Study of human–seat interface pressure distribution under vertical vibration

Abstract The influence of whole-body vertical vibration on the dynamic human–seat interface pressure is investigated using a flexible grid of pressure sensors. The ischium pressure and the overall pressure distribution at the human–seat interface are evaluated as functions of the magnitude and frequency of vibration excitation, and seated posture and height. The dynamic pressure at the seat surface is measured under sinusoidal vertical vibration of different magnitudes in the 1–10 Hz frequency range. Two methods based on ischium pressure and ischium force are proposed to study the influence of seat height, posture and characteristics of vibration. The results of the study reveal that the amplitude of dynamic pressure component increases with an increase in the excitation amplitude in almost entire frequency range considered in this study. The dynamic components of both the ischium pressure and the ischium force reveal peaks in the 4 to 5 Hz frequency band, the range of primary resonant frequency of the seated human body in the vertical mode. The mean values of the dynamic ischium pressure and the ischium force remain constant, irrespective of the excitation frequency and amplitude. The magnitudes of mean pressure and force at the human–seat interface, however, are dependent upon the seat height and the subject's posture. The inter-subject variability of the static ischium pressure and effective contact area are presented as functions of the subject weight and subject weight-to-height ratio. It was found that heavy subjects tend to induce low ischium pressure as a result of increased effective contact area. Relevance to industry Pressure distribution at the human–seat interface has been found to be an important factor affecting the seating comfort and work efficiency of various workers. The study of human–seat interface pressure distribution under vibration is specifically critical to the comfort, work efficiency and health of vehicle drivers, who are regularly exposed to vibration. The results reported in this paper will be useful to study dynamic response of the interface pressure and design vehicle seats.