et al.  In-depth exploration of Si-SiO/sub 2/ interface traps in MOS transistors using the charge pumping technique , 1997 .

[57]  Elyse Rosenbaum,et al.  Anode hole injection versus hydrogen release: the mechanism for gate oxide breakdown , 2000, 2000 IEEE International Reliability Physics Symposium Proceedings. 38th Annual (Cat. No.00CH37059).

[58]  R. Degraeve,et al.  Photo-carrier generation as the origin of Fowler-Nordheim-induced substrate hole current in thin oxides , 1999, International Electron Devices Meeting 1999. Technical Digest (Cat. No.99CH36318).

[59]  Tetsuo Endoh,et al.  A reliable bi-polarity write/erase technology in flash EEPROMs , 1990, International Technical Digest on Electron Devices.

[60]  J. Stathis.  Percolation models for gate oxide breakdown , 1999 .

[61]  S. Takagi,et al.  A new I-V model for stress-induced leakage current including inelastic tunneling , 1999 .

[62]  Chenming Hu,et al.  Substrate hole current and oxide breakdown , 1986 .

[63]  Eduard A. Cartier,et al.  Anode hole injection and trapping in silicon dioxide , 1996 .

[64]  Y. Nissan-Cohen,et al.  Trap generation and occupation dynamics in SiO2 under charge injection stress , 1986 .

[65]  D. Arnold,et al.  Impact ionization, trap creation, degradation, and breakdown in silicon dioxide films on silicon , 1993 .

[66]  T. Ma,et al.  Polarity dependent gate tunneling currents in dual-gate CMOSFETs , 1998 .

[67]  Y. Nissan-Cohen,et al.  High field current induced‐positive charge transients in SiO2 , 1983 .

[68]  Bruno Ricco,et al.  Modeling and simulation of stress-induced leakage current in ultrathin SiO/sub 2/ films , 1998 .

[69]  D.J. DiMaria.  Hole trapping, substrate currents, and breakdown in thin silicon dioxide films [ in FETs ] , 1995, IEEE Electron Device Letters.

[70]  Chenming Hu,et al.  Electron-trap generation by recombination of electrons and holes in SiO2 , 1987 .

[71]  Donald R. Young,et al.  Hydrogen migration under avalanche injection of electrons in Si metal‐oxide‐semiconductor capacitors , 1983 .

[72]  K. R. Farmer,et al.  Tunnel electron induced charge generation in very thin silicon oxide dielectrics , 1991 .

[73]  Kow-Ming Chang,et al.  The relaxation phenomena of positive charges in thin gate oxide during Fowler-Nordheim tunneling stress , 1998 .

[74]  R. Fowler,et al.  Electron Emission in Intense Electric Fields , 1928 .

[75]  C. Hu,et al.  Hole injection SiO/sub 2/ breakdown model for very low voltage lifetime extrapolation , 1994 .

[76]  Shinichi Takagi,et al.  Experimental evidence of inelastic tunneling in stress-induced leakage current , 1999 .

[77]  F. J. Feigl,et al.  Positive charge generation in metal‐oxide‐semiconductor capacitors , 1991 .