Experimental investigation and energy analysis of a solar-assisted fluidized-bed dryer including solar water heater and solar-powered infrared lamp for paddy grains drying

Abstract During drying process of paddy grains, as one of the major operations of rice milling process, a considerable amount of fossil fuel is consumed. The air pollutants emitted by combustion of fossil fuels are great threat to human health which strongly contribute to environmental problems. In the present study, to reduce the share of fossil fuels in drying process of paddy grains, a new type solar-assisted fluidized-bed dryer was used with the ability of thermal energy recovery. The drying system mainly consisted of a solar water heater, a solar-powered infrared lamp, a gas water heater, and a desiccant wheel. Two general conditions were considered for conducting the experiments: Natural gas drying (NGD), and Solar-assisted drying (SAD). The results of evaluations showed that the highest total energy consumption of the dryer was equal to 1.163 kWh which was obtained in NGD test mode, while the lowest amount of total energy consumption was obtained in SAD mode which was 0.314 kWh. The specific energy consumption of the drying system in SAD and NGD modes was in the range of 8.30–22.12 and 16.73–32.62 kWh/kg water evaporated, respectively. The highest value of solar fraction index was equal to 0.538 which was obtained at drying air temperature of 45 °C, drying air velocity of 8 m/s, while the lowest solar fraction value (0.179) was attributed to drying air temperature of 35 °C and air velocity of 7 m/s. Although applying the infrared lamp caused the solar energy fraction to increase to 0.741, however, the use of infrared lamp in the fluidizing chamber did not have a significant effect on the dehydration rate of the product. At two levels of the applied drying temperatures (35 °C and 45 °C), the required thermal energy during the drying process was completely supplied only by solar energy and without the need for fossil fuel.

[1]  R. K. Goyal,et al.  Effects of pretreatments and drying air temperature on drying behaviour of peach slice , 2007 .

[2]  S. Kakaç,et al.  Heat Exchangers: Selection, Rating, and Thermal Design , 1997 .

[3]  A. Balbay,et al.  Microwave Drying Kinetics of a Thin-Layer Liquorice Root , 2012 .

[4]  C. Si,et al.  Experimental and numerical simulation of drying of lignite in a microwave-assisted fluidized bed , 2019, Fuel.

[5]  Zhijian Liu,et al.  Design of high-performance water-in-glass evacuated tube solar water heaters by a high-throughput screening based on machine learning: A combined modeling and experimental study , 2017 .

[6]  Mohammad Reza Alizadeh,et al.  Design, development and performance evaluation of an automatic control system for rice whitening machine based on computer vision and fuzzy logic , 2016, Comput. Electron. Agric..

[7]  S. B. Thombre,et al.  Development of a new type of solar dryer: Its mathematical modelling and experimental evaluation , 2008 .

[8]  E. Akpinar,et al.  Mathematical modelling of a thin layer drying of apricots in a solar energized rotary dryer , 2004 .

[9]  Pankaj Khatak,et al.  Progress in solar dryers for drying various commodities , 2016 .

[10]  V. P. Chandramohan,et al.  Design, Development and Performance of Indirect Type Solar Dryer for Banana Drying ☆ , 2017 .

[11]  Masud Behnia,et al.  Water-in-Glass Evacuated Tube Solar Water Heaters , 2004 .

[12]  M. H. Komarizadeh,et al.  Effects of crop-machine variables on paddy grain damage during handling with an inclined screw auger , 2010 .

[13]  Kamaruzzaman Sopian,et al.  Performance and economic analyses on solar-assisted heat pump fluidised bed dryer integrated with biomass furnace for rice drying , 2018, Solar Energy.

[14]  Mojtaba Tohidi,et al.  Energy and quality aspects for fixed deep bed drying of paddy , 2017 .

[15]  A. Benseddik,et al.  Mathematical empirical models of thin-layer airflow drying kinetics of pumpkin slice , 2018, Engineering in Agriculture, Environment and Food.

[16]  Somchart Soponronnarit,et al.  Cross-Flow Fluidized Bed Paddy Dryer: Prototype and Commercialization , 1995 .

[17]  S. Chamoli,et al.  Experimental investigation of a packed-bed thermal energy storage system fitted with perforated cylindrical elements , 2019, Heat and Mass Transfer.

[18]  Mostafa M. Azam,et al.  Energy analysis of hybrid solar tunnel dryer with PV system and solar collector for drying mint (MenthaViridis) , 2018 .

[19]  A. Amini,et al.  Analysis of drying of melon in a solar-heat recovery assisted infrared dryer , 2016 .

[20]  Gagan Deep Singh,et al.  Drying and rehydration characteristics of water chestnut (Trapa natans) as a function of drying air temperature , 2008 .

[21]  Somchart Soponronnarit,et al.  Integration of a rotary desiccant wheel into a hot-air drying system: Drying performance and product quality studies , 2007 .

[22]  S. Chamoli,et al.  Experimental investigation on thermal performance and fluid flow characteristics in heat exchanger tube with solid hollow circular disk inserts , 2016 .

[23]  L. S. Leung,et al.  Pneumatic Conveying of Solids: A Theoretical and Practical Approach , 1993 .

[24]  R. Chayjan,et al.  Modeling of moisture diffusivity, activation energy and specific energy consumption of high moisture corn in a fixed and fluidized bed convective dryer , 2011 .

[25]  A. Yadav,et al.  Comparative performance of desiccant wheel with effective and ordinary regeneration sector using mathematical model , 2014 .

[26]  O. Alves-Filho,et al.  Influence of drying conditions on the moisture diffusion andfluidization quality during multi-stage fluidized bed dryingof bovine intestine for pet food , 2013 .

[27]  F. Perera.  Pollution from Fossil-Fuel Combustion is the Leading Environmental Threat to Global Pediatric Health and Equity: Solutions Exist , 2017, International journal of environmental research and public health.

[28]  D. Ganji,et al.  Analytical thermal analysis of air-heating solar collectors , 2013 .

[29]  S. Chamoli,et al.  Multi-objective shape optimization of a heat exchanger tube fitted with compound inserts , 2017 .

[30]  A. Durmuş,et al.  Thin layer solar drying and mathematical modeling of mulberry , 2009 .

[31]  Somchart Soponronnarit,et al.  Fluidised-Bed Paddy Drying , 1999 .

[32]  Ho-Hsien Chen,et al.  A study of the drying effect on lemon slices using a closed-type solar dryer , 2005 .

[33]  T. K. Goswami,et al.  Modelling and optimization of drying variables in thin layer drying of parboiled paddy , 2007 .

[34]  S. Chamoli,et al.  A review on technical improvements, economic feasibility and world scenario of solar water heating system , 2017 .

[35]  W. Beckman,et al.  Solar Engineering of Thermal Processes , 1985 .

[36]  Seyfi Şevik,et al.  Experimental investigation of a new design solar-heat pump dryer under the different climatic conditions and drying behavior of selected products , 2014 .

[37]  M. Bargach,et al.  Experimental and theoretical analysis of drying grapes under an indirect solar dryer and in open sun , 2018, Innovative Food Science & Emerging Technologies.

[38]  S. Chamoli,et al.  Experimental Investigation on Thermo-Hydraulic Performance of Heat Exchanger Tube with Solid and Perforated Circular Disk Along with Twisted Tape Insert , 2019 .

[39]  J. Paulo. Davim,et al.  Design of Experiments in Production Engineering , 2016 .

[40]  K. Sopian,et al.  Energy and exergy analyses of solar-assisted fluidized bed drying integrated with biomass furnace , 2017 .

[41]  Aymen El Khadraoui,et al.  Drying of red pepper slices in a solar greenhouse dryer and under open sun: Experimental and mathematical investigations , 2019, Innovative Food Science & Emerging Technologies.

[42]  İbrahim Doymaz,et al.  Effect of citric acid and blanching pre-treatments on drying and rehydration of Amasya red apples , 2010 .

[43]  Ekin Can Dolgun,et al.  Performance analysis of solar and solar-infrared dryer of mint and apple slices using energy-exergy methodology , 2019, Solar Energy.

[44]  A. Ghafoor,et al.  Study of the Drying Behavior and Performance Evaluation of Gas Fired Hybrid Solar Dryer , 2017 .

[45]  Ndukwu Macmanus Chinenye,et al.  Effect of Drying Temperature and Drying Air Velocity on the Drying Rate and Drying Constant of Cocoa Bean , 2009 .

[46]  S. Iniyan,et al.  Fluidized bed drying of some agro products – A review , 2016 .

[47]  M. Yahya,et al.  Performance Analysis of Solar Assisted Fluidized Bed Dryer Integrated Biomass Furnace with and without Heat Pump for Drying of Paddy , 2016 .

[48]  S. Chamoli,et al.  Thermal performance improvement of a solar air heater fitted with winglet vortex generators , 2018 .

[49]  Mohammad Reza Alizadeh,et al.  Energy consumption and rice milling quality upon drying paddy with a newly-designed horizontal rotary dryer , 2017 .

[50]  S. Chamoli,et al.  Performance assessment of heat transfer and friction characteristics of a packed bed heat storage system embedded with internal grooved cylinders , 2018 .

[51]  A. J. Mawson,et al.  Effects of Different Solar Drying Methods on Drying Time and Rice Grain Quality , 2011 .

[52]  Tara Quinn,et al.  Health and climate change: policy responses to protect public health , 2015, BDJ.

[53]  S. Nassiri,et al.  Energy Use Efficiency of Different Drying Methods for Two Rough Rice Cultivars , 2015 .

[54]  Kuppan Thulukkanam.  Heat Exchanger Design Handbook , 2013 .

[55]  Saeid Minaei,et al.  Performance of a recirculating dryer equipped with a desiccant wheel , 2016 .

[56]  S. Murugavelh,et al.  Thin layer drying kinetics and exergy analysis of turmeric (Curcuma longa) in a mixed mode forced convection solar tunnel dryer , 2018, Renewable Energy.

[57]  M. Mahrouz,et al.  Drying characteristics and kinetics solar drying of Moroccan rosemary leaves , 2017 .

[58]  A. Keyhani,et al.  Effect of temperature, relative humidity and air velocity on drying kinetics and drying rate of basil leaves. , 2011 .

[59]  Mortaza Aghbashlo,et al.  Thermodynamic analysis of fluidized bed drying of carrot cubes , 2010 .

[60]  S. Priya,et al.  A Review on Low-Grade Thermal Energy Harvesting: Materials, Methods and Devices , 2018, Materials.

[61]  Efstathios E. Michaelides,et al.  Alternative Energy Sources , 2012 .

[62]  A. Ziaforoughi,et al.  A salient reduction of energy consumption and drying time in a novel PV-solar collector-assisted intermittent infrared dryer , 2016 .

[63]  D. Andronoiu,et al.  Effect of different drying methods on moisture ratio and rehydration of pumpkin slices. , 2016, Food chemistry.

[64]  Mohamed A. Eltawil,et al.  Solar PV powered mixed-mode tunnel dryer for drying potato chips , 2018 .

[65]  Characteristics of fluidisation behaviour in a pressurised bubbling fluidised bed , 2013 .

[66]  Ali Zomorodian,et al.  A Study of the Effect of Solar Drying System on Rice Quality , 2009 .

[67]  Ranchan Chauhan,et al.  Experimental investigation of the performance of a novel solar dryer for drying medicinal plants in Western Himalayan region , 2019, Solar Energy.

[68]  Mortaza Aghbashlo,et al.  Influence of drying conditions on the effective moisture diffusivity, energy of activation and energy consumption during the thin-layer drying of berberis fruit (Berberidaceae) , 2008 .

[69]  Bernadette K. McCabe,et al.  Investigation into thin layer drying rates and equilibrium moisture content of abattoir paunch waste , 2017, Renewable Energy.