Ag3PO4/reduced graphite oxide sheets nanocomposites with highly enhanced visible light photocatalytic activity and stability

Abstract A series of Ag3PO4 and reduced graphite oxide sheets (RGOs) nanocomposites have been fabricated by a facile chemical precipitation approach in N,N-dimethylformamide (DMF) solvent without any hard/soft templates. The as-prepared Ag3PO4/RGOs composites were characterized by X-ray diffraction pattern (XRD), Fourier transform infrared spectra (FTIR), Raman spectroscopy, field emission scanning electron microscopy (SEM), transmission electron microscopy (TEM), and ultraviolet–visible (UV–vis) diffuse reflectance spectroscopy (DRS). It is found that the nano-sized Ag3PO4 particles are deposited on the surfaces of RGOs. The Ag3PO4/RGOs nanocomposites exhibit enhanced photocatalytic activity for the photodegradation of organic methyl orange (MO) and methylene blue (MB) under visible light irradiation. The photocatalytic rate of Ag3PO4/2.1 wt% RGOs nanocomposite is 3 and 2 times of that of pure Ag3PO4 nanoparticles for the degradation of MO and MB, respectively. Furthermore, the photocatalytic and structural stability of Ag3PO4 is greatly enhanced. It is suggested that RGOs can be used as protective coatings that partially inhibit the photocorrosion of Ag3PO4. Overall, this work could provide a new approach to the improvement not only in the photocatalytic activity but also the stability of photocorrosion catalysts.

[1]  E. Williams,et al.  Atomic structure of graphene on SiO2. , 2007, Nano letters.

[2]  N. Umezawa,et al.  Facet effect of single-crystalline Ag3PO4 sub-microcrystals on photocatalytic properties. , 2011, Journal of the American Chemical Society.

[3]  B. Liu,et al.  A facile one-step solvothermal synthesis of graphene/rod-shaped TiO₂ nanocomposite and its improved photocatalytic activity. , 2012, Nanoscale.

[4]  P. Kamat,et al.  TiO2-graphene nanocomposites. UV-assisted photocatalytic reduction of graphene oxide. , 2008, ACS nano.

[5]  Eric R. Waclawik,et al.  An efficient photocatalyst structure: TiO(2)(B) nanofibers with a shell of anatase nanocrystals. , 2009, Journal of the American Chemical Society.

[6]  R. Czerw,et al.  Substrate-interface interactions between carbon nanotubes and the supporting substrate , 2002 .

[7]  Michael O'Keeffe,et al.  A route to high surface area, porosity and inclusion of large molecules in crystals , 2004, Nature.

[8]  Shuxin Ouyang,et al.  Photocatalytic and photoelectric properties of cubic Ag3PO4 sub-microcrystals with sharp corners and edges. , 2012, Chemical communications.

[9]  Shuxin Ouyang,et al.  Nano‐photocatalytic Materials: Possibilities and Challenges , 2012, Advanced materials.

[10]  Shuxin Ouyang,et al.  Facile synthesis of rhombic dodecahedral AgX/Ag3PO4 (X = Cl, Br, I) heterocrystals with enhanced photocatalytic properties and stabilities. , 2011, Physical chemistry chemical physics : PCCP.

[11]  Yueming Li,et al.  P25-graphene composite as a high performance photocatalyst. , 2010, ACS nano.

[12]  M. Rajamathi,et al.  CHEMICALLY MODIFIED GRAPHENE SHEETS PRODUCED BY THE SOLVOTHERMAL REDUCTION OF COLLOIDAL DISPERSIONS OF GRAPHITE OXIDE , 2008 .

[13]  S. Yin,et al.  Synthesis of excellent visible-light responsive TiO2−xNy photocatalyst by a homogeneous precipitation-solvothermal process , 2005 .

[14]  Z. Xiong,et al.  Photocatalytic degradation of dyes over graphene-gold nanocomposites under visible light irradiation. , 2010, Chemical communications.

[15]  H. Ming,et al.  Carbon quantum dots/Ag3PO4 complex photocatalysts with enhanced photocatalytic activity and stability under visible light , 2012 .

[16]  J. Banfield,et al.  Particle size effects on transformation kinetics and phase stability in nanocrystalline TiO2 , 1997 .

[17]  Kwang‐Bum Kim,et al.  Li4Ti5O12/reduced graphite oxide nano-hybrid material for high rate lithium-ion batteries , 2010 .

[18]  Hua Wang,et al.  A facile way to rejuvenate Ag3PO4 as a recyclable highly efficient photocatalyst. , 2012, Chemistry.

[19]  Sher Bahadur Rawal,et al.  Novel Ag3PO4/TiO2 composites for efficient decomposition of gaseous 2-propanol under visible-light irradiation , 2012 .

[20]  Jiaguo Yu,et al.  Highly efficient visible-light-driven photocatalytic hydrogen production of CdS-cluster-decorated graphene nanosheets. , 2011, Journal of the American Chemical Society.

[21]  K. Ariga,et al.  Photocatalytic degradation of 2,4,6-trichlorophenol using lanthanum doped ZnO in aqueous suspension , 2007 .

[22]  Hui Yang,et al.  An orthophosphate semiconductor with photooxidation properties under visible-light irradiation. , 2010, Nature materials.

[23]  H. Dai,et al.  Solvothermal reduction of chemically exfoliated graphene sheets. , 2009, Journal of the American Chemical Society.

[24]  J. Banfield,et al.  UNDERSTANDING POLYMORPHIC PHASE TRANSFORMATION BEHAVIOR DURING GROWTH OF NANOCRYSTALLINE AGGREGATES: INSIGHTS FROM TIO2 , 2000 .

[25]  Yong Xu,et al.  The absolute energy positions of conduction and valence bands of selected semiconducting minerals , 2000 .

[26]  Chan Beum Park,et al.  Highly Photoactive, Low Bandgap TiO2 Nanoparticles Wrapped by Graphene , 2012, Advanced materials.

[27]  G. Wallace,et al.  Processable aqueous dispersions of graphene nanosheets. , 2008, Nature nanotechnology.

[28]  A. Musumeci,et al.  Raman spectroscopy of hydrotalcites with phosphate in the interlayer: implications for the removal of phosphate from water , 2006 .

[29]  L. Mao,et al.  Magnetically separable Fe3O4–Ag3PO4 sub-micrometre composite: facile synthesis, high visible light-driven photocatalytic efficiency, and good recyclability , 2012 .

[30]  Chao Ma,et al.  Synthesis and characterization of high efficiency and stable Ag3PO4/TiO2 visible light photocatalyst for the degradation of methylene blue and rhodamine B solutions , 2012 .

[31]  Yajun Wang,et al.  Significant photocatalytic enhancement in methylene blue degradation of TiO2 photocatalysts via graphene-like carbon in situ hybridization , 2010 .

[32]  A. Tong,et al.  The study of the partitioning mechanism of methyl orange in an aqueous two-phase system. , 1999, Talanta.

[33]  Cao-Thang Dinh,et al.  Large-scale synthesis of uniform silver orthophosphate colloidal nanocrystals exhibiting high visible light photocatalytic activity. , 2011, Chemical communications.

[34]  H. Arakawa,et al.  The visible light induced photocatalytic activity of tungsten trioxide powders , 2001 .

[35]  A. Manthiram,et al.  Rapid, Facile Microwave-Solvothermal Synthesis of Graphene Nanosheets and Their Polyaniline Nanocomposites for Energy Strorage , 2009 .

[36]  M. Chance,et al.  In situ analysis of mineral content and crystallinity in bone using infrared micro-spectroscopy of the nu(4) PO(4)(3-) vibration. , 2001, Biochimica et biophysica acta.

[37]  Nan Wang,et al.  TiO2 nanoparticles assembled on graphene oxide nanosheets with high photocatalytic activity for removal of pollutants , 2011 .

[38]  S. Stankovich,et al.  Synthesis of graphene-based nanosheets via chemical reduction of exfoliated graphite oxide , 2007 .

[39]  Huaqiang Cao,et al.  ZnO@graphene composite with enhanced performance for the removal of dye from water , 2011 .

[40]  J. Tascón,et al.  Preparation of graphene dispersions and graphene-polymer composites in organic media , 2009 .

[41]  Xianzhi Fu,et al.  TiO2-graphene nanocomposites for gas-phase photocatalytic degradation of volatile aromatic pollutant: is TiO2-graphene truly different from other TiO2-carbon composite materials? , 2010, ACS nano.

[42]  E. Bekyarova,et al.  Chemical modification of epitaxial graphene: spontaneous grafting of aryl groups. , 2009, Journal of the American Chemical Society.

[43]  M. Jaroniec,et al.  Tunable photocatalytic selectivity of TiO2 films consisted of flower-like microspheres with exposed {001} facets. , 2011, Chemical communications.

[44]  M. López-Bote,et al.  Raman intensities, vibrational eigenvectors, electro‐optical parameters and force constants of SO42−, ClO4−, PO43, CO32− and NO3− anions in polycrystalline samples , 1980 .

[45]  L. Ge.  Novel visible-light-driven Pt/BiVO4 photocatalyst for efficient degradation of methyl orange , 2008 .

[46]  Yasuhiro Shiraishi,et al.  Adsorption-driven photocatalytic activity of mesoporous titanium dioxide. , 2005, Journal of the American Chemical Society.

[47]  R. Ruoff,et al.  Chemical methods for the production of graphenes. , 2009, Nature nanotechnology.

[48]  Jintao Zhang,et al.  Graphene–metal–oxide composites for the degradation of dyes under visible light irradiation , 2011 .

[49]  L. Zang,et al.  Photochemistry of semiconductor particles 3. Effects of surface charge on reduction rate of methyl orange photosensitized by ZnS sols , 1995 .

[50]  B. N. Murthy,et al.  Heterogeneous photo catalytic degradation of anionic and cationic dyes over TiO2 and TiO2 doped with Mo6+ ions under solar light: Correlation of dye structure and its adsorptive tendency on the degradation rate , 2009 .

[51]  Hexing Li,et al.  Highly active TiO2N photocatalysts prepared by treating TiO2 precursors in NH3/ethanol fluid under supercritical conditions. , 2006, The journal of physical chemistry. B.

[52]  A. Boskey,et al.  Fourier transform infrared spectroscopy of the solution-mediated conversion of amorphous calcium phosphate to hydroxyapatite: New correlations between X-ray diffraction and infrared data , 2006, Calcified Tissue International.

[53]  Kian Ping Loh,et al.  The chemistry of graphene , 2010 .

[54]  Liang Fang,et al.  One-pot pyridine-assisted synthesis of visible-light-driven photocatalyst Ag/Ag3PO4 , 2012 .

[55]  Jae-Young Choi,et al.  Efficient Reduction of Graphite Oxide by Sodium Borohydride and Its Effect on Electrical Conductance , 2009 .

[56]  Jiaguo Yu,et al.  Enhanced photocatalytic activity of mesoporous TiO2 aggregates by embedding carbon nanotubes as electron-transfer channel. , 2011, Physical chemistry chemical physics : PCCP.

[57]  Jinqing Wang,et al.  Synthesis of hydrothermally reduced graphene/MnO2 composites and their electrochemical properties as supercapacitors , 2011 .

[58]  Liang Fang,et al.  Highly efficient and stable Ag/Ag3PO4 plasmonic photocatalyst in visible light , 2012 .

[59]  Andre K. Geim,et al.  The rise of graphene. , 2007, Nature materials.

[60]  T. Florence.  Polarography of aromatic azo compounds. I. Effect of substituents on the electroreduction of azo compounds , 1965 .

[61]  Hui Huang,et al.  Ag3PO4/SnO2 semiconductor nanocomposites with enhanced photocatalytic activity and stability , 2012 .

[62]  R. Turan,et al.  Current–voltage and capacitance–voltage characteristics of a Sn/Methylene Blue/p-Si Schottky diode , 2009 .

[63]  Yuhua Wang,et al.  Highly dispersive {001} facets-exposed nanocrystalline TiO2 on high quality graphene as a high performance photocatalyst , 2012 .