Different thermal analysis technique application in determination of fold surface-free energy

In this work, the crystallization rates and spherulitic growth rate of miscible blends of poly(vinylidene fluoride) (PVDF) and acrylic rubber (ACM) were determined using differential scanning calorimetry (DSC), real-time FTIR, and optical microscopy. FTIR results suggest that blending does not induce the creation of polymorphic crystalline forms of PVDF. SAXS data demonstrate the formation of interlamellar structure after blending. The fold surface-free energy (σe) was analyzed and compared using different thermal analysis techniques. The isothermal crystallization curves obtained using real-time FTIR and DSC explored in two different methods: t1/2 or Avrami equation. While the Avrami equation is more widespread and precise, both analytical methods gave similar free energy of folding values. However, it was found that the direct optical method of measuring spherulitic growth rate yields σe values 30–50 % lower than those obtained from the overall crystallization rate data. Conversely, the σe values were found to increase with increasing amorphous ACM phase content regardless of the analytical methods.

[1]  B. Cheng,et al.  DSC analysis of isothermally melt-crystallized bacterial poly(3-hydroxybutyrate-co-3-hydroxyhexanoate) films , 2011 .

[2]  D. Grenier,et al.  Avrami analysis: Three experimental limiting factors , 1980 .

[3]  Minoo Naebe,et al.  A new approach for mechanisms of ferroelectric crystalline phase formation in PVDF nanocomposites. , 2014, Physical chemistry chemical physics : PCCP.

[4]  F. D. Santis,et al.  Nucleation density and growth rate of polypropylene measured by calorimetric experiments , 2013, Journal of Thermal Analysis and Calorimetry.

[5]  Z. Zhong,et al.  The miscibility and morphology of hexamine cross-linked novolac/poly(ϵ-caprolactone) blends , 1997 .

[6]  J. Hoffman,et al.  Extension of theory of growth of chain‐folded polymer crystals to large undercoolings , 1973 .

[7]  R. Shanks,et al.  Comparison of reversible melting behaviour of poly(3-hydroxybutyrate) using quasi-isothermal and other modulated temperature differential scanning calorimetry techniques , 2011 .

[8]  Wanxi Zhang,et al.  Calorimetric analysis of the multiple melting behavior of melt-crystallized poly(l-lactic acid) with a low optical purity , 2013, Journal of Thermal Analysis and Calorimetry.

[9]  M. Avrami,et al.  Kinetics of Phase Change 2 , 1940 .

[10]  A. Salimi,et al.  FTIR STUDIES OF -PHASE CRYSTAL FORMATION IN STRETCHED PVDF FILMS , 2003 .

[11]  Senentxu Lanceros-Méndez,et al.  α- to β Transformation on PVDF Films Obtained by Uniaxial Stretch , 2006 .

[12]  John D. Hoffman,et al.  Crystallization of Bulk Polymers With Chain Folding: Theory of Growth of Lamellar Spherulites , 1961, Journal of research of the National Bureau of Standards. Section A, Physics and chemistry.

[13]  P. Cebe,et al.  Avrami analysis of melt crystallization behavior of Trogamid , 2013, Journal of Thermal Analysis and Calorimetry.

[14]  Ali Akbar Yousefi,et al.  Hybrid Polyvinylidene Fluoride/Nanoclay/ MWCNT Nanocomposites: PVDF Crystalline Transformation , 2011 .

[15]  V. Álvarez,et al.  Effect of different inorganic filler over isothermal and non-isothermal crystallization of polypropylene homopolymer , 2012, Journal of Thermal Analysis and Calorimetry.

[16]  J. Azcue,et al.  Crystallization kinetics of polymer–diluent mixtures. Influence of benzophenone on the spherulitic growth rate of isotactic polystyrene , 1968 .

[17]  J. Hoffman,et al.  Theory of Formation of Polymer Crystals with Folded Chains in Dilute Solution , 1960, Journal of research of the National Bureau of Standards. Section A, Physics and chemistry.

[18]  S. A. Samsudin,et al.  The equilibrium melting temperature and isothermal crystallisation kinetics of cyclic poly(butylene terephthalate) and styrene maleimide (c-PBT/SMI) blends , 2013, Journal of Thermal Analysis and Calorimetry.

[19]  H. Reynaers,et al.  Miscibility, crystallization and real-time small-angle X-ray scattering investigation of the semicrystalline morphology in thermosetting polymer blends , 2001 .

[20]  Wantai Yang,et al.  Miscible Crystalline/Crystalline Polymer Blends of Poly(vinylidene fluoride) and Poly(butylene succinate-co-butylene adipate): Spherulitic Morphologies and Crystallization Kinetics † , 2007 .

[21]  L. B. Morgan.  Crystallization phenomena in polymers - The course of the crystallization , 1954, Philosophical transactions of the Royal Society of London. Series A: Mathematical and physical sciences.

[22]  M. Avrami.  Kinetics of Phase Change. I General Theory , 1939 .

[23]  Q. Guo,et al.  Miscibility, crystallization kinetics and real-time small-angle X-ray scattering investigation of the semicrystalline morphology in thermosetting polymer blends of epoxy resin and poly(ethylene oxide) , 2001 .

[24]  Q. Guo,et al.  Crystallization kinetics of poly(ε-caprolactone) in miscible thermosetting polymer blends of epoxy resin and poly(ε-caprolactone) , 2001 .

[25]  Senentxu Lanceros-Méndez,et al.  α to β Phase Transformation and Microestructural Changes of PVDF Films Induced by Uniaxial Stretch , 2009 .

[26]  L. Mandelkern,et al.  On regimes I and II during polymer crystallization , 1987 .

[27]  J. Hoffman,et al.  On the problem of crystallization of polymers from the melt with chain folding , 1979 .

[28]  M. M. Abolhasani,et al.  CRYSTALLINE STRUCTURES AND α → β AND γ POLYMORPHS TRANSFORMATION INDUCED BY NANOCLAY IN PVDF-BASED NANOCOMPOSITE , 2014 .

[29]  J. L. Acosta,et al.  Tensile and dynamic mechanical behaviour of polymer blends based on PVDF , 1997 .

[30]  Mohammad Mahdi Abolhasani,et al.  Poly(vinylidene fluoride)-acrylic rubber partially miscible blends: Phase behavior and its effects on the mechanical properties , 2013 .

[31]  Jiachun Feng,et al.  DSC and morphological studies on the crystallization behavior of β-nucleated isotactic polypropylene composites filled with Kevlar fibers , 2011 .

[32]  R. Alamo,et al.  Crystallization of polyformals: 1. Crystallization kinetics of poly(1,3-dioxolane) , 1982 .

[33]  T. Nishi,et al.  Spherulitic Crystallization in Compatible Blends of Poly(vinylidene fluoride) and Poly(methyl methacrylate) , 1977 .

[34]  M. M. Abolhasani,et al.  Poly(vinylidene fluoride)-acrylic rubber partially miscible blends: Crystallization within conjugated phases induce dual lamellar crystalline structure , 2013 .

[35]  J. Hoffman,et al.  Kinetic of crystallization from the melt and chain folding in polyethylene fractions revisited: theory and experiment , 1997 .

[36]  M. M. Abolhasani,et al.  Influence of Miscibility Phenomenon on Crystalline Polymorph Transition in Poly(Vinylidene Fluoride)/Acrylic Rubber/Clay Nanocomposite Hybrid , 2014, PloS one.

[37]  Zhaobin Qiu,et al.  Crystallization and morphology of poly(vinylidene fluoride)/poly(3‐hydroxybutyrate) blends. III. Crystallization and phase diagram by differential scanning calorimetry , 2005 .

[38]  Jie Zhu,et al.  Polar phase formation in poly(vinylidene fluoride) induced by melt annealing , 2012 .