Electrical and optical study of Cu(In, Ga)Se2 co-evaporated thin films

Abstract Co-evaporation technique from three sources was used to prepare Cu(In, Ga)Se2 polycrystalline thin films for photovoltaic conversion. Their conductivity was studied in the range 20–300 K. The grain boundary scattering mechanism is mainly responsible for the diffusion process in the latter materials. In the low temperature region, we interpret the data in terms of Mott law and the analysis is very consistent with the variable range hopping. However, thermoionic emission is predominant at high temperatures. When the conductivity deviates from the classical grain boundary conduction models, inhomogeneity is then considered and parameters such as the standard deviation and the mean potential barrier height are derived. Transmittance measurements yielded band gap values of 1.07 and 1.64 eV for CuInSe2 and CuGaSe2, respectively.

[1]  C. Jagadish,et al.  Effect of Excess Copper on the Electrical Properties of Polycrystalline Thin Films of CuInSe2 , 1986 .

[2]  S. Chaudhuri,et al.  Some aspects of surface roughness in polycrystalline thin films: optical constants and grain distribution , 1992 .

[3]  K. Gürs,et al.  Ho laser with 50‐W output and 6.5% slope efficiency , 1975 .

[4]  K. Mannan,et al.  The optical and electrical properties of copper indium di-selenide thin films , 2000 .

[5]  J. Loferski,et al.  Spray pyrolysis of CuInSe2 thin films , 1980 .

[6]  S. Chaudhuri,et al.  Electron transport processes in CuIn1−xGaxSe2 films prepared by four source co-evaporation technique , 2002 .

[7]  L. M. Schiavone,et al.  p−dHybridization of the Valence Bands of I-III-VI2Compounds , 1972 .

[8]  A. Zunger,et al.  Defect physics of the CuInSe 2 chalcopyrite semiconductor , 1998 .

[9]  H. Sakata,et al.  Electrical Conductivity of Flash‐Evaporated CuInSe2 Films , 1997 .

[10]  J.D. Meindl,et al.  Modeling and optimization of monolithic polycrystalline silicon resistors , 1981, IEEE Transactions on Electron Devices.

[11]  D. Lemoine,et al.  Electrical properties of evaporated a-CdTe films , 1981 .

[12]  Giorgio Baccarani,et al.  Transport properties of polycrystalline silicon films , 1978 .

[13]  B. Mansour,et al.  Transport properties of CuGaSe2 thin films , 1995 .

[14]  Rommel Noufi,et al.  Progress toward 20% efficiency in Cu(In,Ga)Se2 polycrystalline thin‐film solar cells , 1999 .

[15]  A. Simashkevich,et al.  Electrical and luminescent properties of CuGaSe2 crystals and thin films , 2001 .

[16]  Sudarshan Kundu,et al.  Characterization of Cu(In,Ga)Se2 films by Raman scattering , 2002 .

[17]  N. Mott,et al.  Electronic Processes In Non-Crystalline Materials , 1940 .

[18]  J. Goral,et al.  Effects of composition and substrate temperature on the electro-optical properties of thin-film CuInSe2 and CuGaSe2☆ , 1988 .

[19]  F. Baumgartner,et al.  Photoluminescence and electrical properties of Sn‐doped CuGaSe2 single crystals , 1996 .

[20]  Uwe Rau,et al.  Electronic properties of Cu(In,Ga)Se2 heterojunction solar cells–recent achievements, current understanding, and future challenges , 1999 .

[21]  J. Werner.  Origin of Curved Arrhenius Plots for the Conductivity of Polycrystalline Semiconductors , 1994 .