Replacing fossil based PET with biobased PEF; process analysis, energy and GHG balance

An energy and greenhouse gas (GHG) balance study was performed on the production of the bioplastic polyethylene furandicarboxylate (PEF) starting from corn based fructose. The goal of the study was to analyze and to translate experimental data on the catalytic dehydration of fructose to a simulation model, using the ASPEN Plus modeling software. The mass and energy balances of the simulation model results were then used as inputs for a process chain analysis (by application of the life cycle assessment methodology, LCA) and compared to its petrochemical counterpart polyethylene terephthalate (PET). The production of PEF can be divided into three main units: the production of fructose from corn starch; the conversion of fructose into Furanics and subsequent recovery and upgrading; and the oxidation to the monomer 2,5-furandicarboxylic acid (FDCA) and polymerization with ethylene glycol (EG) into PEF. The ASPEN Plus simulation model describes the conversion of fructose into Furanics, subsequent recovery and upgrading and a CHP unit. The production of fructose from corn starch and the oxidation and polymerization into PEF were based on the literature. In total, six model cases were analyzed, using different sets of underlying experimental data; four cases based on crystalline fructose and two cases on high fructose corn syrup (HFCS). Fructose can be converted into Furanics at efficiencies between 38% and 47%. The production of PEF can reduce the NREU approximately 40% to 50% while GHG emissions can be reduced approximately 45% to 55%, compared to PET for the system cradle to grave. These reductions are higher than for other biobased plastics, such as polylactic acid (PLA) or polyethylene (PE). With an annual market size of approximately 15 million metric tonnes (Mt) of PET bottles produced worldwide, the complete bottle substitution of PEF for PET would allow us to save between 440 and 520 PJ of non-renewable energy use (NREU) and to reduce GHG emissions by 20 to 35 Mt of CO2 equivalents. If also substantial substitution takes place in the PET fibres and film industry, the savings increase accordingly. The GHG emissions could be further reduced by a switch to lignocellulosic feedstocks, such as straw, but this requires additional research.

[1]  Martin Kumar Patel,et al.  Medium and Long-term Opportunities and Risks of the Biotechnological Production of Bulk Chemicals from Renewable Resources , 2006 .

[2]  J. Horvat,et al.  Mechanism of levulinic acid formation , 1985 .

[3]  H. V. Bekkum,et al.  Platinum Catalyzed Oxidation of 5-Hydroxymethylfurfural , 1990 .

[4]  Ernst Worrell,et al.  Present and future development in plastics from biomass , 2010 .

[5]  Steve Davies,et al.  ORIGINAL RESEARCH: The eco-profile for current Ingeo® polylactide production , 2010 .

[6]  Danièle Revel,et al.  IPCC Special Report on Renewable Energy Sources and Climate Change Mitigation , 2011 .

[7]  A. Corma,et al.  Synthesis of transportation fuels from biomass: chemistry, catalysts, and engineering. , 2006, Chemical reviews.

[8]  Jacinto F. Fabiosa,et al.  Use of U.S. Croplands for Biofuels Increases Greenhouse Gases Through Emissions from Land-Use Change , 2008, Science.

[9]  Ernst Worrell,et al.  Open-loop recycling: A LCA case study of PET bottle-to-fibre recycling , 2010 .

[10]  Seungdo Kim,et al.  Life Cycle Assessment Study of Biopolymers (Polyhydroxyalkanoates) - Derived from No-Tilled Corn (11 pp) , 2005 .

[11]  Andrew J. McAloon,et al.  Engineering process and cost model for a conventional corn wet milling facility , 2008 .

[12]  Michael O'Hare,et al.  Greenhouse gas emissions from biofuels' indirect land use change are uncertain but may be much greater than previously estimated. , 2010, Environmental science & technology.

[13]  J. Lewkowski.  Synthesis, chemistry and applications of 5-hydroxymethyl-furfural and its derivatives , 2003 .

[14]  Ernst Worrell,et al.  New gross energy-requirement figures for materials production , 1994 .

[15]  Masson-Delmotte,et al.  The Physical Science Basis , 2007 .

[16]  Akshay D. Patel,et al.  Techno-economic analysis of 5-nonanone production from levulinic acid. , 2010 .

[17]  Klaus-Dieter Vorlop,et al.  A new approach for the production of 2,5-furandicarboxylic acid by in situ oxidation of 5-hydroxymethylfurfural starting from fructose , 2000 .

[18]  Vincenzo Piemonte,et al.  Land‐use change emissions: How green are the bioplastics? , 2011 .

[19]  Birgit Kamm,et al.  Biorefineries – Industrial Processes and Products , 2005 .

[20]  Scott Duncan,et al.  A survey of unresolved problems in life cycle assessment , 2008 .

[21]  Ernst Worrell,et al.  Environmental impact assessment of man-made cellulose fibres , 2010 .

[22]  Yuriy Román-Leshkov,et al.  Phase Modifiers Promote Efficient Production of Hydroxymethylfurfural from Fructose , 2006, Science.

[23]  C. Afonso,et al.  5-Hydroxymethylfurfural (HMF) as a building block platform: Biological properties, synthesis and synthetic applications , 2011 .

[24]  Xinli Tong,et al.  Biomass into chemicals: Conversion of sugars to furan derivatives by catalytic processes , 2010 .

[25]  Francesco Cherubini,et al.  GHG balances of bioenergy systems – Overview of key steps in the production chain and methodological concerns , 2010 .

[26]  André Faaij,et al.  Greenhouse gas footprints of different biofuel production systems , 2010 .

[27]  Joseph J. Bozell,et al.  Technology development for the production of biobased products from biorefinery carbohydrates—the US Department of Energy’s “Top 10” revisited , 2010 .

[28]  Arvin R. Mosier,et al.  Effect of land use change on methane oxidation in temperate forest and grassland soils , 1993 .

[29]  Jean-Paul Lange,et al.  Valeric biofuels: a platform of cellulosic transportation fuels. , 2010, Angewandte Chemie.

[30]  Corinne Le Quéré,et al.  Climate Change 2013: The Physical Science Basis , 2013 .

[31]  Birka Wicke,et al.  Indirect land use change: review of existing models and strategies for mitigation , 2012 .

[32]  K. Zeitsch,et al.  The Chemistry and Technology of Furfural and Its Many By-Products , 2000 .

[33]  G. N. Richards,et al.  Mechanism of formation of 5-(hydroxymethyl)-2-furaldehyde from D-fructose an sucrose. , 1990, Carbohydrate research.

[34]  J. Seabra,et al.  Green house gases emissions in the production and use of ethanol from sugarcane in Brazil: the 2005/2006 averages and a prediction for 2020. , 2008 .

[35]  D. Murphy,et al.  Short-term effects of nitrogen on methane oxidation in soils , 1998, Biology and Fertility of Soils.