A solar-powered microbial electrolysis cell with a platinum catalyst-free cathode to produce hydrogen.

This paper reports successful hydrogen evolution using a dye-sensitized solar cell (DSSC)-powered microbial electrolysis cell (MEC) without a Pt catalyst on the cathode, indicating a solution for the inherent drawbacks of conventional MECs, such as the need for an external bias and catalyst. DSSCs fabricated by assembling a ruthenium dye-loaded TiO(2) film and platinized FTO glass with an I(-)/I(3)(-) redox couple were demonstrated as an alternative bias (V(oc) = 0.65 V). Pt-loaded (0.3 mg Pt/cm(2)) electrodes with a Pt/C nanopowder showed relatively faster hydrogen production than the Pt-free electrodes, particularly at lower voltages. However, once the applied photovoltage exceeded a certain level (0.7 V), platinum did not have any additional effect on hydrogen evolution in the solar-powered MECs: hydrogen conversion efficiency was almost comparable for either the plain (71.3-77.0%) or Pt-loaded carbon felt (79.3-82.0%) at >0.7 V. In particular, the carbon nanopowder-coated electrode without Pt showed significantly enhanced performance compared to the plain electrode, which indicates efficient electrohydrogenesis, even without Pt by enhancing the surface area. As the applied photovoltage was increased, anodic methanogenesis decreased gradually, resulting in increasing hydrogen yield.

[1]  P. Liska,et al.  Fabrication of thin film dye sensitized solar cells with solar to electric power conversion efficiency over 10 , 2008 .

[2]  Jurg Keller,et al.  Non-catalyzed cathodic oxygen reduction at graphite granules in microbial fuel cells , 2007 .

[3]  L. T. Angenent,et al.  Application of Bacterial Biocathodes in Microbial Fuel Cells , 2006 .

[4]  K. Ho,et al.  A high-performance counter electrode based on poly(3,4-alkylenedioxythiophene) for dye-sensitized solar cells , 2009 .

[5]  Hong Liu,et al.  Hydrogen production using single-chamber membrane-free microbial electrolysis cells. , 2008, Water research.

[6]  Michael Grätzel,et al.  Photoelectrochemical cells , 2001, Nature.

[7]  Tsukasa Yoshida,et al.  Room‐Temperature Synthesis of Porous Nanoparticulate TiO2 Films for Flexible Dye‐Sensitized Solar Cells , 2006 .

[8]  H. Hamelers,et al.  Effects of membrane cation transport on pH and microbial fuel cell performance. , 2006, Environmental science & technology.

[9]  Bruce E Logan,et al.  Hydrogen production in a single chamber microbial electrolysis cell lacking a membrane. , 2008, Environmental science & technology.

[10]  H. Hamelers,et al.  Performance of single chamber biocatalyzed electrolysis with different types of ion exchange membranes. , 2007, Water research.

[11]  Willy Verstraete,et al.  Methanogenesis in membraneless microbial electrolysis cells , 2009, Applied Microbiology and Biotechnology.

[12]  E. Teller,et al.  ADSORPTION OF GASES IN MULTIMOLECULAR LAYERS , 1938 .

[13]  G. Gil,et al.  Operational parameters affecting the performannce of a mediator-less microbial fuel cell. , 2003, Biosensors & bioelectronics.

[14]  H. Hamelers,et al.  Principle and perspectives of hydrogen production through biocatalyzed electrolysis , 2006 .

[15]  Hong Liu,et al.  Electrochemically assisted microbial production of hydrogen from acetate. , 2005, Environmental science & technology.

[16]  In S. Kim,et al.  Biohydrogen production via biocatalyzed electrolysis in acetate-fed bioelectrochemical cells and microbial community analysis , 2008 .

[17]  Willy Verstraete,et al.  Biological denitrification in microbial fuel cells. , 2007, Environmental science & technology.

[18]  C. Buisman,et al.  Towards practical implementation of bioelectrochemical wastewater treatment. , 2008, Trends in biotechnology.

[19]  In S. Kim,et al.  Effect of different substrates on the performance, bacterial diversity, and bacterial viability in microbial fuel cells. , 2009, Bioresource technology.

[20]  J. N. B U I S M A N,et al.  Hydrogen Production with a Microbial Biocathode , 2007 .

[21]  Uwe Schröder,et al.  Application of pyrolysed iron(II) phthalocyanine and CoTMPP based oxygen reduction catalysts as cathode materials in microbial fuel cells , 2005 .

[22]  I. Chang,et al.  Mass Transport through a Proton Exchange Membrane (Nafion) in Microbial Fuel Cells , 2008 .

[23]  P. Kamat.  Meeting the Clean Energy Demand: Nanostructure Architectures for Solar Energy Conversion , 2007 .

[24]  E. Stathatos,et al.  Quasi-solid-state dye-sensitized solar cells employing nanocrystalline TiO2 films made at low temperature , 2008 .

[25]  Michael Grätzel,et al.  Applied physics: Solar cells to dye for , 2003, Nature.

[26]  Willy Verstraete,et al.  Microbial Fuel Cells: Recent Advances, Bacterial Communities and Application Beyond Electricity Generation , 2008 .

[27]  Boris Tartakovsky,et al.  High rate membrane-less microbial electrolysis cell for continuous hydrogen production , 2009, International Journal of Hydrogen Energy.

[28]  Juhwan Kim,et al.  Efficient Polymer Solar Cells with Surface Relief Gratings Fabricated by Simple Soft Lithography , 2008 .

[29]  Bruce E Logan,et al.  Sustainable and efficient biohydrogen production via electrohydrogenesis , 2007, Proceedings of the National Academy of Sciences.

[30]  S H A O A N C H E N G, † H U B E R T U,et al.  Microbial Electrolysis Cells for High Yield Hydrogen Gas Production from Organic Matter , 2008 .